test report part 2

FCC ID: TJ7M16

Test Report

Download: PDF
FCCID_3132427

Report No.: TCT160801E002 6.10. Conducted Spurious Emission Measurement 6.10.1. Test Specification Test Requirement: FCC Part15 C Section 15.247 (d) Test Method: ANSI C63.10:2013 and DA00-705 In any 100 kHz bandwidth outside the intentional radiation frequency band, the radio frequency power shall be at least 20 dB below the highest level of the Limit: radiated power. In addition, radiated emissions which fall in the restricted bands must also comply with the radiated emission limits. Test Setup: Test Mode: Transmitting mode with modulation 1. The testing follows the guidelines in Spurious RF Conducted Emissions of FCC Public Notice DA 00-705 Measurement Guidelines 2. The RF output of EUT was connected to the spectrum analyzer by RF cable and attenuator. The path loss was compensated to the results for each measurement. 3. Set to the maximum power setting and enable the Test Procedure: EUT transmit continuously. 4. Set RBW = 100 kHz, VBW = 300kHz, scan up through 10th harmonic. All harmonics / spurs must be at least 20 dB down from the highest emission level within the authorized band as measured with a 100 kHz RBW. 5. Measure and record the results in the test report. 6. The RF fundamental frequency should be excluded against the limit line in the operating frequency band. Test Result: PASS 6.10.2. Test Instruments RF Test Room Equipment Manufacturer Model Serial Number Calibration Due Spectrum Analyzer Agilent N9020A MY49100060 Sep. 12, 2016 RF cable TCT RE-06 N/A Sep. 12, 2016 Antenna Connector TCT RFC-01 N/A Sep. 12, 2016 Note: The calibration interval of the above test instruments is 12 months and the calibrations are traceable to international system unit (SI). Page 41 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 6.10.3. Test Data GFSK mode Lowest Channel Middle Channel Highest Channel Page 42 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Pi/4DQPSK mode Lowest Channel Middle Channel Highest Channel Page 43 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 8DPSK mode Lowest Channel Middle Channel Highest Channel Page 44 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 6.11. Radiated Spurious Emission Measurement 6.11.1. Test Specification Test Requirement: FCC Part15 C Section 15.209 Test Method: ANSI C63.4: 2014 and ANSI C63.10: 2013 Frequency Range: 9 kHz to 25 GHz Measurement Distance: 3m Antenna Polarization: Horizontal & Vertical Frequency Detector RBW VBW Remark 9kHz- 150kHz Quasi-peak 200Hz 1kHz Quasi-peak Value 150kHz- Quasi-peak 9kHz 30kHz Quasi-peak Value Receiver Setup: 30MHz 30MHz-1GHz Quasi-peak 100KHz 300KHz Quasi-peak Value Peak 1MHz 3MHz Peak Value Above 1GHz Peak 1MHz 10Hz Average Value Field Strength Measurement Frequency (microvolts/meter) Distance (meters) 0.009-0.490 2400/F(KHz) 300 0.490-1.705 24000/F(KHz) 30 1.705-30 30 30 30-88 100 3 88-216 150 3 Limit: 216-960 200 3 Above 960 500 3 Measurement Field Strength Frequency Distance Detector (microvolts/meter) (meters) 500 3 Average Above 1GHz 5000 3 Peak For radiated emissions below 30MHz Test setup: 30MHz to 1GHz Page 45 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Above 1GHz Test Mode: Transmitting mode with modulation 1. The testing follows the guidelines in Spurious Radiated Emissions of FCC Public Notice DA 00-705 Measurement Guidelines. 2. For the radiated emission test below 1GHz: The EUT was placed on a turntable with 1.5 meter above ground. The EUT was set 3 meters from the interference receiving antenna, which was mounted on the top of a variable height antenna tower. The EUT was arranged to its worst case and then tune the antenna tower (from 1 m to 4 m) and turntable (from 0 degree to 360 degrees) to find the maximum Test Procedure: reading. A pre-amp and a high PASS filter are used for the test in order to get better signal level. For the radiated emission test above 1GHz: Place the measurement antenna on a turntable with 1.5 meter above ground, which is away from each area of the EUT determined to be a source of emissions at the specified measurement distance, while keeping the measurement antenna aimed at the source of emissions at each frequency of significant emissions, with polarization oriented for maximum response. The measurement antenna may have to be higher or lower than the EUT, Page 46 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 depending on the radiation pattern of the emission and staying aimed at the emission source for receiving the maximum signal. The final measurement antenna elevation shall be that which maximizes the emissions. The measurement antenna elevation for maximum emissions shall be restricted to a range of heights of from 1 m to 4 m above the ground or reference ground plane. 3. Set to the maximum power setting and enable the EUT transmit continuously. 4. Use the following spectrum analyzer settings: (1) Span shall wide enough to fully capture the emission being measured; (2) Set RBW=100 kHz for f < 1 GHz, RBW=1MHz for f>1GHz ; VBW≥RBW; Sweep = auto; Detector function = peak; Trace = max hold for peak (3) For average measurement: use duty cycle correction factor method per 15.35(c). Duty cycle = On time/100 milliseconds On time =N1*L1+N2*L2+...+Nn-1*LNn-1+Nn*Ln Where N1 is number of type 1 pulses, L1 is length of type 1 pulses, etc. Average Emission Level = Peak Emission Level + 20*log(Duty cycle) Corrected Reading: Antenna Factor + Cable Loss + Read Level - Preamp Factor = Level Test results: PASS Page 47 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 6.11.2. Test Instruments Radiated Emission Test Site (966) Name of Serial Manufacturer Model Calibration Due Equipment Number ROHDE&SCHW ESPI Test Receiver ESVD 100008 Sep. 11, 2016 ARZ ROHDE&SCHW Spectrum Analyzer FSEM 848597/001 Sep. 11, 2016 ARZ Spectrum Analyzer Agilent N9020A MY49100060 Sep. 12, 2016 EM Electronics Pre-amplifier Corporation EM30265 07032613 Sep. 11, 2016 CO.,LTD Pre-amplifier HP 8447D 2727A05017 Sep. 11, 2016 Loop antenna ZHINAN ZN30900A 12024 Sep. 13, 2016 Broadband Antenna Schwarzbeck VULB9163 340 Sep. 13, 2016 Horn Antenna Schwarzbeck BBHA 9120D 631 Sep. 13, 2016 Horn Antenna Schwarzbeck BBHA 9170 373 Sep. 13, 2016 Antenna Mast CCS CC-A-4M N/A N/A Coax cable TCT RE-low-01 N/A Sep. 11, 2016 Coax cable TCT RE-high-02 N/A Sep. 11, 2016 Coax cable TCT RE-low-03 N/A Sep. 11, 2016 Coax cable TCT RE-high-04 N/A Sep. 11, 2016 Shurple EMI Test Software EZ-EMC N/A N/A Technology Note: The calibration interval of the above test instruments is 12 months and the calibrations are traceable to international system unit (SI). Page 48 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 6.11.3. Test Data Duty cycle correction factor for average measurement DH5 on time (One Pulse) Plot on Channel 00 RBW 1 MHz Delta 2 [T1 ] * VBW 1 MHz -1.17 dB Ref 23 dBm * Att 20 dB SWT 4 ms 2.961538 ms 20 Offset 1 dB Marker 1 [T1 ] -59.29 dBm 416.666667 µs A 10 SGL 1 PK * CLRWR LVL 0 -10 -20 -30 3DB -40 -50 1 2 -60 -70 Center 2.402 GHz 400 µs/ Date: 9.AUG.2016 15:51:47 DH5 on time (Count Pulses) Plot on Channel 00 RBW 1 MHz Delta 2 [T1 ] * VBW1 MHz -0.01 dB Ref 23 dBm * Att 20 dB SWT 100 ms 2.083333 ms 20 Offset 1 dB Marker 1 [T1 ] 0.97 dBm 97.916667 ms A 10 SGL 1 PK * CLRWR 1 2 LVL 0 -10 -20 -30 3DB -40 -50 -60 -70 Center 2.402 GHz 10 ms/ Date: 9.AUG.2016 15:53:26 Note: 1. Worst case Duty cycle = on time/100 milliseconds = (2.962*26+2.083)/100= 0.7910 2. Worst case Duty cycle correction factor = 20*log (Duty cycle) = -2.04dB 3. 2DH5 has the highest duty cycle worst case and is reported. 4. The average levels were calculated from the peak level corrected with duty cycle correction factor (-2.04dB) derived from 20log (dwell time/100ms). This correction is only for signals that hop with the fundamental signal, such as band-edge and harmonic. Other spurious signals that are independent of the hopping signal would not use this correction. Page 49 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Please refer to following diagram for individual Below 1GHz Horizontal: Page 50 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Vertical: Note: 1.The low frequency, which started from 9KHz~30MHz, was pre-scanned and the result which was 20dB lower than the limit line per 15.31(o) was not reported 2. Measurements were conducted in all three channels (high, middle, low) and three modulation (GFSK, Pi/4 DQPSK, 8DPSK) and the worst case Mode (Middle channel and GFSK) was submitted only. Page 51 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Above 1GHz Modulation Type: GFSK Low channel: 2402 MHz Frequency Ant. Pol. Peak AV Correction Emission Level Peak limit AV limit Margin (MHz) H/V reading reading Factor Peak AV (dBµV) (dBuV) (dB/m) (dBµV/m) (dBµV/m) (dBµV/m) (dBµV/m) (dB) 2390 H 44.53 --- -8.23 36.30 --- 74 54 -17.70 4804 H 41.03 --- 6.59 47.62 --- 74 54 -6.38 7206 H 37.05 --- 12.87 49.92 --- 74 54 -4.08 --- H --- --- --- --- --- --- --- --- 2390 V 39.64 --- -8.23 31.41 --- 74 54 -22.59 4804 V 39.01 --- 6.59 45.60 --- 74 54 -8.40 7206 V 37.57 --- 12.87 50.44 --- 74 54 -3.56 --- V --- --- --- --- --- --- --- --- Middle channel: 2441 MHz Peak Frequency Ant. Pol. reading AV Correction Emission Level Peak limit AV limit Margin reading Factor Peak AV (MHz) H/V (dBµV) (dBµV) (dB/m) (dBµV/m) (dBµV/m) (dBµV/m) (dBµV/m) (dB) 4882 H 37.85 --- 7.01 44.86 --- 74 54 -9.14 7323 H 36.31 --- 13.21 49.52 --- 74 54 -4.48 --- H --- --- --- --- --- --- --- --- 4882 V 38.79 --- 7.01 45.80 --- 74 54 -8.20 7323 V 36.91 --- 13.21 50.12 --- 74 54 -3.88 --- V --- --- --- --- ---- --- --- --- High channel: 2480 MHz Peak Frequency Ant. Pol. reading AV Correction Emission Level Peak limit AV limit Margin reading Factor Peak AV (MHz) H/V (dBµV) (dBµV) (dB/m) (dBµV/m) (dBµV/m) (dBµV/m) (dBµV/m) (dB) 2483.5 H 41.97 --- -7.52 34.45 --- 74 54 -19.55 4960 H 40.69 --- 7.44 48.13 --- 74 54 -5.87 7440 H 35.29 --- 13.54 48.83 --- 74 54 -5.17 --- H --- --- --- --- --- --- --- --- 2483.5 V 40.20 --- -7.52 32.68 --- 74 54 -21.32 4960 V 41.55 --- 7.44 48.99 --- 74 54 -5.01 7440 V 37.74 --- 13.54 51.28 --- 74 54 -2.72 --- V --- --- --- --- --- --- --- --- Note: 1. Emission Level=Peak Reading + Correction Factor; Correction Factor= Antenna Factor + Cable loss – Pre-amplifier 2. Margin (dB) = Emission Level (Peak) (dBµV/m)-Average limit (dBµV/m) 3. The emission levels of other frequencies are very lower than the limit and not show in test report. 4. Measurements were conducted from 1 GHz to the 10th harmonic of highest fundamental frequency. 5. Data of measurement shown “---“in the above table mean that the reading of emissions is attenuated more than 20 dB below the limits or the field strength is too small to be measured. 6. Measurements were conducted in all three modulation (GFSK, Pi/4 DQPSK, 8DPSK), and the worst case Mode (GFSK) was submitted only. *****END OF REPORT***** Page 52 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Appendix A: Photographs of Test Setup Product: Bluetooth Headset Model: M16 Radiated Emission Page 53 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Conducted Emission Page 54 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Appendix B: Photographs of EUT Product: Bluetooth Headset Model: M16 External Photos Page 55 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Page 56 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Page 57 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Page 58 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Product: Bluetooth Headset Model: M16 Internal Photos Page 59 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Page 60 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Page 61 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Page 62 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com

Report No.: TCT160801E002 Page 63 of 63 Hotline: 400-6611-140 Tel: 86-755-27673339 Fax: 86-755-27673332 http://www.tct-lab.com


Document Created: 2016-09-02 18:08:01
Document Modified: 2016-09-02 18:08:01
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC