Test report

FCC ID: RUZ-068

Test Report

Download: PDF
FCCID_3946557

Report on the FCC Testing of the FCS, Outstation, Model: Tri-corr Touch Pro In accordance with FCC 47 CFR Part 15B Prepared for: HWM-Water Ltd Llantarnam Park Way Cwmbran NP44 3AW United Kingdom On Behalf of: Fluid Conservation Systems 502 TechneCenter Drive Suite B Milford OH 45150 USA FCC ID: RUZ-068 COMMERCIAL-IN-CONFIDENCE Document Number: 75940615-01 | Issue: 01 RESPONSIBLE FOR NAME DATE SIGNATURE Project Management Natalie Bennett 13 June 2018 Authorised Signatory Kim Archer 13 June 2018 Signatures in this approval box have checked this document in line with the requirements of TÜV SÜD Product Service document control rules. ENGINEERING STATEMENT The measurements shown in this report were made in accordance with the procedures described on test pages. All reported testing was carried out on a sample equipment to demonstrate limited compliance with FCC 47 CFR Part 15B. The sample tested was found to comply with the requirements defined in the applied rules. RESPONSIBLE FOR NAME DATE SIGNATURE Testing Sharif Sendagire 13 June 2018 FCC Accreditation 90987 Octagon House, Fareham Test Laboratory EXECUTIVE SUMMARY A sample of this product was tested and found to be compliant with FCC 47 CFR Part 15B: 2017 for the tests detailed in section 1.3. DISCLAIMER AND COPYRIGHT This non-binding report has been prepared by TÜV SÜD Product Service with all reasonable skill and care. The document is confidential to the potential Client and TÜV SÜD Product Service. No part of this document may be reproduced without the prior written approval of TÜV SÜD Product Service. © 2018 TÜV SÜD Product Service. ACCREDITATION Our UKAS Accreditation does not cover opinions and interpretations and any expressed are outside the scope of our UKAS Accreditation. Results of tests not covered by our UKAS Accreditation Schedule are marked NUA (Not UKAS Accredited). TÜV SÜD Product Service TUV SUD Ltd is a Phone: +44 (0) 1489 558100 TÜV SÜD Product Service is a trading name of TUV SUD Ltd TÜV SÜD Group Company Fax: +44 (0) 1489 558101 Octagon House Registered in Scotland at East Kilbride, www.tuv-sud.co.uk Concorde Way Glasgow G75 0QF, United Kingdom Fareham Registered number: SC215164 Hampshire PO15 5RL United Kingdom TÜV SÜD Product Service

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Contents 1 Report Summary .........................................................................................................................2 1.1 Report Modification Record...........................................................................................................2 1.2 Introduction....................................................................................................................................2 1.3 Brief Summary of Results .............................................................................................................3 1.4 Declaration of Build Status ............................................................................................................4 1.5 Product Information .......................................................................................................................5 1.6 Deviations from the Standard........................................................................................................5 1.7 EUT Modification Record ..............................................................................................................5 1.8 Test Location .................................................................................................................................5 2 Test Details ..................................................................................................................................6 2.1 Radiated Disturbance ....................................................................................................................6 3 Measurement Uncertainty ........................................................................................................20 COMMERCIAL-IN-CONFIDENCE Page 1 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE 1 Report Summary 1.1 Report Modification Record Alterations and additions to this report will be issued to the holders of each copy in the form of a complete document. Issue Description of Change Date of Issue 1 First Issue 13 June 2018 1.2 Introduction Applicant HWM Water Ltd Manufacturer Fluid Conservation Systems (FCS) Model Number(s) Tri-corr Touch Pro Serial Number(s) Not Serialised (75940615-TSR0004) Hardware Version(s) B Software Version(s) 105 Number of Samples Tested 1 Test Specification/Issue/Date FCC 47 CFR Part 15B: 2017 Order Number 75593 Date 18-October-2017 Date of Receipt of EUT 31-May-2018 Start of Test 07-June-2018 Finish of Test 07-June-2018 Name of Engineer(s) Sharif Sendagire Related Document(s) ANSI C63.4: 2014 COMMERCIAL-IN-CONFIDENCE Page 2 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE 1.3 Brief Summary of Results A brief summary of the tests carried out in accordance with FCC 47 CFR Part 15B is shown below. Section Specification Clause Test Description Result Comments/Base Standard Part 15B Configuration and Mode: Idle 2.1 15.109 Radiated Disturbance Pass ANSI C63.4: 2014 COMMERCIAL-IN-CONFIDENCE Page 3 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE 1.4 Declaration of Build Status COMMERCIAL-IN-CONFIDENCE Page 4 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE 1.5 Product Information 1.5.1 Technical Description Acoustic Correlator for determining the location of a leak in a length of a water pipe. 1.6 Deviations from the Standard No deviations from the applicable test standard were made during testing. 1.7 EUT Modification Record The table below details modifications made to the EUT during the test programme. The modifications incorporated during each test are recorded on the appropriate test pages. Date Modification Modification State Description of Modification still fitted to EUT Modification Fitted By Fitted Serial Number: Not Serialised (75940615-TSR0004) 0 As supplied by the customer Not Applicable Not Applicable Table 1 1.8 Test Location TÜV SÜD Product Service conducted the following tests at our Fareham Test Laboratory. Test Name Name of Engineer(s) Accreditation Configuration and Mode: Idle Radiated Disturbance Sharif Sendagire UKAS Table 2 Office Address: Octagon House Concorde Way Segensworth North Fareham Hampshire PO15 5RL United Kingdom COMMERCIAL-IN-CONFIDENCE Page 5 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE 2 Test Details 2.1 Radiated Disturbance 2.1.1 Specification Reference FCC 47 CFR Part 15B, Clause 15.109 2.1.2 Equipment Under Test and Modification State Tri-corr Touch Pro, S/N: Not Serialised (75940615-TSR0004) – Modification State 0 2.1.3 Date of Test 07-June-2018 2.1.4 Test Method The EUT was set up in a semi-anechoic chamber on a remotely controlled turntable and placed on a non-conductive in accordance with ANSI C63.4, clause 8. A pre-scan of the EUT emissions profile was made while varying the antenna-to-EUT azimuth and antenna-to-EUT polarisation using a peak detector; measurements were taken at a 3m distance. Using the pre-scan list of the highest emissions detected, their bearing and associated antenna polarisation, the EUT was then formally measured using a Quasi-Peak, Peak, Average detector as appropriate. The readings were maximised by adjusting the antenna height, polarisation and turntable azimuth, in accordance with the specification. 2.1.5 Environmental Conditions Ambient Temperature 21.4°C Relative Humidity 51.9% COMMERCIAL-IN-CONFIDENCE Page 6 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE 2.1.6 Test Results Results for Configuration and Mode : Idle. Performance assessment of the EUT made during this test: Pass Detailed results are shown below. Highest frequency generated or used within the EUT: 467.925 MHz Which necessitates an upper frequency test limit of: 3 GHz Figure 1 - 30 MHz to 1 GHz – Polarity: Horizontal, EUT Orientation: X COMMERCIAL-IN-CONFIDENCE Page 7 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 2 - 30 MHz to 1 GHz - Polarity: Vertical, EUT Orientation: X Frequency QP Level QP Limit QP Margin Angle(Deg) Height(m) Polarity (MHz) (dBuV/m) (dBuV/m) (dBuV/m) 179.987 40.5 43.5 -3.0 243 100 Vertical 179.995 39.0 43.5 -4.5 186 107 Vertical 629.957 40.9 46.4 -5.5 120 100 Vertical 742.454 41.8 46.4 -4.6 24 112 Horizontal Table 3 - 30 MHz to 1 GHz - EUT Orientation: X No other emissions were detected within 10 dB of the limit. COMMERCIAL-IN-CONFIDENCE Page 8 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 3 - 30 MHz to 1 GHz - Polarity: Horizontal, EUT Orientation: Y Figure 4 - 30 MHz to 1 GHz - Polarity: Vertical, EUT Orientation: Y COMMERCIAL-IN-CONFIDENCE Page 9 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Frequency QP Level QP Limit QP Margin Angle(Deg) Height(m) Polarity (MHz) (dBuV/m) (dBuV/m) (dBuV/m) 269.975 40.9 46.4 -5.5 335 110 Horizontal 539.976 42.2 46.4 -4.2 326 113 Vertical Table 4 - 30 MHz to 1 GHz - EUT Orientation: Y No other emissions were detected within 10 dB of the limit. COMMERCIAL-IN-CONFIDENCE Page 10 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 5 - 30 MHz to 1 GHz- Polarity: Horizontal, EUT Orientation: Z Figure 6 - 30 MHz to 1 GHz - Polarity: Vertical, EUT Orientation: Z COMMERCIAL-IN-CONFIDENCE Page 11 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Frequency QP Level QP Limit QP Margin Angle(Deg) Height(m) Polarity (MHz) (dBuV/m) (dBuV/m) (dBuV/m) 179.989 38.6 43.5 -5.0 282 108 Vertical 539.965 44.5 46.4 -1.9 243 100 Vertical 629.965 42.7 46.4 -3.7 272 123 Horizontal 742.464 41.4 46.4 -5.0 19 103 Horizontal Table 5 - 30 MHz to 1 GHz - EUT Orientation: Z No other emissions were detected within 10 dB of the limit. COMMERCIAL-IN-CONFIDENCE Page 12 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 7 - 1 GHz to 3 GHz – Polarity: Horizontal, EUT Orientation: X - Peak Figure 8 - 1 GHz to 3 GHz – Polarity: Horizontal, EUT Orientation: X - Average COMMERCIAL-IN-CONFIDENCE Page 13 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 9 - 1 GHz to 3 GHz – Polarity: Vertical, EUT Orientation: X - Peak Figure 10 - 1 GHz to 3 GHz – Polarity: Vertical, EUT Orientation: X - Average COMMERCIAL-IN-CONFIDENCE Page 14 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 11 - 1 GHz to 3 GHz – Polarity: Horizontal, EUT Orientation: Y - Peak Figure 12 - 1 GHz to 3 GHz – Polarity: Horizontal, EUT Orientation: Y - Average COMMERCIAL-IN-CONFIDENCE Page 15 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 13 - 1 GHz to 3 GHz – Polarity: Vertical, EUT Orientation: Y - Peak Figure 14 - 1 GHz to 3 GHz – Polarity: Vertical, EUT Orientation: Y - Average COMMERCIAL-IN-CONFIDENCE Page 16 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 15 - 1 GHz to 3 GHz – Polarity: Horizontal, EUT Orientation: Z - Peak Figure 16 - 1 GHz to 3 GHz – Polarity: Horizontal, EUT Orientation: Z - Average COMMERCIAL-IN-CONFIDENCE Page 17 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Figure 17 - 1 GHz to 3 GHz – Polarity: Vertical, EUT Orientation: Z - Peak Figure 18 - 1 GHz to 3 GHz – Polarity: Vertical, EUT Orientation: Z - Average COMMERCIAL-IN-CONFIDENCE Page 18 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE Frequency Result (dBµV/m) Limit (dBµV/m) Margin (dBµV/m) (GHz) Peak Average Peak Average Peak Average * Table 6 - 1 GHz to 3 GHz *No emissions were detected within 10 dB of the limit. FCC 47 CFR Part 15, Limit Clause 15.109 Frequency of Emission (MHz) Field Strength (µV/m) 30 to 88 100.0 88 to 216 150.0 216 to 960 200.0 Above 960 500.0 Table 7 2.1.7 Test Location and Test Equipment Used This test was carried out in EMC Chamber 5. Calibration Instrument Manufacturer Type No TE No Period Calibration Due (months) Turntable Controller Inn-Co GmbH CO 1000 1606 - TU Antenna (Bilog) Chase CBL6143 2904 24 8-Aug-2019 Tilt Antenna Mast Maturo Gmbh TAM 4.0-P 3916 - TU Mast Controller Maturo Gmbh NCD 3917 - TU 1GHz to 8GHz Low Noise Wright Technologies APS04-0085 4365 12 18-Oct-2018 Amplifier Cable (Rx, Nm-Nm, 7m) Scott Cables SLU18-NMNM- 4498 6 19-Jun-2018 07.00M Cable (Rx, Km-Km 2m) Scott Cables KPS-1501-2000- 4526 6 2-Jul-2018 KPS Cable (Rx, SMAm-SMAm Scott Cables SLSLL18-SMSM- 4528 6 15-Aug-2018 0.5m) 00.50M 4dB Attenuator Pasternack PE7047-4 4935 12 28-Nov-2018 Table 8 TU – Traceability Unscheduled COMMERCIAL-IN-CONFIDENCE Page 19 of 20

Document Number: 75940615-01 | Issue: 01 COMMERCIAL-IN-CONFIDENCE 3 Measurement Uncertainty For a 95% confidence level, the measurement uncertainties for defined systems are: Test Name Measurement Uncertainty Radiated Disturbance 30 MHz to 1 GHz, Bilog Antenna, ±5.2 dB 1 GHz to 40 GHz, Horn Antenna, ±6.3 dB Table 9 COMMERCIAL-IN-CONFIDENCE Page 20 of 20


Document Created: 2018-06-13 08:57:38
Document Modified: 2018-06-13 08:57:38
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC