Test report

FCC ID: R8Y7RC04-CF100002

Test Report

Download: PDF
FCCID_2377742

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 1 of 22 EMC TEST REPORT Report No. : TW14040007 Model No. : 7RC04-CF100005 Issued Date :Aug. 21, 2014 Applicant: Pan-World Control Technologies, Inc. 5F, No. 81, Sec. 1, Sintai 5th. RD., Sijhih, New Taipei City 22101, Taiwan Test Method/ Standard: 47 CFR FCC Part 15.249 & ANSI C63.4 2003 Test By: Intertek Testing Services Taiwan Ltd. No. 11, Lane 275, Ko-Nan 1 Street, Chia-Tung Li, Shiang-Shan District, Hsinchu City, Taiwan It may be duplicated completely for legal use with the allowance of the applicant. It shall not be reproduced except in full, without the written approval of Intertek Laboratory. The test result(s) in this report only applies to the tested sample(s). The test report was prepared by: Evelyn Lee/ Officer These measurements were taken by: Ricky Lee/ Engineer The test report was reviewed by: Name Jimmy Yang Title Senior Engineer

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 2 of 22 Table of Contents Summary of Tests ............................................................................................................. 3 1. General information...................................................................................................... 4 1.1 Identification of the EUT .................................................................................................... 4 1.2 Additional information about the EUT ............................................................................... 5 1.3 Antenna description ............................................................................................................ 5 2. Test specifications......................................................................................................... 6 2.1 Test standard ....................................................................................................................... 6 2.2 Operation mode................................................................................................................... 6 2.3 Test equipment .................................................................................................................... 7 3. Radiated emission test FCC 15.249 (C) ....................................................................... 8 3.1 Operating environment ....................................................................................................... 8 3.2 Test setup & procedure ....................................................................................................... 8 3.3 Emission limit ..................................................................................................................... 9 3.3.1 Fundamental and harmonics emission limits ................................................................... 9 3.3.2 General radiated emission limits...................................................................................... 9 3.4 Radiated spurious emission test data ................................................................................ 10 3.4.1 Measurement results: frequencies equal to or less than 1 GHz ..................................... 10 3.4.2 Measurement results: frequency above 1GHz ............................................................... 11 3.4.3 Measurement results: Fundamental and harmonics emission ........................................ 14 4. Radiated emission on the band edge FCC 15.249(d) ................................................. 16 5. Conducted emission test FCC 15.207 ........................................................................ 19 6. 20dB Bandwidth test .................................................................................................. 20 6.1 Operating environment ..................................................................................................... 20 6.2 Test setup & procedure ..................................................................................................... 20 6.3 Measured data of modulated bandwidth test results ......................................................... 20

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 3 of 22 Summary of Tests Test Reference Results Radiated Emission test 15.249(c), 15.209 Pass Emission on the Band Edge 15.249(d) Pass Conducted Emission of AC Power 15.207 N/A 20dB Bandwidth 15.215(c) Pass

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 4 of 22 1. General information 1.1 Identification of the EUT Product: Remote control for ceiling fan Model No.: 7RC04-CF100005 FCC ID.: R8Y7RC04-CF100002 Frequency Range: 2410MHz, 2420MHz, 2425MHz Channel Number: 3 channels Frequency of Each Channel: Low channel: 2410 MHz, Middle channel: 2420 MHz, High channel: 2425 MHz Type of Modulation: GFSK Rated Power: DC 3V Power Cord: N/A Data Cable: N/A Sample Received: Aug. 15, 2014 Test Date(s): Aug. 18, 2014 Note 1: This report is for the exclusive use of Intertek's Client and is provided pursuant to the agreement between Intertek and its Client. Intertek's responsibility and liability are limited to the terms and conditions of the agreement. Intertek assumes no liability to any party, other than to the Client in accordance with the agreement, for any loss, expense or damage occasioned by the use of this report. Only the Client is authorized to permit copying or distribution of this report and then only in its entirety. Any use of the Intertek name or one of its marks for the sale or advertisement of the tested material, product or service must first be approved in writing by Intertek. The observations and test results in this report are relevant only to the sample tested. This report by itself does not imply that the material, product, or service is or has ever been under an Intertek certification program. Note 2: When determining the test conclusion, the Measurement Uncertainty of test has been considered.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 5 of 22 1.2 Additional information about the EUT The EUT is a Remote control for ceiling fan, and was defined as information technology equipment. Modification (R1) to test report No.: TW14040007(R1) (Verification No.: TW14040007(R1)) The original Test Report Ref. No.: TW14040007, dated Apr. 25, 2014 was modified on Aug. 21, 2014 to include the following changes and/or additions, which were considered technical modifications: Add a serial model “7RC04-CF100005”, and the different is in microphone. After engineer judgment, the difference does not affect the RF characteristic; the model was evaluated and deemed as meet the standards requirement, radiated emission test was considered necessary. For more detail features, please refer to user's Manual. 1.3 Antenna description The EUT uses a permanently connected antenna. Antenna Gain : 0 dBi Antenna Type : Print antenna Connector Type : Fixed

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 6 of 22 2. Test specifications 2.1 Test standard The EUT was performed according to the procedures in FCC Part 15 Subpart C Paragraph 15.249 for non-spread spectrum devices. The test of radiated measurements according to FCC Part15 Section 15.33(a) had been conducted and the field strength of this frequency band was all meet limit requirement, thus we evaluate the EUT pass the specified test. 2.2 Operation mode The EUT is supplied with DC 3 V from battery and use of individual EUT fixed frequency, press the power button for continuous emission. The signal is maximized through rotation and placement in the three orthogonal axes. X axis Y axis Z axis After verifying three axes, we found the maximum electromagnetic field was occurred at X axis. The final test data was executed under this configuration.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 7 of 22 2.3 Test equipment Next Calibration Equipment Brand Model No. Serial No. Calibration Date Date EMI Test Rohde & Schwarz ESCI 100018 2013/11/29 2014/11/28 Receiver Spectrum Rohde & Schwarz FSP30 100137 2014/06/16 2015/06/15 Analyzer Spectrum Rohde & Schwarz FSEK30 100186 2014/01/20 2015/01/19 Analyzer Horn Antenna Schwarzbeck BBHA 9120 D 9120D-456 2012/09/03 2014/09/03 (1-18G) Horn Antenna SHWARZBECK BBHA 9170 BBHA9170159 2012/09/05 2014/09/05 (14-42G) Broadband SCHWARZBECK VULB 9168 9168-172 2013/08/08 2015/08/07 Antenna AFS44-0010265 Pre-Amplifier MITEQ 1495287 2013/10/27 2015/10/26 0--42-10P-44 JS4-26004000-- Pre-Amplifier MITEQ 828825 2012/09/18 2014/09/17 27-8A Power Meter Anritsu ML2495A 0844001 2013/10/10 2014/10/09 Power Senor Anritsu MA2411B 0738452 2013/10/10 2014/10/09 Temperature&Hu MHU-225LRU midity Test TERCHY 950838 2014/06/12 2015/06/11 (SA) Chamber Two-Line Rohde & Schwarz ESH3-Z5 838979/014 2013/10/12 2014/10/11 V-Network Note: The above equipments are within the valid calibration period.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 8 of 22 3. Radiated emission test FCC 15.249 (C) 3.1 Operating environment Temperature: 25 ℃ Relative Humidity: 50 % Atmospheric Pressure 1008 hPa 3.2 Test setup & procedure The Diagram below shows the test setup, which is utilized to make these measurements. Antenna Tower Horn or Bilog 3 meter 1-4 meter Antenna HPF and Pre-Amp. EUT 0.8 Ground Plane □ RF Test Receiver Radiated emissions were invested cover the frequency range from 30MHz to 1000MHz using a receiver RBW of 120kHz record QP reading, and the frequency over 1GHz using a spectrum analyzer RBW of 1MHz and 10Hz VBW record Average reading. (15.209 paragraph), the Peak reading (1MHz RBW; 3MHz VBW) recorded also on the report. The EUT for testing is arranged on a wooden turntable. If some peripherals apply to the EUT, the peripherals will be connected to EUT and the whole system. During the test, all cables were arranged to produce worst-case emissions. The signal is maximized through rotation. The height of antenna and polarization is changing constantly for exploring for maximum signal level. The height of antenna can be up to 4 meters and down to 1 meter.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 9 of 22 3.3 Emission limit 3.3.1 Fundamental and harmonics emission limits Field Strength of Fundamental Field Strength of Harmonics Frequency (MHz) (mV/m@3m) (dBuV/m@3m) (uV/m@3m) (dBuV/m@3m) 2400-2483.5 50 94 500 54 3.3.2 General radiated emission limits Emissions radiated outside of the specified frequency bands, except for harmonics, shall be attenuated by at least 50dB below the level of the fundamental or to the general radiated emission limits in paragraph 15.209, whichever is the lesser attenuation. Frequency 15.209 Limits MHz (dBμV/m@3m) 30-88 40 88-216 43.5 216-960 46 Above 960 54 Remark: 1. In the above table, the tighter limit applies at the band edges. 2. Distance refers to the distance in meters between the measuring instrument antenna and the closed point of any part of the device or system Measurement uncertainty was calculated in accordance with TR 100 028-1. Parameter Uncertainty Radiated Emission ± 5.10 dB Conducted Emission ± 2.786 dB This uncertainty represents an expanded uncertainty expressed at approximately the 95 % confidence level using a coverage factor of k=2.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 10 of 22 3.4 Radiated spurious emission test data 3.4.1 Measurement results: frequencies equal to or less 1 G than Hz The test was performed on EUT under Low, Middle, High channel continuously transmitting mode. The worst case occurred at Tx High channel. EUT : 7RC04-CF100002 Test Condition : Tx at High channel Antenna Freq. Receiver Corr. Reading Corrected Limit Margin Polariz. Factor Level @3m (V/H) (MHz) Detector (dB/m) (dBuV) (dBuV/m) (dBuV/m) (dB) Vertical 274.44 QP 16.66 6.41 23.07 46.00 -22.93 Vertical 313.24 QP 17.76 23.00 23.53 46.00 -22.47 Vertical 383.08 QP 19.51 23.00 27.44 46.00 -18.56 Vertical 435.46 QP 20.82 23.00 27.89 46.00 -18.11 Vertical 464.56 QP 21.44 23.00 28.45 46.00 -17.55 Vertical 577.08 QP 23.69 23.00 31.95 46.00 -14.05 Horizontal 383.08 QP 19.37 23.00 27.96 46.00 -18.04 Horizontal 429.64 QP 20.18 23.00 27.01 46.00 -18.99 Horizontal 497.54 QP 21.37 23.00 29.62 46.00 -16.38 Horizontal 516.94 QP 21.71 23.00 34.44 46.00 -11.56 Horizontal 544.10 QP 22.19 23.00 31.67 46.00 -14.33 Horizontal 577.08 QP 22.77 21.00 35.00 46.00 -11.00 Remark: 1. Corr. Factor = Antenna Factor + Cable Loss 2. Corrected Level = Reading + Corr. Factor

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 11 of 22 3.4.2 Measurement results: frequency above 1GHz EUT : 7RC04-CF100002 Test Condition : Tx at Low channel Frequency Spectrum Antenna Correction Reading Corrected Limit Margin Analyzer Polariz. Factor Level @3m (MHz) Detector (H/V) (dB/m) (dBuV) (dBuV/m) (dBuV/m) (dB) 4820 PK V -0.13 46.04 45.91 74.00 -28.09 4820 PK H -0.13 44.90 44.77 74.00 -29.23 7230 PK V 8.21 38.46 46.67 74.00 -27.33 7230 PK H 8.21 38.91 47.12 75.00 -27.88 9640 PK V 12.21 40.89 53.10 74.00 -20.90 12050 PK V 14.25 50.44 64.69 74.00 -9.31 12050 AV V 14.25 23.72 37.97 54.00 -16.03 12050 PK H 14.25 37.73 51.98 74.00 -22.02 Remark: 1. Correction Factor = Antenna Factor + Cable Loss 2. Corrected Level = Reading + Correction Factor – Preamp. Gain 3. The frequency measured ranges from 1 GHz to 25 GHz.The data value listed above which is higher than the system noise floor.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 12 of 22 EUT : 7RC04-CF100002 Test Condition : Tx at Middle channel Frequency Spectrum Antenna Correction Reading Corrected Limit Margin Analyzer Polariz. Factor Level @3m (MHz) Detector (H/V) (dB/m) (dBuV) (dBuV/m) (dBuV/m) (dB) 4840 PK V -0.04 50.42 50.38 74.00 -23.62 4840 PK H -0.04 58.45 58.41 74.00 -15.59 4840 AV H -0.04 32.58 32.54 54.00 -21.46 7260 PK V 8.34 61.55 69.89 74.00 -4.11 7260 AV V 8.34 25.21 33.55 54.00 -20.45 7260 PK H 8.34 50.15 58.49 74.00 -15.51 7260 AV H 8.34 24.07 32.41 54.00 -21.59 9680 PK V 12.21 50.89 63.10 74.00 -10.90 9680 AV V 12.21 23.68 35.89 54.00 -18.11 9680 PK H 12.21 48.49 60.70 74.00 -13.30 9680 AV H 12.21 32.36 44.57 54.00 -9.43 12120 PK V 14.28 37.88 52.16 74.00 -21.84 Remark: 1. Correction Factor = Antenna Factor + Cable Loss 2. Corrected Level = Reading + Correction Factor – Preamp. Gain 3. The frequency measured ranges from 1 GHz to 25 GHz.The data value listed above which is higher than the system noise floor.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 13 of 22 EUT : 7RC04-CF100002 Test Condition : Tx at High channel Frequency Spectrum Antenna Correction Reading Corrected Limit Margin Analyzer Polariz. Factor Level @3m (MHz) Detector (H/V) (dB/m) (dBuV) (dBuV/m) (dBuV/m) (dB) 4850 PK V 0.01 48.65 48.66 74.00 -25.34 4850 PK H 0.01 45.99 46.00 74.00 -28.00 7275 PK V 8.41 55.81 64.22 74.00 -9.78 7275 AV V 8.41 24.57 32.98 54.00 -21.02 7275 PK H 8.41 52.48 60.89 74.00 -13.11 7275 AV H 8.41 23.95 32.36 54.00 -21.64 9700 PK V 12.21 51.75 63.96 74.00 -10.04 9700 AV V 12.21 23.92 36.13 54.00 -17.87 9700 PK H 12.21 45.17 57.38 74.00 -16.62 9700 AV H 12.21 23.17 35.38 54.00 -18.62 12125 PK V 14.29 51.11 65.40 74.00 -8.60 12125 AV V 14.29 23.32 37.61 54.00 -16.39 Remark: 1. Correction Factor = Antenna Factor + Cable Loss 2. Corrected Level = Reading + Correction Factor – Preamp. Gain 3. The frequency measured ranges from 1 GHz to 25 GHz.The data value listed above which is higher than the system noise floor.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 14 of 22 3.4.3 Measurement results: Fundamental and harmonics emission EUT : 7RC04-CF100002 Test Condition : Tx at Low channel Frequency Spectrum Ant. Correction Reading Corrected Limit Margin Analyzer Pol. Factor Reading @3m (MHz) Detector (H/V) (dB/m) (dBμV) (dBμV/m) (dBμV/m) (dB) 2410 PK V 32.58 49.54 82.12 94.00 -11.88 2410 PK H 32.58 60.09 92.67 94.00 -1.33 Remark: 1. Correction Factor = Antenna Factor + Cable Loss 2. Corrected Level = Reading + Correction Factor – Preamp. Gain 3. The frequency measured ranges from 1 GHz to 25 GHz.The data value listed above which is higher than the system noise floor. EUT : 7RC04-CF100002 Test Condition : Tx at Middle channel Frequency Spectrum Ant. Correction Reading Corrected Limit Margin Analyzer Pol. Factor Reading @3m (MHz) Detector (H/V) (dB/m) (dBμV) (dBμV/m) (dBμV/m) (dB) 2420 PK V 32.62 48.18 80.80 94.00 -13.20 2420 PK H 32.62 56.54 89.16 94.00 -4.84 Remark: 1. Correction Factor = Antenna Factor + Cable Loss 2. Corrected Level = Reading + Correction Factor – Preamp. Gain 3. The frequency measured ranges from 1 GHz to 25 GHz.The data value listed above which is higher than the system noise floor.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 15 of 22 EUT : 7RC04-CF100002 Test Condition : Tx at High channel Frequency Spectrum Ant. Correction Reading Corrected Limit Margin Analyzer Pol. Factor Reading @3m (MHz) Detector (H/V) (dB/m) (dBμV) (dBμV/m) (dBμV/m) (dB) 2425 PK V 32.63 50.23 82.86 94.00 -11.14 2425 PK H 32.63 60.82 93.45 94.00 -0.55 Remark: 1. Correction Factor = Antenna Factor + Cable Loss 2. Corrected Level = Reading + Correction Factor – Preamp. Gain 3. The frequency measured ranges from 1 GHz to 25 GHz.The data value listed above which is higher than the system noise floor.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 16 of 22 4. Radiated emission on the band edge FCC 15.249(d) Emissions radiated outside of the specified frequency bands, except for harmonics, shall be attenuated by at least 50 dB below the level of the fundamental (2410 ~ 2425 MHz) or to the general radiated emission limits in §15.209, whichever is the lesser attenuation. Frequency Spectrum Ant. Correction Reading Corrected Limit Margin Restricted Analyzer Pol. Factor Reading @ 3 m band (MHz) Detector (H/V) (dB/m) (dBμV) (dBμV/m) (dBμV/m) (dB) (MHz) 2390.00 PK H 32.51 23.70 56.21 74 -17.79 2310~2390 2390.00 AV H 32.51 12.31 44.82 54 -9.18 2410.00 PK H 32.58 62.29 94.87 - 94.87 - 2410.00 AV H 32.58 15.92 48.50 - 48.50 2425.00 PK H 32.63 64.97 97.60 - 97.60 - 2425.00 AV H 32.63 16.40 49.03 - 49.03 2483.50 PK H 32.84 25.18 58.02 74 -15.98 2483.5~2500 2383.50 AV H 32.49 12.91 45.40 54 -8.60 Please see the plot below.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 17 of 22 Band edge @ GFSK mode Low channel PK MARKER 1 * RBW 1 MHz Marker 1 [T1 ] 2.40996 GHz * VBW 3 MHz 94.87 dBµV Ref 97 dBµV * Att 0 dB SWT 5 ms 2.409960000 GHz 1 Marker 2 [T1 ] 90 56.21 dBµV 2.390000000 GHz A 1 PK 80 MAXH Limit_1 70 TDF 60 2 Limit_2 50 40 30 20 10 0 Center 2.3625 GHz 10.5 MHz/ Span 105 MHz Comment: 2nd comment ... Date: 26.MAR.2014 17:15:18 Band edge @ GFSK mode Low channel AV MARKER 1 * RBW 1 MHz Marker 1 [T1 ] 2.40996 GHz * VBW 10 Hz 48.50 dBµV Ref 97 dBµV * Att 0 dB SWT 27 s 2.409960000 GHz Marker 2 [T1 ] 90 44.82 dBµV 2.390000000 GHz A 1 PK 80 MAXH Limit_1 70 TDF 60 Limit_2 1 50 2 40 30 20 10 0 Center 2.3625 GHz 10.5 MHz/ Span 105 MHz Comment: 2nd comment ... Date: 26.MAR.2014 17:16:28

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 18 of 22 Band edge @ GFSK mode High channel PK MARKER 1 * RBW 1 MHz Marker 1 [T1 ] 2.4248 GHz * VBW 3 MHz 97.60 dBµV Ref 1 97 dBµV * Att 0 dB SWT 2.5 ms 2.424800000 GHz Marker 2 [T1 ] 90 58.02 dBµV 2.483500000 GHz A 1 PK 80 MAXH Limit_1 70 TDF 60 2 Limit_2 50 40 30 20 10 0 Start 2.42 GHz 8 MHz/ Stop 2.5 GHz Comment: 2nd comment ... Date: 23.APR.2014 16:50:21 Band edge @ GFSK mode High channel AV MARKER 1 * RBW 1 MHz Marker 1 [T1 ] 2.4248 GHz * VBW 10 Hz 49.03 dBµV Ref 97 dBµV * Att 0 dB SWT 20 s 2.424800000 GHz Marker 2 [T1 ] 90 45.40 dBµV 2.483500000 GHz A 1 PK 80 MAXH Limit_1 70 TDF 60 Limit_2 1 50 2 40 30 20 10 0 Start 2.42 GHz 8 MHz/ Stop 2.5 GHz Comment: 2nd comment ... Date: 23.APR.2014 16:51:08

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 19 of 22 5. Conducted emission test FCC 15.207 Since the EUT is not connected to AC source, therefore, the test can be waived.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 20 of 22 6. 20dB Bandwidth test 6.1 Operating environment Temperature: 25 ℃ Relative Humidity: 50 % Atmospheric Pressure: 1008 hPa 6.2 Test setup & procedure The 20dB bandwidth was measured using a 50 ohm spectrum analyzer with the resolutions bandwidth set at 100 kHz, the video bandwidth≧RBW, and the SPAN may equal to approximately 2 to 3 times the 20dB bandwidth. The test was performed at 3 channels (lowest, middle and highest channel). The maximum 20dB modulation bandwidth is in the following Table. 6.3 Measured data of modulated bandwidth test results 20dB Frequency Data rate Bandwidth(MHz) Limit Mode Channel Pass/Fail (MHz) (MHz) Mbps chain0 Low 2410 1.56 0.5 Pass GFSK Middle 2420 1 1.65 0.5 Pass High 2425 1.41 0.5 Pass Please see the plot below.

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 21 of 22 20 dB Bandwidth @ Low channel 20 dB Bandwidth @ Middle channel

FCC ID. :R8Y7RC04-CF100002 Report No.: TW14040007(R1) Page 22 of 22 20 dB Bandwidth @ High channel


Document Created: 2014-08-26 09:45:40
Document Modified: 2014-08-26 09:45:40
© 2025 FCC.report
This site is not affiliated with or endorsed by the FCC