Test Report

FCC ID: PBR-SZHHG32D

Test Report

Download: PDF
FCCID_3741383


Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 2 von 17 Test Report No.: 19660356 001 Page 2 of 17 TABLE OF CONTENTS 1 TEST RESULT SUMMARY .................................................................................................................................. 3 TEST SITES ................................................................................................................................................................. 3 1.1 Testing Facilities ............................................................................................................................................ 3 1.2 List of Test and Measurement Instruments ................................................................................................... 4 2 GENERAL PRODUCT INFORMATION................................................................................................................ 4 2.1 Product Function and Intended Use .............................................................................................................. 4 2.2 Ratings and System Details .......................................................................................................................... 5 2.3 Measurement Uncertainty: ............................................................................................................................ 5 3 OPERATIONAL DESCRIPTIONS ........................................................................................................................ 6 4 TEST SET-UP AND OPERATION MODE ............................................................................................................ 6 4.1 Principle of Configuration Selection .............................................................................................................. 6 4.2 Test Operation and Test Software................................................................................................................. 6 4.3 Special Accessories and Auxiliary Equipment .............................................................................................. 6 4.4 Countermeasures to achieve EMC Compliance ........................................................................................... 6 5 TEST METHODOLOGY ....................................................................................................................................... 7 5.1 Radiated Emission Test ................................................................................................................................. 7 5.1.1 Test Setup Configuration .............................................................................................................................. 8 6 TEST RESULTS ................................................................................................................................................. 10 6.1 Restricted Spurious Emissions & Restricted Bands of Operation ............................................................... 10 6.2 Conducted Emission Test on A.C. Power Line ........................................................................................... 14 7 LIST OF TABLES................................................................................................................................................ 17 8 LIST OF FIGURES ............................................................................................................................................. 17 APPENDIX 1: TEST SETUP PHOTO APPENDIX 2: EUT EXTERNAL PHOTO APPENDIX 3: EUT INTERNAL PHOTO APPENDIX 4: FCC LABEL AND LABEL LOCATION APPENDIX 5: BLOCK DIAGRAM APPENDIX 6: SPECIFICATION OF EUT APPENDIX 7: SCHEMATIC DIAGRAMS APPENDIX 8: BILL OF MATERIAL APPENDIX 9: USER MANUAL APPENDIX 10: MAXIMUM PERMISSIBLE EXPOSURE INFORMATION Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 3 von 17 Test Report No.: 19660356 001 Page 3 of 17 1 TEST RESULT SUMMARY Table 1: Test result summary FCC Test Clause Test Item Results Remarks Maximum Peak 15.247 (b) (3) N/T Conducted Output Power This product 15.247 (a) (2) 6 dB / DTS Bandwidth N/T contains the certified module with FCC ID : Maximum Power Spectral PBR-SZMDLNR1 15.247 (e) N/T and the test Density results of the same are Emissions in non – excluded in the 15.247 (d) N/T restricted band report. Conducted Spurious 15.247 (a)(1) N/T Emissions Conducted emission on 15.407 Pass - A.C power lines Radiated Spurious FCC 15.209 , FCC 15.205 Emissions and Restricted Pass - bands of operation TEST SITES 1.1 Testing Facilities TUV Rheinland (India) Private Limited 108 , Beside ISBR Business School, Electronic city Phase I Bangalore - 560 100. Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 4 von 17 Test Report No.: 19660356 001 Page 4 of 17 1.2 List of Test and Measurement Instruments Table 2: List of Test and Measurement Instruments Model Serial Calibration Used for Test Equipment Manufacturer Periodicity Name Number Due Date Items Rohde & EMI Test Receiver ESU 40 100288 24-10-2018 Yearly Schwarz Active loop LAX-10- Frankonia LAX-10 13.04.2018 Yearly antenna 800 Schwarzbeck VHBB-9124 Biconical Antenna 9124-656 09.01.2018 Yearly mess - elektronik / BBA-9106 Spurious Log - Periodic Schwarzbeck VUSLP- Radiated 9111B-111 10.01.2018 Yearly Antenna mess - elektronik 9111B Emissions Broadband Horn Frankonia HAX-18 HAX18-802 16-03-2018 Yearly Antenna Emission Horn ETS Lindgren 116706 00107323 22.06.2018 Yearly Antenna Semi Anechoic Frankonia - - - - Chamber Rohde & EMI Test Receiver ESR7 101133 16.01.2018 Yearly Schwarz Conducted Emission on Two Line V- Rohde & AC Power ENV216 100022 05.09.2018 Yearly Network (LISN) Schwarz Lines 2 GENERAL PRODUCT INFORMATION 2.1 Product Function and Intended Use SRHHG32D has two ZigBee modules mounted on it. These ZigBee Modules are used for wireless data communication with other ZigBee device. It also has RGB graphic LCD , Keypad , Mic , Speaker , vibrating motor, 2D Barcode scanner and a VGA CMOS Imager for user interface . User can scan barcode and QR Code using 2D scanner and receive all information about product over wireless ZigBee network. And can able to see on RGB graphic LCD. Using Keypad we can able to add/remove item in cart list. Device can be use as walkie-talkie by using mic and speaker. Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 5 von 17 Test Report No.: 19660356 001 Page 5 of 17 2.2 Ratings and System Details Table 3: Ratings and System Details Operating Frequency Range 2400MHz – 2483.5MHz Radio Protocol ZigBee No. of channels 15 Channel Spacing 5 MHz Modulation DSSS Data Rate 250 kbps Number of antennas Two (One on each module) Antenna Gain & Type 3.27dBi Max & PCB Inverted F antenna Supply Voltage to Product 3.7V DC Temp: 5-45 ºC (41-113 ºF) Environmental conditions Humidity: 20-80% RHG Test Conditions: Voltage: 3.7 V DC Battery Supply Environmental conditions: Temperature: +23 °C RH: 62 % 2.3 Measurement Uncertainty: Table 4: Measurement Uncertaninty Parameter Uncertainty Occupied Channel Bandwidth ±5 % RF output power, conducted ±1.5 dB Power Spectral Density, conducted ±3 dB Unwanted Emissions, conducted ±3 dB All emissions, radiated ±6 dB Temperature ±3 ̊C Supply Voltages ±3 % Time ±5 % Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 6 von 17 Test Report No.: 19660356 001 Page 6 of 17 3 OPERATIONAL DESCRIPTIONS SRHHG32D (CC2530 based ZigBee Scanning Handheld) SRHHG32D is Battery operated hand held device. It can perform data transfer over air using on - Board ZigBee Modules. User can scan barcode of product and will get all information about that Product to device this information transfer over Wireless ZigBee network .Device can also use as walkie-talkie audio data also transfer over ZigBee network. Device can be used to take the images of the product which customer wants to report about. 4 TEST SET-UP AND OPERATION MODE 4.1 Principle of Configuration Selection Transmission was enabled on highest possible duty cycled transmission on low, mid and high channel on supporting datarates to obtain maximum emissions 4.2 Test Operation and Test Software Testing software was used to enable the continuous transmission on low/mid/high channels on the EUT for the tests in this report. 4.3 Special Accessories and Auxiliary Equipment - None 4.4 Countermeasures to achieve EMC Compliance - None Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 7 von 17 Test Report No.: 19660356 001 Page 7 of 17 Table 5: List of Centre Frequencies Frequency Frequency Band Channel No. (MHz) 11 2405 12 2410 13 2415 14 2420 15 2425 16 2430 17 2435 2400-2483.5 MHz 18 2440 19 2445 20 2450 21 2455 22 2460 23 2465 24 2470 25 2475 5 TEST METHODOLOGY 5.1 Radiated Emission Test The radiated emission measurement was performed according to the procedures in ANSI C63.10-2013. The equipment under test (EUT) was placed at the middle of the 80 cm high turntable for below 1 GHz & 1.5 m height for above 1 GHz measurement, and the EUT is 3 meters far from the measuring antenna. The turntable was rotated 360ﾟ for obtaining the maximum emission. The height of the measuring antennas was scanned between 1 m and 4 m, and the antenna rotated to repeat the measurements for both the horizontal and vertical antenna polarizations. Repeat the measurement steps until the maximum emissions were obtained. The measurement above 1000 MHz was performed by horn antenna, The measurement below 30 MHz was performed by loop antenna. The EUT was rotated around the X-, Y-, and Z-Axis and the results from worst case axis are recorded . Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 8 von 17 Test Report No.: 19660356 001 Page 8 of 17 5.1.1 Test Setup Configuration Figure 1: Frequency Range 9 KHz -30 MHz Semi-anechoic Chamber 3m Pre-Amplifier Measuring Receiver / EUT Spectrum Analyzer Turntable Ground Plane Figure 2: Frequency Range 30 MHz – 200 MHz Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 9 von 17 Test Report No.: 19660356 001 Page 9 of 17 Semi-anechoic 3m Pre-Amplifier Measuring Receiver / EUT Spectrum Analyzer Turntable Ground Plan Figure 3: Frequency Range 200 MHz - 1 GHz Figure 4: Frequency above 1 GHz Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 10 von 17 Test Report No.: 19660356 001 Page 10 of 17 6 TEST RESULTS 6.1 Restricted Spurious Emissions & Restricted Bands of Operation Result Pass Test Specification FCC 15.205, FCC 15.209 Test Method ANSI C63.10-2013 Measurement Location Semi Anechoic Chamber 9 KHz to 40 GHz (Up to 10th harmonic of the highest fundamental Measuring Frequency Range frequency) Measuring Distance 3m Detection QP for frequency below 1 GHz,Peak, Average for frequency above 1 GHz Requirement As per the limits mentioned in the below table Table 6: Limit for radiated emission measurement 15.209 Frequency Field strength Field strength Distance of (MHz) (V/m) (dBV/m) Measurement (m) 0.009 – 0.490 2400/F (KHz) 48.50 – 13.80 300* 0.490 – 1.705 24000/F (KHz) 33.80 – 23.00 30* 1.705 - 30 30 29.54 30* 30 - 88 100 40.0 3 88 - 216 150 43.5 3 216 - 960 200 46.0 3 Above 960 500 54.0 3 Remark: * The limit shows in the table above of frequency range 0.009 – 0.490, 0.490 – 1.705 MHz and 1.705-30MHz is at 300 meter, 30 meter and 30 meter range respectively, which corresponds to 128.51 – 93.80, 73.80 – 62.96 and 69.54 dBμV/m at 3m range by extrapolation calculation and the measurement of loop antenna. The emission limits shown in the above table are based on measurements employing a CISPR quasi- peak detector except for the frequency bands 9–90 kHz, 110–490 kHz and above 1000 MHz Radiated emission limits in these three bands are based on measurements employing an average detector. Test Conditions: Voltage: 3.7 V DC Battery Supply Environmental conditions: Temperature: +23 °C RH: 62 % Test results: Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 11 von 17 Test Report No.: 19660356 001 Page 11 of 17 No emission found for the frequency range 9 KHz to 30 MHz Test results for the frequency range 30 MHz to 1GHz are reported below. Table 7: Test results for frequency range 30 MHz to 1 GHz Measured Radiated Spurious Limit Margin Polarization Frequency Emission (MHz) (dBµV/m) (dBµV/m) (dB) 39.11 36.3 40 3.7 53.59 33.89 40 6.11 Vertical 72.1 33.17 40 6.83 216 39.15 43.5 4.35 32.32 32.12 40 7.88 216.04 32.78 43.5 10.72 Horizontal 359.99 33.54 46 12.46 768.07 42.92 46 3.08 Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 12 von 17 Test Report No.: 19660356 001 Page 12 of 17 Table 8: Test results for frequency range 1 GHz to 26.5 GHz Radiated Channel Measured Limit Spurious Margin Frequency Polarization Frequency Emission (dB) (MHz) (MHz) (dBµV/m) (dBµV/m) Test Configuration 1: Both modules operating at low channel 2390 (Pk) 46.4 74 27.6 2390 (Av) 30.02 54 23.98 2405 (Pk) 72.24 * - Vertical 2405 (Av) 64.41 * - 4810 (Pk) 49.61 74 24.39 4810 (Av) 37.22 54 16.78 2405 2390 (Pk) 41.17 74 32.83 2390 (Av) 26.74 54 27.26 2405 (Pk) 78.27 * - Horizontal 2405 (Av) 73.38 * - 4810 (Pk) 49.14 74 24.86 4810 (Av) 37.11 54 16.89 Test Configuration 2: Both modules operating at high channel 2483.5 (Pk) 42.01 74 31.99 2483.5 (Av) 29.38 54 24.62 2480 (Pk) 74.25 * - Vertical 2480 (Av) 68.95 * - 4960 (Pk) 49.58 74 24.42 4960 (Av) 36.55 54 17.45 2480 2483.5 (Pk) 42.22 74 31.78 2483.5 (Av) 32.75 54 21.25 2480 (Pk) 81.55 * - Horizontal 2480 (Av) 76.74 * - 4960 (Pk) 49.48 74 24.52 4960 (Av) 36.67 54 17.33 Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 13 von 17 Test Report No.: 19660356 001 Page 13 of 17 Channel Radiated Measured Frequency Spurious Limit Margin Polarization Frequency Emission (dBµV/m) (dB) (MHz) (MHz) (dBµV/m) Test Configuration 3: Both modules operating in different channels 2390(Pk) 50.74 74 23.26 2390(Av) 33.26 54 20.74 2405(Pk) 71.4 * - 2405(Av) 64.24 * - 2480(Pk) 75.66 * - 2480(Av) 70.54 * - V 2483.5(Pk) 42.09 74 31.91 2483.5(Av) 28.83 54 25.17 4810(Pk) 49.61 74 24.39 4810(Av) 37.24 54 16.76 Module1: 4960(Pk) 49.59 74 24.41 2405MHz 4960(Av) 37.47 54 16.53 Module2: 2390(Pk) 43.26 74 30.74 2480MHz 2390(Av) 28.35 54 25.65 2405(Pk) 80.56 * - 2405(Av) 75.59 * - 2480(Pk) 81.58 * - 2480(Av) 75.78 * - H 2483.5(Pk) 42.6 74 31.4 2483.5(Av) 31.96 54 22.04 4810(Pk) 49.14 74 24.86 4810(Av) 37.11 54 16.89 4960(Pk) 49.98 74 24.02 4960(Av) 37.27 54 16.73 Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 14 von 17 Test Report No.: 19660356 001 Page 14 of 17 6.2 Conducted Emission Test on A.C. Power Line Result Pass Test Specification : FCC Part 15 Section 15.207 Test Method : ANSI C63.10-2013 Testing Location : Screened room Measurement Bandwidth : 9kHz Frequency Range : 150kHz – 30MHz Supply Voltage : 120VAC,60Hz Limit of section 15.207 Frequency of QP Limit AV Limit emission (MHz) (dBµV) (dBμV/m) 0.15 – 0.5 66 – 56* 56 – 46* 0.5 – 5 56 46 5 – 30 60 50 * Decreases with the logarithm of the frequency Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 15 von 17 Test Report No.: 19660356 001 Page 15 of 17 Table 9: Test Result: LINE - Graphs and Tables Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 16 von 17 Test Report No.: 19660356 001 Page 16 of 17 Table 10: Test Result for Neutral - Graphs and Tables Test Datum / Date : 12/12/2017

Produkte www.tuv.com Products Prüfbericht - Nr.: Seite 17 von 17 Test Report No.: 19660356 001 Page 17 of 17 7 LIST OF TABLES Table 1: Test result summary ........................................................................................................................................... 3 Table 2: List of Test and Measurement Instruments ........................................................................................................ 4 Table 3: Ratings and System Details ............................................................................................................................... 5 Table 4: Measurement Uncertaninty ................................................................................................................................ 5 Table 5: List of Centre Frequencies ................................................................................................................................. 7 Table 6: Limit for radiated emission measurement 15.209 ............................................................................................ 10 Table 7: Test results for frequency range 30 MHz to 1 GHz .......................................................................................... 11 Table 8: Test results for frequency range 1 GHz to 26.5 GHz ....................................................................................... 12 Table 9: Test Result: LINE - Graphs and Tables ........................................................................................................... 15 Table 10: Test Result for Neutral - Graphs and Tables ................................................................................................. 16 8 LIST OF FIGURES Figure 1: Frequency Range 9 KHz -30 MHz .................................................................................... 8 Figure 2: Frequency Range 30 MHz – 200 MHz ............................................................................. 8 Figure 3: Frequency Range 200 MHz - 1 GHz ............................................................................... 9 Figure 4: Frequency above 1 GHz ................................................................................................... 9 ***END OF TEST REPORT*** Test Datum / Date : 12/12/2017


Document Created: 2019-10-01 21:54:50
Document Modified: 2019-10-01 21:54:50
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC