Test Report

FCC ID: WAP2001

Test Report

Download: PDF
FCCID_2607232

A TUVRheinland® Precisely Right. Produkte Products Priifbericht — Nr.: 19660174 001 Seite 1 von 26 Test Report No.: Page 1 of 26 Auftraggeber: Cypress Semiconductor Client: 198 Champion Court San Jose, CA 95134 USA Tel: (408) 943 2600 Gegenstand der Priifung: EZ—BLE PRoC Module Test item: Bezeichnung: CYBLE—022001—00 Serien—Nr.: Engineering Sample Identification: Serial No. Wareneingangs—Nr.: 1803073245 Eingangsdatum: 07.04.2015 Receipt No.: Date of receipt: Priifort: . Refer Page 4 of 26 for test facilities Testing location: Priifgrundlage: FCC Part 15, Subpart C Test specification: ANSI C63.10—2009 Priifergebnis: Der Priifgegenstand entspricht oben genannter Priifgrundlage(n). Test Result: The test items passed the test specification(s). Priiflaboratorium: TUV Rheinland (India) Pvt. Ltd. Testing Laboratory: 82/A, 3rd Main, West Wing, Electronic City Phase 1 Hosur Road, Bangalore — 560 100. India FCC Registration No.: 176555; IC Assigned Code: 3466E gepriift / fested by: kontrolliert / reviewed by: \—/’ 10.04.2015 Shrikanth S Naik S éy/ 13.04.2015 Raghavendra Kulkarni ®TUV, TUEV and TUV are registered trademarks. Any use or application requires prior approval. Engineer Sr.Manager y Datum Name/Stellung Unterschrift Datum Name/Stellung Unterschrift Date Name/Position Signature Date Name/Position Signature Sonstiges /Other Aspects: FCC ID : WAP2001 Abklirzungen: P(ass) = entspricht Priifgrundlage Abbreviations: P(ass) = passed F(ail) = entspricht nicht Priifgrundlage F(ail) = failed N/A = nicht anwendbar N/A = notapplicable N/T = nicht getestet N/T = not tested Dieser Priifbericht bezieht sich nur auf das 0.g. Priifmuster und darf ohne Genehmigung der Priifstelle nicht auszugsweise vervielfaltigt werden. Dieser Bericht berechtigt nicht zur Verwendung eines Priifzeichens. This test report relates to the a. m. test sample. Without permission of the test center this test report is not permitted to be duplicated in extracts. This test report does not entitle to carry any safety mark on this or similar products. TUV Rheinland India Pvt. Ltd. 82/A, 3rd Main, West Wing Electronic City Phase 1, Hosur Road, Bangalore—560100, India Tel.: +9180 6723 3500 : Fax: +9180 6723 3542 + Web: www.tuv.com

www.tuv.com Test Result Summary Clause Test Item Result FCC 15.247(b) (3) Maximum Conducted Peak Output Power Pass FCC 15.247(a) (2) DTS (6dB) Bandwidth Pass FCC 15.247(e) Power Spectral Density Pass Emission in the non-restricted frequency bands FCC 15.247(d) Pass (Band-edge compliance) Spurious Radiated Emissions and Restricted FCC 15.209 / FCC 15.205 Pass Bands of Operation FCC 15.207 Conducted Emissions on A.C Power lines Pass Note: Conducted measurements are done according to the procedure given in KDB No. 558074 D01 DTS Meas Guidance v03r02 Test Report No.: 19660174 001 Date: 10.04.2015 Page 2 of 26

www.tuv.com Content List of Test and Measurement Instruments ............................................................................... 4 General Product Information Product Function and Intended Use .......................................................................................................... 5 Ratings and System Details........................................................................................................................ 5 Test Set-up and Operation Mode .................................................................................................... 7 Principle of Configuration Selection ......................................................................................................... 7 Test Operation and Test Software ............................................................................................................. 7 Special Accessories and Auxiliary Equipment ......................................................................................... 7 Countermeasures to achieve EMC Compliance ....................................................................................... 7 Test Methodology .................................................................................................................................. 8 Radiated Emission Test .............................................................................................................................. 8 Conducted Emission Test on A.C. mains line .......................................................................................... 8 Test Results ........................................................................................................................................................................... 9 Maximum Conducted Peak Output Power Section 15.247(b) (3) ..................... 9 Power Spectral Density Section 15.247(e) ........................ 12 6 dB Bandwidth Section 15.247(a) (2) ................... 15 Band-edge Compliance Section 15.247(d) ........................ 17 Spurious Radiated Emissions and Restricted Bands of Operation Section 15.209 and 15.205 ......... 21 Conducted Emission Test on A.C. Power Line Section 15.207............................. 24 Appendix 1: Test Setup Photo Appendix 2: EUT External Photo Appendix 3: EUT Internal Photo Appendix 4: FCC Label and Label Location Appendix 5: Block Diagram Appendix 6: Specification of EUT Appendix 7: Schematic Diagram Appendix 8: Bill of Material Appendix 9: User Manual Appendix 10: Maximum Permissible Exposure Calculation Test Report No.: 19660174 001 Date: 10.04.2015 Page 3 of 26

www.tuv.com List of Test and Measurement Instruments Testing Facilities 1) TÜV Rheinland (India) Pvt. Ltd. 82/A, 3rd Main, West Wing, Electronic City, West Phase, Hosur Road Bangalore – 560 100. Model Serial Calibration Used for Test Equipment Manufacturer Periodicity Name Number Due Date Items Antenna port Agilent Spectrum Analyser E4407B US41192772 27.03.2016 Yearly conducted Technologies measurements 2) TUV Rheinland (India) Private Limited 108 , Beside ISBR Business School, Electronic city Phase I Bangalore - 560 100. Model Serial Calibration Used for Equipment Manufacturer Periodicity Name Number Due Date Test Items Rohde & EMI Test Receiver ESU 40 100288 20.06.2015 Yearly Schwarz Broadband ALX-4000- Frankonia ALX-4000 22.06.2015 Yearly Antenna 806 Active Loop Spurious Frankonia LAX-10 LAX-10-800 22.06.2015 Yearly Antenna Radiated Horn Antenna Frankonia HAX-18 HAX18-802 22.06.2015 Yearly Emissions Double-Ridged Waveguide Horn ETS 116706 00107323 22.06.2015 Yearly Antenna Anechoic Chamber Frankonia - - - - Rohde & Conducted LISN ENV216 100022 12.09.2015 Yearly Schwarz Emission on Rohde & AC power EMI Receiver ESR7 101133 19.11.2015 Yearly Schwarz lines Test Report No.: 19660174 001 Date: 10.04.2015 Page 4 of 26

www.tuv.com General Product Information Product Function and Intended Use The EZ_BLE PRoC module comes with a 32 bit, ARM Cortex-M0 microcontroller with a variety of analog and digital peripherals, a BLE radio and link layer along with all the associated circuitry and built-in Antenna. The module enables customers to develop a quick turnaround Bluetooth Low Energy solution for their products. Ratings and System Details Operating Frequency 2400 – 2483.5MHz No. of channel 40 Channel Spacing 2 MHz Modulation GFSK Transmit Power (ERP) 2.16 dBm / 1.64437mW Data Rate 1 Mbps Antenna Type Chip antenna Number of antenna One Antenna Gain 0.5dBi Supply Voltage 1.9 V to 5.5V (3.3V nominal from test jig) Dimension 10 mm x 10 mm Environmental Operating: -40 ⁰C to +85 ⁰C Test Conditions: Voltage: 5VDC from USB. Environmental conditions: Temperature: +23 º C RH: 62% Test Report No.: 19660174 001 Date: 10.04.2015 Page 5 of 26

www.tuv.com Operational Description For testing purpose, the EZ-BLE module is supplied power through a test jig which also has LEDs and a button to change the test modes. Upon power up the module is in idle mode, pressing the button each time takes the user through all the test modes. The first three modes have receiver ON at low mid and high channels. The next three modes have packet transmission as at low mid and high channels. Block Diagram Test Report No.: 19660174 001 Date: 10.04.2015 Page 6 of 26

www.tuv.com Test Set-up and Operation Mode Principle of Configuration Selection Transmission was enabled with highest possible duty cycle on low, mid and high channel. Test Operation and Test Software A button on the base board was used to enable the transmission at maximum defined power level and to select channels low, mid and high in 2.4 GHz band on the EUT for the tests in this report. Special Accessories and Auxiliary Equipment - None Countermeasures to achieve EMC Compliance - None Table of frequencies Frequency Band Frequency (MHz) (MHz) 2402 2404 2406 ; : : 2440 2400 – 2483.5 2442 2444 ; : : 2478 2480 Test Report No.: 19660174 001 Date: 10.04.2015 Page 7 of 26

www.tuv.com Test Methodology Radiated Emission Test The radiated emission measurement was performed according to the procedures in ANSI C63.10-2009. The equipment under test (EUT) was placed at the middle of the 80 cm high turntable, and the EUT is 3 meters far from the measuring antenna. The turntable was rotated 360ﾟ for obtaining the maximum emission. The height of the measuring antennas was scanned between 1m and 4m, and the antenna rotated to repeat the measurements for both the horizontal and vertical antenna polarizations. Repeat the measurement steps until the maximum emissions were obtained. The measurement above 1000MHz was performed by horn antenna. The measurement below 30MHz was performed by loop antenna. The EUT was rotated around the X-, Y-, and Z-Axis and the results from worst case axis are recorded. Semi-anechoic Chamber 3m Pre-Amplifier Measuring Receiver / EUT Spectrum Analyzer Turntable Ground Plane Conducted Emission Test on A.C. mains line The equipment under test (EUT) was placed on a wooden table 80cm above the ground plane, the LISN was place 80cm away from the EUT. The test was performed in accordance with ANSI C63.10: 2009, with the following: an initial measurement was performed in peak and average detection mode on the live and neutral lines. The pre-scan was performed by peak detection on both live and neutral conductors. Any emissions recorded within 20dB of the relevant limit line were re-measured using quasi-peak and average detections, the 6 worst cases was recorded in the table of results. Screened Room 0.8m Mains Input EUT 50Ω Output EMI Wooden Table Receiver 0.8m LISN Ground Plane Test Report No.: 19660174 001 Date: 10.04.2015 Page 8 of 26

www.tuv.com Test Results Maximum Conducted Peak Output Power Section 15.247(b) (3) Result Pass Test Specification FCC Part 15 Subpart C Measurement Bandwidth (RBW) 1 MHz Detector Peak Requirement <1 watt (30dBm). Test Method: EUT Spectrum Analyzer Cable Loss: 1.6dB (Included in the test results) Test Result: Frequency Total Output power Limit (MHz) (dBm) (dBm) 2402 2.16 30.00 2440 1.70 30.00 2480 1.53 30.00 Test Report No.: 19660174 001 Date: 10.04.2015 Page 9 of 26

www.tuv.com Channel Frequency: 2402 MHz Channel Frequency: 2440 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 10 of 26

www.tuv.com Channel Frequency: 2480 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 11 of 26

www.tuv.com Power Spectral Density Section 15.247(e) Result Pass Test Specification FCC Part 15 Subpart C Detector Function Peak Requirement For digitally modulated systems, the power spectral density conducted from the intentional radiator to the antenna shall not be greater than 8 dBm. Test Method: EUT Spectrum Analyzer Cable Loss: 1.6 dB (Included in the test results) Test Result: Frequency Total PSD Limit (MHz) (dBm) (dBm) 2402 1.64 8 2440 1.16 8 2480 1.00 8 Test Report No.: 19660174 001 Date: 10.04.2015 Page 12 of 26

www.tuv.com Channel Frequency: 2402 MHz Channel Frequency: 2440 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 13 of 26

www.tuv.com Channel Frequency: 2480 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 14 of 26

www.tuv.com 6 dB Bandwidth Section 15.247(a) (2) Result Pass Test Specification FCC Part 15 Subpart C Requirement The minimum 6 dB bandwidth shall be at least 500 kHz. Test Method: EUT Spectrum Analyzer Cable Loss: 1.6dB (Included in the test results) Test Result: Frequency 6 dB Bandwidth OBW (MHz) (kHz) (MHz) 2402 743.74 1.108 2440 746.57 1.106 2480 748.68 1.109 6dB BW and OBW: Channel frequency: 2402 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 15 of 26

www.tuv.com 6dB BW and OBW: Channel frequency: 2440 MHz 6dB BW and OBW: Channel frequency: 2480 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 16 of 26

www.tuv.com Emission in the non-restricted frequency bands Section 15.247(d) Result Pass Test Specification FCC Part 15 Subpart C Detector Function Peak Requirement If the peak output power procedure is used to measure the fundamental emission power to demonstrate compliance to 15.247(b)(3) requirements, then the peak conducted output power measured within any 100 kHz outside the authorized frequency band shall be attenuated by at least 20 dB relative to the maximum measured in-band peak PSD level. If the average output power procedure is used to measure the fundamental emission power to demonstrate compliance to 15.247(b)(3) requirements, then the power in any 100 kHz outside of the authorized frequency band shall be attenuated by at least 30 dB relative to the maximum measured in- band average PSD level. Test Method: EUT Spectrum Analyzer Cable Loss: 1.6dB (Included in the test results) Test Result: Value at Band Edge Reference Channel Frequency Band Edge Band Edge Difference Limit PSD (MHz) Frequency Value ‘B’ in A~B (dB) Level ‘A’ (MHz) (dBm) (dB) in (dBm) 2402 2400 1.64 -34.31 35.95 >20.00 2480 2483.5 1.00 -40.93 41.93 >20.00 Note: The reference PSD values are taken from the plots reported under the Power spectral Density Section 15.247(e). Test Report No.: 19660174 001 Date: 10.04.2015 Page 17 of 26

www.tuv.com Channel frequency: 2402 MHz Channel frequency: 2480 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 18 of 26

www.tuv.com Conducted Spurious Emission Channel frequency: 2402 MHz Channel frequency: 2440 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 19 of 26

www.tuv.com Channel frequency: 2480 MHz Test Report No.: 19660174 001 Date: 10.04.2015 Page 20 of 26

www.tuv.com Spurious Radiated Emissions and Restricted Bands of Operation Section 15.209 and 15.205 Result Pass Test Specification FCC Part 15 Subpart C Test Method ANSI C63.10-2009 Measurement Location Semi Anechoic Chamber Measuring Distance 3m Detection QP for frequency below 1GHz, Peak and Average for frequency above 1GHz Requirement As per the limits mentioned in the bellow table Limit for Radiated Emission of Section 15.209: Frequency Field strength Field strength Distance of (MHz) (V/m) (dBV/m) Measurement (m) 0.009 – 0.490 2400/F(kHz) 48.50 – 13.80 300* 0.490 – 1.705 24000/F(kHz) 33.80 – 23.00 30* 1.705 -30 30 29.54 30* 30-88 100 40.0 3 88-216 150 43.5 3 216-960 200 46.0 3 Above 960 500 54.0 3 Remark: * the limit shows in the table above of frequency range 0.009 – 0.490, 0.490 – 1.705 MHz and 1.705-30MHz is at 300 meter, 30 meter and 30 meter range respectively, which corresponds to 88, 50 – 53.80, 53.80 – 43.00 and 49.5dBμV/m at 3m range by extrapolation calculation and the measurement of loop antenna. The emission limits shown in the above table are based on measurements employing a CISPR quasi-peak detector except for the frequency bands 9–90 kHz, 110–490 kHz and above 1000 MHz Radiated emission limits in these three bands are based on measurements employing an average detector. Test Report No.: 19660174 001 Date: 10.04.2015 Page 21 of 26

www.tuv.com Test results: For frequency range 9 KHz to 1 GHz Field Strength Antenna Frequency Limit Margin Level Polarization (MHz) (dBµV/m) (dB) (dBµV/m) 96.73 32.33 43.5 -11.17 Vertical 129.61 28.75 43.5 -14.75 143.1 26.01 43.5 -17.49 Horizontal 310.23 29.47 46 -16.53 Frequencies above 1GHz Fundamental Frequency of Antenna Field Strength Limit Margin Frequency Emission Polarization (dBµV/m) (dBµV/m) (dB) (MHz) (MHz) 2390 (Pk) 51.97 74 -22.03 2390 (Av) 28.06 54 -25.94 2402 (Pk) 88.80 * - V 2402 (Av) 85.19 * - 4804 (Pk) 50.46 74 -23.54 4804 (Av) 37.67 54 -16.33 2402 2390 (Pk) 51.46 74 -22.54 2390 (Av) 27.89 54 -26.11 2402 (Pk) 91.75 * - H 2402 (Av) 87.46 * - 4804 (Pk) 50.42 74 -23.58 4804 (Av) 37.97 54 -16.03 2440 (Pk) 88.45 * - 2440 (Av) 84.75 * - V 4880 (Pk) 50.54 74 -23.46 4880 (Av) 38.14 54 -15.86 2440 2440 (Pk) 88.19 * - 2440 (Av) 84.83 * - H 4880 (Pk) 51.15 74 -22.85 4880 (Av) 39.05 54 -14.95 2480 (Pk) 86.93 * - 2480 (Av) 83.37 * - 2483.5 (Pk) 60.61 74 -13.39 V 2480 2483.5 (Av) 28.53 54 -25.47 4960 (Pk) 51.31 74 -22.69 4960 (Av) 38.25 54 -15.75 Test Report No.: 19660174 001 Date: 10.04.2015 Page 22 of 26

www.tuv.com 2480 (Pk) 90.18 * - 2480 (Av) 85.55 * - H 2483.5 (Pk) 63.11 74 -10.89 2483.5 (Av) 29.04 54 -24.96 4960 (Pk) 51.19 74 -22.81 4960 (Av) 39.05 54 -14.95 Pk -> Peak Detector Av -> Average Detector *- -> Fundamental frequency Test Report No.: 19660174 001 Date: 10.04.2015 Page 23 of 26

www.tuv.com Conducted Emission Test on A.C. Power Line Section 15.207 Result Pass Test Specification : FCC Part 15 Section 15.207 Test Method : ANSI C63.10-2009 Testing Location : Screened room Measurement Bandwidth : 9kHz Frequency Range : 150kHz – 30MHz Supply Voltage : 120VAC,60Hz Limit of section 15.207 Frequency of Emission QP Limit AV Limit (MHz) (dBµV) (dBµV/m) 0.15 – 0.5 66 – 56* 56 – 46* 0.5 – 5 56 46 5 – 30 60 50 * Decreases with the logarithm of the frequency Test Report No.: 19660174 001 Date: 10.04.2015 Page 24 of 26

www.tuv.com Test Results: Mode: Line Test Report No.: 19660174 001 Date: 10.04.2015 Page 25 of 26

www.tuv.com Mode: Neutral ***END OF TEST REPORT*** Test Report No.: 19660174 001 Date: 10.04.2015 Page 26 of 26


Document Created: 2019-10-01 07:52:37
Document Modified: 2019-10-01 07:52:37
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC