Test report

FCC ID: NO9PMNTU4

Test Report

Download: PDF
FCCID_113699

Report of Equipment Authorization for the PMNTU Transmitter Certified under the FCC Rules contained in Title 47 of the CFR, Part 15, Subpart B 15.249 for 902 - 928 MHz Operation MET REPORT EMI1308F August 16, 2000 PREPARED FOR: HBC-Radiomatic Haller Strasse 49-53 D-74564 Crailsheim Germany PREPARED BY: MET Laboratories, Inc. 914 West Patapsco Avenue Baltimore, Maryland 21230-3432

August 16, 2000 HBC-Radiomatic Haller Strasse 49-53 D-74564 Crailsheim Attention: Juergen Schneider Regarding: Certification of the PMNTU Transmitter under Part 15, Subpart B of the FCC Rules as a Transmitter MET Report: EMI1308F Dear Juergen Schneider: Enclosed is a report of of compliance in accordance with FCC Part 15, Subpart B of Title 47 of the Code of Federal Regulations, Section 15.209 and 15.249 for the PMNTU Transmitter. Based on these results, MET Laboratories, Inc. certifies that the PMNTU Transmitter, tested as configured, meets the requirements and interference limitations contained in Section 15.209 and 15.249 under Part 15, Subpart B of Title 47 of the Code of Federal Regulations. If you have any questions concerning this report or your responsibilities as a manufacturer of Certified equipment, please contact us at your convenience. Thank you for using MET's testing services. Sincerely, MET Laboratories, Inc. Tony Permsombut Project Engineer

Report of Equipment Authorization for the PMNTU Transmitter Certified under the FCC Rules contained in Title 47 of the CFR, Part 15, Subpart B 15.249 for 902-928 MHz Operation MET REPORT EMI1308F August 16, 2000 PREPARED FOR: HBC-Radiomatic Haller Strasse 49-53 D-74564 Crailsheim Germany PREPARED BY: MET Laboratories, Inc. 914 West Patapsco Avenue Baltimore, Maryland 21230-3432 Test Engineer: ________________________________ Tony Permsombut Report Writer: ________________________________ Joanna Kolasinski Reviewed by: ________________________________ Chris Harvey EMI Laboratory Director August 16, 2000 -2- EMI1308F

TABLE OF CONTENTS COVER LETTER LEGAL STATEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 EXHIBIT 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 MANUFACTURER & PRODUCT INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 ENGINEERING STATEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 EXHIBIT 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 TEST SITE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 MEASUREMENT PROCEDURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 INSTRUMENTATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 TEST CONFIGURATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 PHOTOGRAPH OF RADIATED EMISSIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 EXHIBIT 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 Radiated Emissions Low Oscillator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Radiated Emissions Mid-Oscillator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Radiated Emissions High Oscillator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 August 16, 2000 -3- EMI1308F

LEGAL STATEMENT While use of the National Voluntary Laboratory Accreditation Program (NVLAP) letters or the NVLAP Logo in this report reflects the MET Accreditation under the NVLAP Program, these letters, logo, or Statements do not claim product endorsement by NVLAP or any Agency of the U.S. Government. Certificates and reports shall not be reproduced except in full, without the written permission of MET Laboratories, Inc. August 16, 2000 -4- EMI1308F

EXHIBIT 1 MANUFACTURER & PRODUCT INFORMATION ENGINEERING STATEMENT August 16, 2000 -5- EMI1308F

MANUFACTURER & PRODUCT INFORMATION TYPE OF AUTHORIZATION: Certification for Transmitter FCC IDENTIFIER: NO9PMNTU4 APPLICABLE FCC RULES: 2.907; 2.103 to 2.1041; 15.209 ; 15.249 CLIENT: HBC-Radiomatic Haller Strasse 49-53 D-74564 Crailsheim Germany EQUIPMENT: PMNTU Transmitter TESTING DATE(S): 3/10/00 ENGINEERING STATEMENT I ATTEST: the measurements shown in this report were made in accordance with the procedures indicated, and that the emissions from this equipment were found to be within the limits applicable. I assume full responsibility for the accuracy and completeness of these measurements, and for the qualifications of all persons taking them. I FURTHER ATTEST: on the basis of the measurements made, the equipment tested is capable of operation in accordance with the requirements of Part 15 of the FCC Rules under normal use and maintenance. ______________________ Tony Permsombut Project Engineer August 16, 2000 -6- EMI1308F

EXHIBIT 2 INTRODUCTION TEST SITE MEASUREMENT PROCEDURES INSTRUMENTATION TEST CONFIGURATION MODIFICATIONS STATEMENT PHOTOGRAPHS August 16, 2000 -7- EMI1308F

INTRODUCTION An EMI evaluation to determine compliance of the PMNTU Transmitter with the requirements of Part 15, Subpart B was conducted. (All references are to the most current version of Title 47 of the Code of Federal Regulations in effect). In accordance with §2.955(a)(3), the following data is presented in support of the certification of the PMNTU Transmitter. HBC-Radiomatic should retain a copy of this document should be kept on file for at least two years after the manufacturing of the PMNTU Transmitter has been permanently discontinued, as per §2.955(b). TEST SITE All testing was conducted at MET Laboratories, Inc., 914 West Patapsco Avenue, Baltimore, Maryland 21230- 3432. Radiated emissions measurements were performed on an open area test site (OATS). In accordance with §2.948(a)(3), a complete site description is contained at MET Laboratories. In accordance with §2.948(d), MET Laboratories has been accredited by the National Voluntary Laboratory Accreditation Program (Lab Code: 100273-0) MEASUREMENT PROCEDURES As required by §15.209, radiated emissions measurements were made in accordance with the general procedures of ANSI C63.4-1992 "Methods of Measurement of Radio-Noise Emissions from Low-Voltage Electrical and Electronic Equipment in the Range of 9kHz to 40 GHz". The measurements were performed over the frequency range of 30 MHz to 10 GHz using broadband antennas as the input transducer to a spectrum analyzer. The measurements were made with the detector set for "quasi-peak" within a bandwidth of 120 kHz for emissions below 1 GHz. A preliminary RF scan was performed in an RF-shielded enclosure. As per §15.249 , operation within the bands 902-928 MHz : (a) the field strength of the emissions from intentional radiators operated within these frequency bands shall comply with the following : Fundamental Field Strength of fundamental Field Strength of harmonics Frequency (millivolts/meter) (microvolts/meter) 902 -928 MHz 50 500 (b) Field strength limit is specified at a distance of 3 meters using quasi-peak detector at 120 kHz bandwidth. (c) Emissions radiated outside of the specified frequency bands, except for harmonics, shall be attenuated by at least 50 dB below the level of the fundamental or to the general radiated emissions limits in §15.209, whichever is the lesser attenuation. (d) As shown in §15.35(b), for frequencies above 1000 MHz , the above field strength limits are based on average limits. However, the peak field strength of any emission shall not exceed the maximum permitted average limits specified above by more than 20 dB under any condition of modulation. MODIFICATIONS STATEMENT No modifications were made during testing. INSTRUMENTATION Radiated emissions measurements were made using the following equipment: August 16, 2000 -8- EMI1308F

Nomenclature Manufacturer Model MET # Cal Due Spectrum Analyzer Hewlett Packard 8593EM 1U0002 10/29/00 Pre-Amplifier Hewlett Packard 8449B 1U0027 12/28/00 Bilog Antenna Schaffner-Chase CBL6140A 1U0040 4/30/00 Horn Antenna EMCO 3115 1U0037 2/5/01 Test Room Lundgreen Fact4 1U0032 5/19/00 Description of EUT The EUT is a transmitter that consists of a battery-operated transmitter with an integral antenna housing with an emergency-stop push button and various position controls. The transmitter is used to control hydraulic cranes or machines. The EUT operates at various frequencies from the low of 902.075 MHz to a high of 918.128 MHz (center of channels) which are selected by utilizing individual reference oscillators. August 16, 2000 -9- EMI1308F

TEST CONFIGURATION Figure 1. Test Configuration Block Diagram August 16, 2000 - 10 - EMI1308F

EUT and Support Equipment Description Manufacturer Model# HBC-radiomatic Case PM Switches Various HBC-radiomatic Mainboard HBC-radiomatic 72.11.039 Transmitter FuS 10 AA HBC-radiomatic Battery HBC-radiomatic FuB 10 AA August 16, 2000 - 11 - EMI1308F

Photograph of Radiated Emissions Test Configuration PMNTU Transmitter August 16, 2000 - 12 - EMI1308F

EXHIBIT 3 TEST DATA August 16, 2000 - 13 - EMI1308F

SUBJECT: Radiated Emissions MET REPORT: EMI1308F Low Oscillator MFG: HBC-Radiomatic TESTED BY: Tony Persombut FCC Part 15 TEST DATE: 3/10/00 EUT: PMNTU Transmitter TECHNICAL SPECIFICATION: 15.209 and 15.249 3m10 Frequency (MHz) Limit (dBµV) @ 3m 30 - 88 40.00 88 - 216 43.52 216 - 230 46.00 230 - 960 46.00 960 - 10000 54.00 *902 - 928 94.00 *Note: This is the limit for the fundamental frequency. Frequency Azimuth Pola Height Raw Pre-Amp Corrected Limit r-ity Amplitude Gain (MHz) E CCW - 0E (E E =EUT (m) Amplitude F V/m) (dBF facing ant.) F V) (dBF (dB) F V/m) (dBF @3m @3m 100.63 0 H 1 30.76 27.2 3.6 43.5 100.63 288 V 1 31.54 27.2 4.3 43.5 160.5 0 H 1 32.95 27 6 43.5 160.5 160 V 1 33.05 27 6 43.5 251.5 0 H 1 34.73 26.5 8.2 46 251.5 0 V 1 35.09 26.5 8.5 46 545.3 0 H 1 42.39 27.9 14.5 46 545.3 0 V 1 43.93 27.9 16 46 51 0 H 1 31.72 27.38 4.3 40 51 0 V 1 31.5 27.38 4.1 40 902.075 145 H 1 113.95 27.08 86.9 94 902.075 84 V 1.05 117.95 27.08 90.9 94 August 16, 2000 - 14 - EMI1308F

Frequency Azimuth Polar- Height Raw Pre- Ant. Cable Dist. Corrected Limit ity Amplitude Amp Corr. Loss (GHz) (m) Gain (dB/m) (dB) Corr. Amplitude F V/m) (dBF F V) (dBF (dB) Factor F V/m) (dBF @3m @1m (dB) @3m 1m to 3m 1.804 135 H 1 54.36 34.9 26.18 1.4 -9.54 37.5 54 1.804 90 V 1 58.1 34.9 26.06 1.4 -9.54 41.1 54 *2.706 240 H 1.05 48.92 34.73 28.98 1.89 -9.54 35.5 54 *2.706 80 V 1.03 57.83 34.73 28.87 1.89 -9.54 44.3 54 *3.608 0 H 1.07 55.49 34.7 31.96 2.28 -9.54 45.5 54 *3.608 180 V 1.03 50.92 34.7 31.92 2.28 -9.54 40.9 54 *4.51 315 H 1 51.78 34.6 32.52 3.01 -9.54 43.2 54 *4.51 225 V 1 51.07 34.6 32.52 3.01 -9.54 42.5 54 *5.412 225 H 1 45.1 34.5 34.64 3.76 -9.54 39.5 54 *5.412 315 V 1 43.75 34.5 34.8 3.76 -9.54 38.3 54 10 0 H 1 29.7 34.7 38.5 9.7 -9.54 33.7 54 10 0 V 1 29.79 34.7 38.4 9.7 -9.54 33.7 54 * Meets restricted band limits of 15.205 Note: The EUT was tested at 1m. The data has been corrected for comparison with the 3m limit using the formula: 20log(1m/3m) as expressed in the 'Dist. Corr. Factor' column. Equipment meets the specifications of Part 15.209 and 15.249 August 16, 2000 - 15 - EMI1308F

SUBJECT: Radiated Emissions MET REPORT: EMI1308F Mid- Oscillator MFG: HBC-Radiomatic TESTED BY: Tony Permsombut FCC Part 15 TEST DATE: 3/10/00 EUT: PMNTU Transmitter TECHNICAL SPECIFICATION: 15.209 and 15.249 3m10 Frequency (MHz) Limit (dBµV) @ 3m 30 - 88 40.00 88 - 216 43.52 216 - 230 46.00 230 - 960 46.00 960 - 10000 54.00 *902 - 928 94.00 *Note: This is the limit for the fundamental frequency Frequency Azimuth Pola Height Raw Pre-Amp Corrected Limit r-ity Amplitude Gain (MHz) E CCW - 0E (E E =EUT (m) Amplitude F V/m) (dBF facing ant.) F V) (dBF (dB) F V/m) (dBF @3m @3m 50.09 0 H 1 31.65 27.39 4.3 40 50.09 0 V 1 31.29 27.39 3.9 40 100.62 0 H 1 30.63 27.2 3.4 43.5 100.62 0 V 1 31.36 27.2 4.2 43.5 160 0 H 1 33.35 27 6.4 43.5 160 0 V 1 33.38 27 6.4 43.5 207.5 174 H 1.21 33.21 26.7 6.5 43.5 207.5 34 V 1 32.51 26/7 5.8 43.5 310 0 H 1 35.62 26.53 9.1 46 310 92 V 1 35.81 26.53 9.3 46 911.7 144 H 1.5 113.7 27.01 86.7 94 911.7 82 V 1.16 117.77 27.01 90.8 94 August 16, 2000 - 16 - EMI1308F

Frequency Azimuth Polar- Height Raw Pre- Ant. Cable Dist. Corrected Limit ity Amplitude Amp Corr. Loss (GHz) (m) Gain (dB/m) (dB) Corr. Amplitude F V/m) (dBF F V) (dBF (dB) Factor F V/m) (dBF @3m @1m (dB) @3m 1m to 3m 1.824 135 H 1 53.38 34.9 26.28 1.4 -9.54 36.6 54 1.824 90 V 1 57.3 34.9 26.16 1.4 -9.54 40.4 54 *2.736 225 H 1.06 52.25 34.72 29.1 1.92 -9.54 39 54 *2.736 90 V 1 56.8 34.72 28.99 1.92 -9.54 43.9 54 *3.647 0 H 1.08 53.69 34.7 32.05 2.29 -9.54 43.8 54 *3.647 180 V 1.05 51.51 34.7 31.99 2.29 -9.54 47.3 54 *4.559 315 H 1.03 54.1 34.6 32.61 3.07 -9.54 45.6 54 *4.559 135 V 1 48.77 34.6 32.61 3.07 -9.54 40.3 54 *5.471 190 H 1.03 45.17 34.5 34.81 3.79 -9.54 39.7 54 *5.471 315 V 1.06 45.89 34.5 35 3.79 -9.54 40.6 54 10 0 H 1 29.65 34.7 38.5 9.7 -9.54 33.6 54 10 0 V 1 29.30 34.7 38.4 9.7 -9.54 33.2 54 * - Meets Restricted Band limits of 15.205 Note: The EUT was tested at 1m. The data has been corrected for comparison with the 3m limit using the formula: 20log(1m/3m) as expressed in the 'Dist. Corr. Factor' column. Equipment meets the specifications of Part 15.209 and 15.249 August 16, 2000 - 17 - EMI1308F

SUBJECT: Radiated Emissions MET REPORT: EMI1308F High Oscillator MFG: HBC-Radiomatic TESTED BY: Tony Permsombut FCC Part 15 TEST DATE: 2/24/00 EUT: PMNTU Transmitter TECHNICAL SPECIFICATION: 15.209 and 15.249 3m10 Frequency (MHz) Limit (dBµV) @ 3m 30 - 88 40.00 88 - 216 43.52 216 - 230 46.00 230 - 960 46.00 960 – 10000 54.00 *902 - 928 94.00 Note: This is the limit for the fundamental frequency. Frequency Azimuth Polar- Height Raw Pre- Corrected Limit ity Amplitude Amp (MHz) E CCW - 0E (E E =EUT (m) Gain Amplitude F V/m) (dBF facing ant.) F V) (dBF (dB) F V/m) (dBF @3m @3m @3m 58.09 0 H 1 31.74 27.33 4.4 43.5 58.09 0 V 1 31.59 27.33 4.3 43.5 99.7 0 H 1 30.9 27.2 3.7 43.5 99.7 0 V 1 31.67 27.2 4.5 43.5 159.5 250 H 1.09 32.97 27 6 46 159.5 0 V 1 33.06 27 6.1 46 255.5 0 H 1 34.76 26.5 8.3 46 255.5 0 V 1 34.59 26.5 8.1 46 399.8 0 H 1 39.74 27.32 12.4 46 399.8 0 V 1 38.98 27.32 11.7 46 918.128 19 H 1.28 112.45 27 85.5 94 918.128 89 V 1.09 117.2 27 90.2 94 August 16, 2000 - 18 - EMI1308F

Frequency Azimuth Polar- Height Raw Pre- Ant. Cable Dist. Corrected Limit ity Amplitude Amp Corr. Loss (GHz) (m) Gain (dB/m) (dB) Corr. Amplitude F V/m) (dBF F V) (dBF (dB) Factor F V/m) (dBF @3m @1m (dB) @3m 1m to 3m 1.836 135 H 1 53.89 34.9 26.35 1.4 -9.54 37.2 54 1.836 70 V 1.03 56.56 34.9 26.21 1.4 -9.54 39.7 54 *2.754 225 H 1 46.66 34.71 29.17 1.93 -9.54 33.5 54 *2.754 80 V 1 61.42 34.71 29.07 1.93 -9.54 48.2 54 *3.672 225 H 1.06 55.98 34.7 32.11 2.3 -9.54 46.2 54 *3.672 180 V 1.14 51.91 34.7 32.04 2.3 -9.54 42 54 *4.590 190 H 1.08 51.94 34.59 32.66 3.11 -9.54 43.6 54 *4.590 280 V 1.20 45.59 34.59 32.66 3.11 -9.54 37.2 54 5.508 225 H 1 46.26 34.5 34.9 3.8 -9.54 40.9 54 5.508 225 V 1 45.4 34.5 34.9 3.8 -9.54 40.3 54 10 0 H 1 29.82 34.7 38.5 9.7 -9.54 33.8 54 10 0 V 1 30.08 34.7 38.5 9.7 -9.54 33.9 54 * Meets Restriced Band limits of 15.205 Note: The EUT was tested at 1m. The data has been corrected for comparison with the 3m limit using the formula: 20log(1m/3m) as expressed in the 'Distance Correction' column. Equipment meets the specifications of Part 15.209 and 15.249 August 16, 2000 - 19 - EMI1308F


Document Created: 2000-08-16 14:33:05
Document Modified: 2000-08-16 14:33:05
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC