TEST REPORT

FCC ID: NLB27058TX

Test Report

Download: PDF

FCCID_740638

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com Test Report Product Name: 27MHz REMOTE CONTROL TRANSMITTER FCC ID: NLB27058TX Applicant: DICKIE-SPIELZEUG GmbH & CO KG WERKSTRABE 1 D-90765 FUERTH D-90765 GERMANY Date Receipt: 12/6/2006 Date Tested: 12/11/2006 APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX REPORT #: D\DICKIE\3327UT6\3327UT6TestReport.doc COVER SHEET$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com TABLE OF CONTENTS LIST APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX TEST REPORT CONTAINING: PAGE 1...............TEST EQUIPMENT LIST PAGE 3...............TEST PROCEDURE PAGE 4...............RADIATION INTERFERENCE TEST DATA PAGE 5...............OCCUPIED BANDWIDTH PAGE 6...............OCCUPIED BANDWIDTH PLOT PAGE 7…............TEST SET UP PHOTO EXHIBITS INCLUDING: BLOCK DIAGRAM SCHEMATIC INSTRUCTION MANUAL LABEL SAMPLE LABEL LOCATION EXTERNAL PHOTOGRAPHS INERNAL PHOTOGRAPHS OPERATIONAL DESCRIPTION TEST SET UP PHOTOGRAPHS APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX REPORT #: D\DICKIE\3327UT6\3327UT6TestReport.doc TABLE OF CONTENTS$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com EMC Equipment List Device Manufacturer Model Serial Number Cal/Char Date Due Date 3/10-Meter TEI N/A N/A Listed 3/27/04 3/26/07 OATS 3-Meter OATS TEI N/A N/A Listed 1/11/06 1/10/09 Antenna: Eaton 94455-1 1057 CAL 12/12/05 12/12/07 Biconnical Antenna: Eaton 94455-1 1096 CAL 10/11/06 10/11/08 Biconnical Antenna: Electro-Metrics BIA-25 1171 CAL 4/29/05 4/29/07 Biconnical Analyzer Blue HP 85650A 2811A01279 CAL 4/13/05 4/13/07 Tower Quasi- Peak Adapter Analyzer Blue HP 85685A 2926A00983 CAL 9/5/05 9/5/07 Tower RF Preselector Analyzer Blue HP 8568B 2928A04729 CAL 4/13/05 4/13/07 Tower 2848A18049 Spectrum Analyzer LISN Electro-Metrics ANS-25/2 2604 CAL 10/5/06 10/5/08 LISN Electro-Metrics EM-7820 2682 CAL 4/28/05 4/28/07 Antenna: Log- Eaton 96005 1243 CAL 12/14/05 12/14/07 Periodic Antenna: ETS-Lindgren 6502 00062529 CAL 3/30/06 3/30/08 Active Loop Antenna: EMC Test EMCO 6512 9706-1211 CAL 4/27/06 4/27/08 Passive Loop Systems APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX REPORT #: D\DICKIE\3327UT6\3327UT6TestReport.doc Page 2 of 7$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com TEST PROCEDURE GENERAL: This report shall NOT be reproduced except in full without the written approval of TIMCO ENGINEERING, INC. RADIATION INTERFERENCE: The test procedure used was ANSI standard C63.4-2003 using a spectrum analyzer with a preselector. The bandwidth of the spectrum analyzer was 100 kHz with an appropriate sweep speed. The analyzer was calibrated in dB above a microvolt at the output of the antenna. The resolution bandwidth was 100 kHz and the video bandwidth was 300 kHz. The ambient temperature of the UUT was 80ºC with a humidity of 76%. FORMULA OF CONVERSION FACTORS: The field strength at 3m was established by adding the meter reading of the spectrum analyzer (which is set to read in units of dBuV) to the antenna correction factor supplied by the antenna manufacturer. The antenna correction factors are stated in terms of dB. The gain of the preselector was accounted for in the spectrum analyzer meter reading. Example: Freq (MHz) METER READING + CL + ACF = FS 33 20 dBuV + 1.00 + 10.36 dB = 30.36 dBuV/m @ 3m ANSI STANDARD C63.4-2003 10.1.7 MEASUREMENT PROCEDURES: The unit under test was placed on a table 80 cm high and with dimensions of 1m by 1.5m. The table used for radiated measurements is capable of continuous rotation. When an emission was found, the table was rotated to produce the maximum signal strength. At this point, the antenna was raised and lowered from 1m to 4m. The antenna was placed in both the horizontal and vertical planes. APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX REPORT #: D\DICKIE\3327UT6\3327UT6TestReport.doc Page 3 of 7$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX NAME OF TEST: RADIATION INTERFERENCE RULES PART NO.: 15.227 REQUIREMENTS: CARRIER FREQUENCY WILL NOT EXCEEDS 80 dBuV/m AT 3M. OUT-OF-BAND EMISSIONS SHALL NOT EXCEED: 30 - 88 MHz 40.0 dBuV/M MEASURED AT 3 METERS 88 - 216 MHz 43.5 dBuV/M 216 - 960 MHz 46.0 dBuV/m ABOVE 960 MHz 54.0 dBuV/m TEST DATA: Emission Meter Ant. Coax Correction Field Margin Frequency Reading Polarity Loss Factor Strength dB MHz dBuV dB dB dBuV/m 27.15 67.2 H 0.80 7.40 75.40 4.60 54.20 16.7 H 1.01 10.07 27.78 12.22 54.20 27.4 V 1.01 9.51 37.92 2.08 81.40 19.2 H 1.24 8.64 29.08 10.92 81.40 20.0 V 1.24 8.74 29.98 10.02 108.50 11.2 H 1.46 10.29 22.95 20.55 108.50 13.1 V 1.46 10.82 25.38 18.12 135.70 15.2 V 1.65 14.94 31.79 11.71 135.70 18.3 H 1.65 14.34 34.29 9.21 162.80 12.4 H 1.84 16.26 30.50 13.00 162.80 17.5 V 1.84 17.23 36.57 6.93 190.00 18.4 V 2.03 14.50 34.93 8.57 190.00 24.3 H 2.03 14.10 40.43 3.07 217.10 4.1 H 2.19 11.59 17.88 28.12 217.10 8.2 V 2.19 11.46 21.85 24.15 244.30 7.1 H 2.32 12.17 21.59 24.41 244.30 7.1 V 2.32 12.16 21.58 24.42 271.40 3.3 V 2.46 13.27 19.03 26.97 271.40 3.8 H 2.46 13.24 19.50 26.50 All measurements below 30 MHz were taken using a Loop Antenna. TEST PROCEDURE: The procedure used was ANSI standard C63.4-2003. The spectrum was scanned from the fundamental to 1000 MHz. When an emission was found, the table was rotated to produce the maximum signal strength. The antenna was placed in both the horizontal and vertical planes and the worse case emissions were reported. The UUT was tested in 3 orthogonal planes. PERFORMED BY: RICHARD BLOCK DATE: 12/11/2006 APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX REPORT #: D\DICKIE\3327UT6\3327UT6TestReport.doc Page 4 of 7$

$TIMCO ENGINEERING INC. 849 NW State Road 45 Newberry, Florida 32669 http://www.timcoengr.com 888.472.2424 F 352.472.2030 email: tei@timcoengr.com APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX NAME OF TEST: Occupied Bandwidth RULES PART NO.: 15.227 REQUIREMENTS: The field strength of any emissions appearing outside of 26.96 and 27.28MHz shall be attenuated to the general limits of 15.209. TEST DATA: THE GRAPH ON THE NEXT PAGE REPRESENTS THE EMISSIONS TAKEN FOR THE DEVICE. METHOD OF MEASUREMENT: A small sample of the transmitter output was fed into the spectrum analyzer and the attached plot was taken. The vertical scale is set to 10 dB per division. PERFORMED BY: RICHARD BLOCK DATE: 12/11/06 APPLICANT: DICKIE-SPIELZEUG GmbH & CO KG FCC ID: NLB27058TX REPORT #: D\DICKIE\3327UT6\3327UT6TestReport.doc Page 5 of 7$

Document Created: 2006-12-15 13:18:05
Document Modified: 2006-12-15 13:18:05