Test Report RF Module

FCC ID: PBR-SZHHG32D

Test Report

Download: PDF
FCCID_3741385

Produkte Products Prüfbericht - Nr.: 01200091 001 Seite 1 von 27 Test Report No.: Page 1 of 27 Auftraggeber: The Kroger Co. Client: 11450 Grooms Rd. Blue Ash, OH 45242 United States Gegenstand der Prüfung: CC2530 ZigBee MODULE Test item: Bezeichnung: SRNMRG Serien-Nr.: Engineering Sample Identification: Serial No. Wareneingangs-Nr.: 1403021240 Eingangsdatum: 21.07.2012 Receipt No.: Date of receipt: Prüfort: Refer Page 4 of 27 for test facilities Testing location: Prüfgrundlage: FCC Part 15, Subpart C Test specification: ANSI C63.4-2003 Prüfergebnis: Der Prüfgegenstand entspricht oben genannter Prüfgrundlage(n). Test Result: The test items passed the test specification(s). Prüflaboratorium: TÜV Rheinland (India) Pvt. Ltd. Testing Laboratory: 82/A, 3rd Main, West Wing, Electronic City Phase 1 Hosur Road, Bangalore – 560 100. India geprüft / tested by: kontrolliert / reviewed by: 22.08.2012 Vinay N 24.08.2012 Raghavendra Kulkarni Test Engineer Manager Datum Name/Stellung Unterschrift Datum Name/Stellung Unterschrift Date Name/Position Signature Date Name/Position Signature Sonstiges /Other Aspects: FCC ID : PBR-SZMDLNR1 Abkürzungen: P(ass) = entspricht Prüfgrundlage Abbreviations: P(ass) = passed F(ail) = entspricht nicht Prüfgrundlage F(ail) = failed N/A = nicht anwendbar N/A = not applicable N/T = nicht getestet N/T = not tested Dieser Prüfbericht bezieht sich nur auf das o.g. Prüfmuster und darf ohne Genehmigung der Prüfstelle nicht auszugsweise vervielfältigt werden. Dieser Bericht berechtigt nicht zur Verwendung eines Prüfzeichens. This test report relates to the a. m. test sample. Without permission of the test center this test report is not permitted to be duplicated in extracts. This test report does not entitle to carry any safety mark on this or similar products. TÜV Rheinland LGA Products GmbH  Tillystraße 2  D - 90431 Nürnberg  Tel.: +49 911 655 5225  Fax: +49 911 655 5226 Mail: service@de.tuv.com  Web: www.tuv.com Rev.:1.2 2009-12-29 / approved: M.Jungnitsch

www.tuv.com Test Result Summary Clause Test Item Result FCC 15.247(b) (3) Maximum Conducted Peak Output Power Pass FCC 15.247(a) (2) 6dB Bandwidth Pass FCC 15.247(e) Power Spectral Density Pass FCC 15.247(d) Band-edge compliance Pass FCC 15.209 Spurious Radiated Emissions Pass FCC 15.205 Restricted Bands of Operation Pass FCC 15.207 Conducted Emissions on a.c Power lines Pass Test Report No.: 01200091 001 Date: 14.08.2012 Page 2 of 27

www.tuv.com Content List of Type and Measurement Instruments ............................................................. 4 General Product Information ..................................................................................... 5 Product Function and Intended Use ............................................................................................. 5 Ratings and System Details........................................................................................................... 5 Test Set-up and Operation Mode ............................................................................... 6 Principle of Configuration Selection ............................................................................................ 6 Test Operation and Test Software ................................................................................................ 6 Special Accessories and Auxiliary Equipment ............................................................................ 6 Countermeasures to achieve EMC Compliance .......................................................................... 6 Test Methodology ....................................................................................................... 7 Radiated Emission Test ................................................................................................................. 7 Test Results ................................................................................................................. 8 Maximum Conducted Peak Output Power Section 15.247(b) (3) ......................... 8 Power Spectral Density Section 15.247(e) ............................ 11 6 dB Bandwidth Section 15.247(a)(2)........................ 14 Band-edge Compliance Section 15.247(d) ........................... 18 Spurious Radiated Emissions and Restricted Bands of Operation Section 15.209 and 15.205 ................................................................................................................................ 23 Conducted Emission Test on a.c. Power Line Section 15.207 .............................. 25 Appendix 1: Test Setup Photo Appendix 2: EUT External Photo Appendix 3: EUT Internal Photo Appendix 4: FCC Label and Label Location Appendix 5: Block Diagram Appendix 6: Specification of EUT Appendix 7: Schematic Diagrams Appendix 8: Bill of Material Appendix 9: User Manual Appendix 10: Maximum Permissible Exposure Calculation Test Report No.: 01200091 001 Date: 14.08.2012 Page 3 of 27

www.tuv.com List of Type and Measurement Instruments TÜV Rheinland (India) Pvt. Ltd, Bangalore List of Test and Measurement Instruments Equipment Manufacturer Model S/N Calibration Due Date EMI Test Receiver Rohde &Schwarz ESU 40 100288 21.07.2013 EMI Test Receiver Rohde &Schwarz ESCI 100661 17.03.2013 Hybrid Log Periodic antenna ETS Lindgren 3142D 00081354 26.07.2013 Broadband Horn Antenna Frankonia HAX-18 HAX18-802 23.03.2013 Double-Ridged Waveguide ETS Lindgren 116794 00133356 01-09-2013 Horn Antenna Emission Horn Antenna ETS Lindgren 116706 00107323 24-08-2013 Active Loop Antenna Frankonia LAX-10 LAX-10-800 11-04-2013 Agilent Spectrum Analyser E4407B US41192772 17.03.2013 Technologies Testing Facilities: 1) TUV Rheinland (India) Private Limited No. 108, West Wing Electronic city Phase I Bangalore – 560100 Test Report No.: 01200091 001 Date: 14.08.2012 Page 4 of 27

www.tuv.com General Product Information Product Function and Intended Use The SRNMRG Module is designed to be use for Zigbee Wireless network applications. The SRNMRG is 2.4GHz ZigBee/802.15.4 Wireless device to be used with Host System to create low power network. The module will be soldered on Host Board and will be powered through Host Board power system. The module will transmit/receive data over the air. Module can communicate with Host CPU using either UART/SPI interface as well through I/O pins. Ratings and System Details Operating Frequency 2400MHz – 2483.5MHz No. of channels 16 Channel Spacing 5MHz Modulation DSSS Transmitted Power 1.12 dBm Data Rate 250 kbps Antenna Type PCB Inverted F Antenna Number of antenna 1 Antenna Gain 2dBi Supply Voltage 2.7V – 3.6V Height: 21.72mm Dimensions Width: 20.96mm Temp: : -30 °C - +75 °C Environmental Humidity: 20-80% RHG Test Conditions: Voltage: 3.3 V DC Environmental conditions: Temperature: +23 º C RH: 62% Test Report No.: 01200091 001 Date: 14.08.2012 Page 5 of 27

www.tuv.com Test Set-up and Operation Mode Principle of Configuration Selection Transmission was enabled with highest possible duty cycle on low, mid and high channel. Test Operation and Test Software Test software was used to enable the transmission with highest possible duty cycle and channels in 2.4 GHz band on the EUT for the tests in this report. Special Accessories and Auxiliary Equipment - None Countermeasures to achieve EMC Compliance - None Table of carrier frequencies Frequency Frequency Band Channel No. (MHz) 11 2405 12 2410 13 2415 14 2420 15 2425 16 2430 17 2435 2400-2483.5 MHz 18 2440 19 2445 20 2450 21 2455 22 2460 23 2465 24 2470 25 2480 Test Report No.: 01200091 001 Date: 14.08.2012 Page 6 of 27

www.tuv.com Test Methodology Radiated Emission Test The radiated emission measurement was performed according to the procedures in ANSI C63.4-2003. The equipment under test (EUT) was placed at the middle of the 80 cm high turntable, and the EUT is 3 meters far from the measuring antenna. The turntable was rotated 360ﾟ for obtaining the maximum emission. The height of the measuring antennas was scanned between 1m and 4m, and the antenna rotated to repeat the measurements for both the horizontal and vertical antenna polarizations. Repeat the measurement steps until the maximum emissions were obtained. The measurement above 1000MHz was performed by horn antenna. The measurement below 30MHz was performed by loop antenna. The EUT was rotated around the X-, Y-, and Z-Axis and the results from worst case axis are recorded. Semi-anechoic Chamber 3m Pre-Amplifier Measuring Receiver / EUT Spectrum Analyzer Turntable Ground Plane Test Report No.: 01200091 001 Date: 14.08.2012 Page 7 of 27

www.tuv.com Test Results Maximum Conducted Peak Output Power Section 15.247(b) (3) Result Pass Test Specification FCC Part 15 Subpart C Measurement Bandwidth (RBW) 1 MHz Requirement <1 watt (30dBm). Test Method: EUT Spectrum Analyzer Test Result: Frequency Total Output Limit (MHz) power (dBm) (dBm) 2405 1.12 30.00 2440 0.64 30.00 2480 0.61 30.00 Test Report No.: 01200091 001 Date: 14.08.2012 Page 8 of 27

www.tuv.com Channel Frequency: 2405 MHz Channel Frequency: 2440 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 9 of 27

www.tuv.com Channel Frequency: 2480 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 10 of 27

www.tuv.com Power Spectral Density Section 15.247(e) Result Pass Test Specification FCC Part 15 Section 15.247 (e) Detector Function Peak For digitally modulated systems, the power spectral density conducted from the intentional radiator to the antenna shall not be greater than 8 dBm in any 3 kHz Requirement band during any time interval of continuous transmission. Test Method: EUT Spectrum Analyzer Test Result: Cable Loss: 0.88 dB Frequency Total PSD Limit (MHz) (dBm) (dBm) 2405 -9.47 8.00 2440 -11.03 8.00 2480 -9.65 8.00 Test Report No.: 01200091 001 Date: 14.08.2012 Page 11 of 27

www.tuv.com Channel Frequency: 2405 MHz Channel Frequency: 2440 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 12 of 27

www.tuv.com Channel Frequency: 2480 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 13 of 27

www.tuv.com 6 dB Bandwidth Section 15.247(a)(2) Result Pass Test Specification FCC Part 15 Section 15.247 (a) (2) Requirement The minimum 6 dB bandwidth shall be at least 500 kHz. Test Method: EUT Spectrum Analyzer Test Result: Carrier Lower Upper 6 dB OBW Frequency Frequency Frequency Bandwidth (MHz) (MHz) (MHz) (MHz) (MHz) 2405 2404.07 2405.72 1.65 2.62 2440 2439.07 2440.70 1.63 2.60 2480 2479.06 2480.70 1.64 2.60 Test Report No.: 01200091 001 Date: 14.08.2012 Page 14 of 27

www.tuv.com Channel frequency: 2405 MHz Channel frequency: 2440 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 15 of 27

www.tuv.com Channel frequency: 2480 MHz OBW Channel frequency: 2405 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 16 of 27

www.tuv.com OBW Channel frequency: 2440 MHz OBW Channel frequency: 2480 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 17 of 27

www.tuv.com Band-edge Compliance Section 15.247(d) Result Pass Test Specification FCC Part 15 Section 15.247(d) Detector Function Peak Requirement In any 100 kHz bandwidth outside the frequency band in which the spread spectrum or digitally modulated intentional radiator is operating, the radio frequency power that is produced by the intentional radiator shall be at least 20 dB below that in the 100 kHz bandwidth within the band that Contains the highest level of the desired power, based on either an RF conducted or a radiated measurement, and provided the transmitter demonstrates compliance with the peak conducted power limits. If the transmitter complies with the conducted power limits based on the use of RMS averaging over a time interval, as permitted under paragraph (b)(3) of this section, the attenuation required under this paragraph Shall be 30 dB instead of 20 dB. Test Method: EUT Spectrum Analyzer Test Result: Fundamental Value at Band Edge Limit Channel Frequency Frequency Value (dBc) (MHz) (MHz) (dBc) Low 2405 2400.00 -52.61 -20.00 High 2480 2483.50 -46.35 -20.00 Test Report No.: 01200091 001 Date: 14.08.2012 Page 18 of 27

www.tuv.com Channel frequency: 2405 MHz Channel frequency: 2480 MHz Conducted Spurious Emission Test Report No.: 01200091 001 Date: 14.08.2012 Page 19 of 27

www.tuv.com Channel frequency: 2405 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 20 of 27

www.tuv.com Channel frequency: 2440 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 21 of 27

www.tuv.com Channel frequency: 2480 MHz Test Report No.: 01200091 001 Date: 14.08.2012 Page 22 of 27

www.tuv.com Spurious Radiated Emissions and Restricted Bands of Operation Section 15.209 and 15.205 Result Pass Test Specification FCC Part 15 Section 15.209 &15.205 Test Method ANSI C63.4-2003 Measurement Location Semi Anechoic Chamber Measuring Distance 3m Detection QP for frequency below 1GHz, Peak and Average for frequency above 1GHz Requirement As per the limits mentioned in the bellow table Limit for Radiated Emission of Section 15.209: Frequency Field strength Field strength Distance of (MHz) (V/m) (dBV/m) Measurement (m) 0.009 – 0.490 2400/F(kHz) 48.50 – 13.80 300* 0.490 – 1.705 24000/F(kHz) 33.80 – 23.00 30* 1.705 -30 30 29.54 30* 30-88 100 40.0 3 88-216 150 43.5 3 216-960 200 46.0 3 Above 960 500 54.0 3 Remark: * the limit shows in the table above of frequency range 0.009 – 0.490, 0.490 – 1.705 MHz and 1.705-30MHz is at 300 meter, 30 meter and 30 meter range respectively, which corresponds to 88, 50 – 53.80, 53.80 – 43.00 and 49.5dBμV/m at 3m range by extrapolation calculation and the measurement of loop antenna. The emission limits shown in the above table are based on measurements employing a CISPR quasi-peak detector except for the frequency bands 9–90 kHz, 110–490 kHz and above 1000 MHz Radiated emission limits in these three bands are based on measurements employing an average detector. Test result: There were no emissions found in the frequency range below 1GHz and hence they are not reported. Test Report No.: 01200091 001 Date: 14.08.2012 Page 23 of 27

www.tuv.com Fundamental Spurious Field Antenna Limit Margin Frequency Emission Strength Polarization (dBµV/m) (dB) (MHz) (MHz) (dBµV/m) 2404.4 (Pk) 81.65 * - 2404.8 (Av) 75.76 * - 2389.3 (Pk) 47.23 74 -26.77 H 2390.0 (Av) 34.92 54 -19.08 4810.25 (Pk) 46.65 74 -27.35 4810.25 (Av) 35.64 54 -18.36 2405 2404.4 (Pk) 85.31 * - 2404.9 (Av) 79.91 * - 2388.5 (Pk) 47.61 74 -26.39 V 2389.8 (Av) 35.03 54 -18.97 4810.25 (Pk) 45.84 74 -28.16 4810.25 (Av) 34.72 54 -19.28 2440.3 (Pk) 85.62 * - 2440.3 (Av) 79.79 * - H 4878.5 (Pk) 49.45 74 -24.55 4880.2 (Av) 37.04 54 -16.96 2440 2440.3 (Pk) 87.05 * - 2440.0 (Av) 80.70 * - V 4882.1 (Pk) 48.51 74 -25.49 4879.6 (Av) 37.59 54 -16.41 2480.4 (Pk) 81.68 * - 2479.9 (Av) 74.88 * - 2483.5 (Pk) 46.97 74 -27.03 H 2483.5 (Av) 35.76 54 -18.24 4960.0 (Pk) 49.93 74 -24.07 4959.7 (Av) 38.37 54 -15.63 2480 2480.4 (Pk) 87.23 * - 2480.1 (Av) 81.35 * - V 2483.5 (Pk) 48.76 74 -25.24 2483.5 (Av) 37.09 54 -16.91 4960.3 (Pk) 50.30 74 -23.70 4959.8 (Av) 39.03 54 -14.97 * - --> Fundamental Frequency Pk--> Peak Detector Av--> Average Detector Test Report No.: 01200091 001 Date: 14.08.2012 Page 24 of 27

www.tuv.com Conducted Emission Test on a.c. Power Line Section 15.207 Result Pass Test Specification : FCC Part 15 Section 15.207 Test Method : ANSI C63.4-2003 Testing Location : Screened room Measurement Bandwidth : 9kHz Frequency Range : 150kHz – 30MHz Supply Voltage : 3V DC Limit of section 15.207 Frequency of QP Limit AV Limit emission (MHz) (dBµV) (dBμV/m) 0.15 – 0.5 66 – 56* 56 – 46* 0.5 – 5 56 46 5 – 30 60 50 * Decreases with the logarithm of the frequency Test Report No.: 01200091 001 Date: 14.08.2012 Page 25 of 27

www.tuv.com Test Result: Mode: Positive Test Report No.: 01200091 001 Date: 14.08.2012 Page 26 of 27

www.tuv.com Mode: Negative Test Report No.: 01200091 001 Date: 14.08.2012 Page 27 of 27


Document Created: 2012-10-25 14:56:20
Document Modified: 2012-10-25 14:56:20
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC