USERS MANUAL

FCC ID: NLB49013TX

Users Manual

Download: PDF

FCCID_634858

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com TABLE OF CONTENTS LIST APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB49013TX TEST REPORT CONTAINING: PAGE 1.............TEST EQUIPMENT LIST PAGE 2.............TEST PROCEDURE PAGE 3.............RADIATION INTERFERENCE TEST DATA PAGE 4.............OCCUPIED BANDWIDTH PAGE 5.............OCCUPIED BANDWIDTH PLOT EXHIBITS INCLUDING: BLOCK DIAGRAM SCHEMATIC INSTRUCTION MANUAL LABEL SAMPLE LABEL LOCATION EXTERNAL PHOTOGRAPHS INTERNAL PHOTOGRAPHS CIRCUIT DESCRIPTION TEST SET UP PHOTOGRAPH APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB49013TX REPORT #: D\DICKIE\219UT6\219UT6TestReport.doc TABLE OF CONTENTS$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com Equipment List Device Manufacturer Model Serial Cal/Char Due Date Number Date 3/10-Meter TEI N/A N/A Listed 3/26/07 OATS 3/27/04 3-Meter TEI N/A N/A Listed 1/10/09 OATS 1/11/06 Biconnical Eaton 94455-1 1057 CAL 12/12/07 Antenna 12/12/05 Biconnical Eaton 94455-1 1096 CAL 8/17/06 Antenna 8/17/04 Biconnical Electro- BIA-25 1171 CAL 4/29/07 Antenna Metrics 4/29/05 Blue Tower HP 85650A 2811A01279 CAL 4/13/07 Quasi-Peak 4/13/05 Adapter Blue Tower HP 85685A 2926A00983 CAL 9/5/07 RF 9/5/05 Preselector Blue Tower HP 8568B 2928A04729 CAL 4/13/07 Spectrum 2848A18049 4/13/05 Analyzer LISN Electro- ANS-25/2 2604 CAL 8/27/06 Metrics 8/27/04 LISN Electro- EM-7820 2682 CAL 4/28/07 Metrics 4/28/05 Log- Eaton 96005 1243 CAL 12/14/07 Periodic 12/14/05 Antenna APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB49013TX REPORT #: D\DICKIE\219UT6\219UT6TestReport.doc Page 1 of 5$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com TEST PROCEDURE GENERAL: This report shall NOT be reproduced except in full without the written approval of TIMCO ENGINEERING, INC. RADIATION INTERFERENCE: The test procedure used was ANSI STANDARD C63.4-2003 using a HEWLETT PACKARD spectrum analyzer with a pre-selector. The bandwidth of the spectrum analyzer was 100 kHz with an appropriate sweep speed. The analyzer was calibrated in dB above a microvolt at the output of the antenna. The resolution bandwidth was 100 kHz and the video bandwidth was 300 kHz. The ambient temperature of the UUT was 80ºC with a humidity of 76%. FORMULA OF CONVERSION FACTORS: The Field Strength at 3m was established by adding the meter reading of the spectrum analyzer (which is set to read in units of dBuV) to the antenna correction factor supplied by the antenna manufacturer. The antenna correction factors are stated in terms of dB. The gain of the Pre- selector was accounted for in the Spectrum Analyzer Meter Reading. Example: Freq (MHz) METER READING + ACF = FS 33 20 dBuV + 10.36 dB = 30.36 dBuV/m @ 3m ANSI STANDARD C63.4-2003 10.1.7 MEASUREMENT PROCEDURES: The unit under test was placed on a table 80 cm high and with dimensions of 1m by 1.5m. The table used for radiated measurements is capable of continuous rotation. When an emission was found, the table was rotated to produce the maximum signal strength. At this point, the antenna was raised and lowered from 1m to 4m. The antenna was placed in both the horizontal and vertical planes. APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB49013TX REPORT #: D\DICKIE\219UT6\219UT6TestReport.doc Page 2 of 5$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB49013TX NAME OF TEST: RADIATION INTERFERENCE RULES PART NO.: 15.235 REQUIREMENTS: CARRIER FREQUENCY WILL NOT EXCEEDS 80 dBuV/m AT 3M. OUT-OF-BAND EMISSIONS SHALL NOT EXCEED: 30 - 88 MHz 40.0 dBuV/M MEASURED AT 3 METERS 88 - 216 MHz 43.5 dBuV/M 216 - 960 MHz 46.0 dBuV/M ABOVE 960 MHz 54.0 dBuV/M TEST DATA: Tuned Emission Meter Ant. Coax Correction Field Margin Frequency Frequency Reading Polarity Loss Factor Strength dB MHz MHz dBuV dB dB dBuV/m 49.9 49.86 46.1 H 0.97 11.20 58.27 21.73 49.9 49.86 59.0 V 0.97 11.07 71.04 8.96 49.9 99.72 17.2 H 1.40 11.38 29.98 13.52 49.9 99.72 18.5 V 1.40 11.55 31.45 12.05 49.9 199.40 12.0 V 2.10 17.22 31.32 12.18 49.9 199.40 12.3 H 2.10 17.32 31.72 11.78 SAMPLE CALCULATION: FSdBuV/m = MR (dBuV) + ACFdB. Emissions attenuated more than 20 dB below the permissible value are not reported. TEST PROCEDURE: The procedure used was ANSI STANDARD C63.4-2003. The spectrum was scanned from 30 MHz to 1000 MHz. When an emission was found, the table was rotated to produce the maximum signal strength. The antenna was placed in both the horizontal and vertical planes and the worse case emissions were reported. The UUT was tested in 3 orthogonal planes. PERFORMED BY: RICHARD BLOCK DATE: 2/28/2006 APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB49013TX REPORT #: D\DICKIE\219UT6\219UT6TestReport.doc Page 3 of 5$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB49013TX NAME OF TEST: Occupied Bandwidth RULES PART NO.: 15.235 REQUIREMENTS: The field strength of any emissions appearing between the band edges and up to 10 kHz above and below the band edges shall be attenuated at least 26 dB below the level of the un-modulated carrier or to the general limits of 15.209, whichever permits the higher emission levels. THE GRAPH ON THE NEXT PAGE REPRESENTS THE EMISSIONS TAKEN FOR THE DEVICE. METHOD OF MEASUREMENT: A small sample of the transmitter output was fed into the spectrum analyzer and the attached plot was taken. The vertical scale is set to 10 dB per division. PERFORMED BY: RICHARD BLOCK DATE: 2/28/06 APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB49013TX REPORT #: D\DICKIE\219UT6\219UT6TestReport.doc Page 4 of 5$

Document Created: 2006-03-06 16:01:14
Document Modified: 2006-03-06 16:01:14