Test Report

FCC ID: PRDRX09

Test Report

Download: PDF
FCCID_2168342

rodurte Products LA¥ TOVRheintland® Priifbericht—Nr.: 10045004 001 Auftrags—Nr.: 114017241 Seite 1 von 24 Test Report No.: Order No.: Page 1 of 24 Kunden—Referenz—Nr.: N/A Auftragsdatum: December 20, 2013 Client Reference No.: Order date: Auttraggeber: ACROX Technologies Co., Ltd., 4F., No.89, Minshan St., Neihu Dist., Taipei City 114, Client; Taiwan, R.O.C. Priifgegenstand: 2.4 GHz Dongle Test item: Bezeichnung / Typ—Nr.: MQ6 Identification / Type No.: Auftrags—Inhalt: FCC Part 15C and IC test report Order content: Priifgrundlage: Test speciffication: FCC 47CFR Part 15: Subpart C Section 15.249 RSS—210 issue 8 (12—2010) Annex 2.9 Wareneingangsdatum: 12/24/2013 Date of receipt: Priifmuster—Nr.: A000033193—005 Test sample No.: Priifzeitraum: 27—Dec—2013 — 31—Dec—2013 Testing period: Ort der Priifung: EMC Laboratory Taipei Place of testing: Priiflaboratorium: TUV Rheinland Taiwan Ltd. Testing laboratory: Priifergebnis*: Pass Test result®: gepriift von / tested by: kontrolliert von / reviewed by: , > Pzirt 2014—01—14 _Danny S. C. Sung/Project Manager 2014—01—14 Rene Charton/Senior—ProjectManager Datum Name / Stellung Unterschrift Datum Name / Stellung Unterschrift Date Name ! Position Signature Date Name / Position Signature Sonstiges / Ofher: Zustand des Priifgegenstandes bei Anlieferung: Prifmuster vollstandig und unbeschddigt Condition of the test item at delivery: Test item complete and undamaged * Legende: 1 = sehr gut 2 = gut 3 = befriedigend 4 = ausreichend 5 = mangehaft P(ass) = entspricht 0.g. Profgrundlage(n) F(all) = entspricht nicht 0.9. Prifgrundlage(n) N/A = nicht anwendbar. N/T = nicht getestet Legend: 1 = very good 2=good 3 = satisfactory 4 = sufficient 5 = poor P(ass) = passed a.m. test specification(s) F(al) = falled a.m. test specification(s) N/A = not applicable N/T = not tested Dieser Priifbericht bezieht sich nur auf das o.g. Priifmuster und darf ohne Genehmigung der Priifstelle nicht auszugsweise vervielfaltigt werden. Dieser Bericht berechtigt nicht zur Verwendung eines Priifzeichens. This test report only relates to the a. m. test sample. Without permission of the test center this test report is not permitted to be w duplicated in extracts. This test report does not entitle to carry any test mark. TUV Rheinland LGA Products GmbH » TillystraRe 2 + D — 90431 Nimberg — Tel.: +49 911 655 5225 + Fax: +49 911 655 5226 Mail: service@de.tuv.com + Web: www.tuv.com

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 2 von 24 Test Report No. Page 2 of 24 TEST SUMMARY 5.1.1 FIELD STRENGTH OF FUNDAMENTAL RESULT: Passed 5.1.2 99% BANDWIDTH RESULT: Passed 5.1.3 SPURIOUS EMISSION RESULT: Passed 5.2.1 SPURIOUS EMISSION RESULT: Passed 5.3.1 CONDUCTED EMISSIONS LINE AND NEUTRAL RESULT: Passed

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 3 von 24 Test Report No. Page 3 of 24 Contents 1. GENERAL REMARKS ............................................................................................... 4 1.1 COMPLEMENTARY MATERIALS ................................................................................. 4 2. TEST SITES ............................................................................................................ 5 2.1 TEST FACILITIES ..................................................................................................... 5 2.2 LIST OF TEST AND MEASUREMENT INSTRUMENTS...................................................... 6 2.3 TRACEABILITY ........................................................................................................ 6 2.4 CALIBRATION ......................................................................................................... 7 2.5 MEASUREMENT UNCERTAINTY ................................................................................. 7 3. GENERAL PRODUCT INFORMATION ........................................................................... 8 3.1 PRODUCT FUNCTION AND INTENDED USE ................................................................. 8 3.2 RATINGS AND SYSTEM DETAILS ............................................................................... 8 3.3 INDEPENDENT OPERATION MODES ........................................................................... 9 3.4 NOISE GENERATING AND NOISE SUPPRESSING PARTS .............................................. 9 3.5 SUBMITTED DOCUMENTS ......................................................................................... 9 4. TEST SET-UP AND OPERATION MODES ................................................................... 10 4.1 PRINCIPLE OF CONFIGURATION SELECTION ............................................................ 10 4.2 TEST OPERATION AND TEST SOFTWARE................................................................. 10 4.3 SPECIAL ACCESSORIES AND AUXILIARY EQUIPMENT ............................................... 10 4.4 COUNTERMEASURES TO ACHIEVE EMC COMPLIANCE.............................................. 11 4.5 TEST SETUP DIAGRAM .......................................................................................... 11 5. TEST RESULTS ..................................................................................................... 13 5.1 TRANSMITTER REQUIREMENT & TEST SUITES ......................................................... 13 5.1.1 Field strength of fundamental..................................................................................................... 13 5.1.2 99% Bandwidth .......................................................................................................................... 15 5.1.3 Spurious Emission ..................................................................................................................... 18 5.2 MAINS CONDUCTED EMISSIONS ............................................................................. 19 5.2.1 Conducted Emissions Line and Neutral ..................................................................................... 19 6. PHOTOGRAPHS OF THE TEST SET-UP..................................................................... 20 7. LIST OF TABLES ................................................................................................... 24 8. LIST OF PHOTOGRAPHS......................................................................................... 24

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 4 von 24 Test Report No. Page 4 of 24 1. General Remarks 1.1 Complementary Materials All attachments are integral parts of this test report. This applies especially to the following appendix: Appendix P: Photo Documentation (File Name: 10045004APPENDIX P) Appendix D: Test Result of Radiated Emissions (File Name: 10045004APPENDIX D) Test Specifications The following standards were applied Table 1: Applied Standard and Test Levels Radio FCC 47CFR Part 15: Subpart C Section 15.249 RSS-210 issue 8 (12-2010) Annex 2.9 ANSI C63.4:2009

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 5 von 24 Test Report No. Page 5 of 24 2. Test Sites 2.1 Test Facilities TUV Rheinland Taiwan Ltd. 11F. No.758, Sec. 4, Bade Rd., Songshan Dist. Taipei City 105 Taiwan (R.O.C.) FCC Registration No.: 365730 TAF Accredited NCC Test Lab. No.:0759 TAF ISO17025 Certification effective periods: 2013-Jul-1st to 2016-Jun-30th

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 6 von 24 Test Report No. Page 6 of 24 2.2 List of Test and Measurement Instruments Table 2: List of Test and Measurement Equipment Kind of Calibrated Manufacturer Type S/N Equipment until EMI Test R&S ESCI 7 101062 1-Sep-14 Receiver Bilog Antenna TESEQ CBL6111D 29802 29-Jun-14 Spectrum R&S FSV 40 100921 10-Dec-14 Analyzer Horn Antenna ETS-Lindgren 3117 138160 10-Jan-14 Horn Antenna COM- AH840 101031 29-Oct-15 (18GHz~40GHz) POWER Preamplifier HP 8447F 2805A03335 2-Sep-14 (30MHz -1GHz) Preamplifier (18 COM- PAM-840 461257 2-Sep-14 GHz -40 GHz) POWER Pre-Amplifier EM EM30180 60558 23-Oct-14 (1GHz~18GHz) Electronics Loop Antenna Schwarzbeck FMZB 1513 1513-076 28-Sep-14 EMI Test R&S ESCI 101094 29-Aug-14 Receiver LISN (1 phase) R&S ENV216 101243 5-Jun-14 LISN Rolf Heine NNB-2/16Z 99080 30-Aug-14 2.3 Traceability All measurement equipment calibrations are traceable to NML(Taiwan)/NIST(USA) or where calibration is performed outside Taiwan, to equivalent nationally recognized standards organizations.

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 7 von 24 Test Report No. Page 7 of 24 2.4 Calibration Equipment requiring calibration is calibrated periodically by a suitably accredited Calibration Lab. Additionally all equipment is verified for proper performance on a regular basis using in house standards or comparisons. 2.5 Measurement Uncertainty The estimated combined standard uncertainty for radiated emissions and conducted emissions measurements:. Table 3: Emission Measurement Uncertainty Parameter Uncertainty RF power, conducted ± 1.5 dB Adjacent channel power ± 3 dB Radiated emission of transmitter, valid up to 26 GHz ± 6 dB Radiated emission of receiver, valid up to 26 GHz ± 6 dB Temperature ± 2 ºC Humidity ± 10 %

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 8 von 24 Test Report No. Page 8 of 24 3. General Product Information 3.1 Product Function and Intended Use The EUT is a set: A Wireless Mouse which sends control information to a Wireless Dongle, that can be inserted into a Computer. This report covers the Dongle For details refer to the User Guide, Data Sheet and Circuit Diagram. 3.2 Ratings and System Details Table 4: Basic Information of EUT Item EUT information Kind of Equipment 2.4 GHz Dongle Type Designation MQ6 Brand Name FCC ID PRDRX09 Table 5: Technical Specification of EUT Technical Specification Value Operating Frequencies 2408 2440 2474 MHz Channel Spacing 2 MHz minimum Channel number 32 Operation Voltage 5V Modulation FSK

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 9 von 24 Test Report No. Page 9 of 24 3.3 Independent Operation Modes Basic operation modes are: A. Transmitting 1. Low channel 2. Middle channel 3. High channel B. Receiving 1. Low channel 2. Middle channel 3. High channel 3.4 Noise Generating and Noise Suppressing Parts Refer to the Circuit Diagram. 3.5 Submitted Documents - Circuit Diagram - Instruction Manual - Rating Label - Technical Description

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 10 von 24 Test Report No. Page 10 of 24 4. Test Set-up and Operation Modes 4.1 Principle of Configuration Selection The equipment under test (EUT) was configured to measure its maximum emission level. The test modes were adapted accordingly in reference to the instructions for use. 4.2 Test Operation and Test Software Setup for testing: Test samples are provided with a USBI interface which makes it possible to control them through a test software installed on a notebook computer. This software was running on the laptop computer connected to the EUT. It was used to enable the operation modes listed in section 3.3 as appropriate. Emission Level Measurement Results are obtained with the EUT set to continuous transmission mode. The pulse timing of the actual operation mode is obtained by exercising the optical sensor of the mouse Mouse, in the normal operating mode, with a paper slip attached to the rotor of a DC Fan. Please also refer to the Photo in the Test Setup Section. Full test was applied on all test modes, but only worst case was shown. 4.3 Special Accessories and Auxiliary Equipment The product has been tested together with the following additional accessories: Kind of Equipment Manufacturer Model Name S/N Laptop HP HSTNN-Q78C-3 CNF0339QBM

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 11 von 24 Test Report No. Page 11 of 24 4.4 Countermeasures to achieve EMC Compliance The test sample which has been tested containing the noise suppression parts as shown in the Photo Appendix and the Test Setup Photos. No additional measures were employed to achieve compliance. 4.5 Test Setup Diagram Diagram of Measurement Configuration for Radiation Test

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 12 von 24 Test Report No. Page 12 of 24 Diagram of Measurement Equipment Configuration for Mains Conduction Measurement (if applicable)

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 13 von 24 Test Report No. Page 13 of 24 5. Test Results 5.1 Transmitter Requirement & Test Suites 5.1.1 Field strength of fundamental RESULT: Passed Test standard : FCC Part 15.249(a), RSS-210 A2.9 LP0002: 3.10.2(2) Basic standard : ANSI C63.10:2009 Kind of test site : Semi-Anechoic Chamber Test setup Test Channel : Low/ Middle/ High Operation Mode : A Atmospheric pressure : 100-103 kPa In the table below the maximum results found are reported. For detailed results of all frequencies tested, please refer to Appendix D. The EUT employs pulsed operation. The pulse width is: 480 us Pulse repetition interval: 8 ms The Tables below show calculated average values from the pulsed emissions measurement data, corrected with the worst case duty cycle factor over 100 msec. The average values noted are calculated through the application of a duty cycle correction, according to part 15.35c Duty cycle calculation: Duty cycle correction (dB) = 20 log ( 480 us / 8 ms ) = - 24 dB.

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 14 von 24 Test Report No. Page 14 of 24 Test Plot pulse width Table 6: Test result of Field strength of fundamental Channel Test result Frequency (MHz) Level Limit Antenna Detector (dBuV/m) (dBuV/m) orientation 2408 92.32 114 Peak Horizontal 2408 <92.32 94 Average 2408 87.15 114 Peak Vertical 2408 <87.15 94 Average 2440 91.91 114 Peak Horizontal 2440 <91.91 94 Average 2440 89.29 114 Peak Vertical 2440 <89.29 94 Average 2474 90.35 114 Peak Horizontal 2474 <90.35 94 Average 2474 88.69 114 Peak Vertical 2474 <88.69 94 Average Remark: For details refer to Appendix D.

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 15 von 24 Test Report No. Page 15 of 24 5.1.2 99% Bandwidth RESULT: Passed Test standard : RSS-Gen Basic standard : ANSI C63.10:2009 Kind of test site : Semi-Anechoic Chamber Test setup Test Channel : Low/ Middle/ High Operation Mode : A Ambient temperature : 22-26 °C Relative humidity : 50-65 % Atmospheric pressure : 100-103 kPa Table 7: Test result of 99% Bandwidth, Channel 99% Bandwidth Channel Frequency (MHz) (MHz) Low Channel 2408 0.264 Mid Channel 2440 0.292 High Channel 2474 0.289

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 16 von 24 Test Report No. Page 16 of 24 Test Plot of 99% Bandwidth Low Channel Middle Channel

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 17 von 24 Test Report No. Page 17 of 24 High Channel

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 18 von 24 Test Report No. Page 18 of 24 5.1.3 Spurious Emission RESULT: Passed Test standard : FCC part 15.249(d), FCC 15.205, FCC 15.209, RSS-210 2.2, RSS-210 A2.9(b), RSS-Gen 7.2.1 Basic standard : ANSI C63.10: 2009 Limits : Radiated emissions which fall in the restricted bands, as defined in FCC 15.205(a), must comply with the radiated emission limits specified in FCC 15.209(a). Emission radiated outside the specified frequency bands must comply with the radiated emission limits specified in FCC 15.209(a) and FCC 15.249(a). Kind of test site : 3m Semi-Anechoic Chamber Test setup Test Channel : Low/ Middle/ High Operation mode : A Remark: Testing was carried out within frequency range 30MHz to the tenth harmonic. For details refer to Appendix D. The Radiated Emissions testing was performed in the X, Y and Z axis orientation. The X Axis orientation is the worst-case and recorded in this test report. Due to the small size of the product and that there are no inductive components of significant size, 9kHz to 30MHz frequency range is not tested based on technical judgment. The EUT employs pulsed operation. The pulse width is: 480 us Pulse repetition interval: 8 ms The average values shown in the appendix are measured with the EUT set to a continuous signal. In case the limit of 54 dBuV is exceeded, the duty cycle correction factor according to part 15.35c is applied to the measurement result obtained with the peak detector. Duty cycle calculation: Duty cycle correction (dB) = 20 log ( 480 us / 8 ms ) = - 24 dB.

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 19 von 24 Test Report No. Page 19 of 24 5.2 Mains Conducted Emissions 5.2.1 Conducted Emissions Line and Neutral RESULT: Passed Test standard : FCC Part 15.207 FCC Part 15.107 RSS-Gen 7.2.4 Limits : Mains Conducted emissions as defined in above test standards must comply with the mains conducted emission limits specified Kind of test site : Shielded Room Test setup Test Channel : Middle Operation mode : Charging Remark: For details refer to Appendix D.

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 20 von 24 Test Report No. Page 20 of 24 6. Photographs of the Test Set-Up Photograph 1: Set-up for Spurious Emissions (Front View)

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 21 von 24 Test Report No. Page 21 of 24 Photograph 2: Set-up for Spurious Emissions (Back View 1 TX) Photograph 3: Set-up for Spurious Emissions (Back View 2 TX)

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 22 von 24 Test Report No. Page 22 of 24 Photograph 4: Set-up for Exercising Mouse in Normal Operation Mode

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 23 von 24 Test Report No. Page 23 of 24 Photograph 5: Set-up for for Mains Conducted testing, Back Photograph 6: Set-up for for Mains Conducted testing, Front

Produkte Products Prüfbericht - Nr.: 10045004 001 Seite 24 von 24 Test Report No. Page 24 of 24 7. List of Tables Table 1: Applied Standard and Test Levels .................................................................................................. 4 Table 2: List of Test and Measurement Equipment ...................................................................................... 6 Table 3: Emission Measurement Uncertainty................................................................................................ 7 Table 4: Basic Information of EUT ................................................................................................................ 8 Table 5: Technical Specification of EUT ....................................................................................................... 8 Table 6: Test result of Field strength of fundamental .................................................................................. 14 Table 7: Test result of 99% Bandwidth, ....................................................................................................... 15 8. List of Photographs Photograph 1: Set-up for Spurious Emissions (Front View)........................................................................ 20 Photograph 2: Set-up for Spurious Emissions (Back View 1 TX) ............................................................... 21 Photograph 3: Set-up for Spurious Emissions (Back View 2 TX) ............................................................... 21 Photograph 6: Set-up for for Mains Conducted testing Back ...................................................................... 23 Photograph 7: Set-up for for Mains Conducted testing Front...................................................................... 23


Document Created: 2014-01-17 07:27:00
Document Modified: 2014-01-17 07:27:00
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC