Test Report

FCC ID: NLB24057TX

Test Report

Download: PDF
FCCID_4180056

Produkte Products Prüfbericht-Nr.: 50216463 001 Auftrags-Nr.: 158100104 Seite 1 von 14 Test Report No.: Order No.: Page 1 of 14 Kunden-Referenz-Nr.: N/A Auftragsdatum: 10.01.2019 Client Reference No.: Order date: Auftraggeber: Dickie Toys Hong Kong Ltd. Client: 19/F., Prudential Tower, The Gateway, Harbour City, 21 Canton Road, Tsimshatsui, Kowloon, Hong Kong Prüfgegenstand: Short Range Device - Radio Controlled Toy Transmitter (2.4GHz) Test item: Bezeichnung / Typ-Nr.: 24057 Identification / Type No.: Auftrags-Inhalt: FCC Certification Order content: Prüfgrundlage: FCC Part 15 Subpart C Test specification: ANSI C63.10-2013 Wareneingangsdatum: 08.01.2019 Date of receipt: Prüfmuster-Nr.: A000864582-010 Test sample No.: Prüfzeitraum: 10.01.2019 – 17.01.2019 Testing period: Ort der Prüfung: Hong Kong Place of testing: Prüflaboratorium: TÜV Rheinland Hong Kong Testing laboratory: Ltd. Prüfergebnis*: Pass Test result*: geprüft von / tested by: kontrolliert von / reviewed by: Joey Leung Sharon Li 22.02.2019 Project Manager 22.02.2019 Unit Senior Manager Datum Name / Stellung Unterschrift Datum Name / Stellung Unterschrift Date Name / Position Signature Date Name / Position Signature Sonstiges FCC ID: NLB24057TX Other: Zustand des Prüfgegenstandes bei Anlieferung: Prüfmuster vollständig und unbeschädigt Condition of the test item at delivery: Test item complete and undamaged * Legende: 1 = sehr gut 2 = gut 3 = befriedigend 4 = ausreichend 5 = mangelhaft P(ass) = entspricht o.g. Prüfgrundlage(n) F(ail) = entspricht nicht o.g. Prüfgrundlage(n) N/A = nicht anwendbar N/T = nicht getestet Legend: 1 = very good 2 = good 3 = satisfactory 4 = sufficient 5 = poor P(ass) = passed a.m. test specification(s) F(ail) = failed a.m. test specification(s) N/A = not applicable N/T = not tested Dieser Prüfbericht bezieht sich nur auf das o.g. Prüfmuster und darf ohne Genehmigung der Prüfstelle nicht auszugsweise vervielfältigt werden. Dieser Bericht berechtigt nicht zur Verwendung eines Prüfzeichens. This test report only relates to the a. m. test sample. Without permission of the test center this test report is not permitted to be duplicated in extracts. This test report does not entitle to carry any test mark. TÜV Rheinland Hong Kong Ltd. 3-4, 11/F., Fou Wah Industrial Building, 10-16 Pun Shan Street, Tsuen Wan, N.T., Hong Kong Tel.: +852 2192 1000 Fax: +852 2192 1001 Email service-gc@tuv.com Web: www.tuv.com

www.tuv.com Table of Content Page Cover Page ............................................................................................................................... 1 Table of Content ...................................................................................................................... 2 Product information................................................................................................................ 4 Manufacturers declarations ................................................................................................................................ 4 Product function and intended use.................................................................................................................... 4 Submitted documents ......................................................................................................................................... 4 Independent Operation Modes ........................................................................................................................... 4 Related Submittal(s) Grants ................................................................................................................................ 4 Remark .................................................................................................................................................................. 4 Test Set-up and Operation Mode ........................................................................................... 5 Principle of Configuration Selection .................................................................................................................. 5 Test Operation and Test Software ..................................................................................................................... 5 Special Accessories and Auxiliary Equipment ................................................................................................. 5 Countermeasures to achieve EMC Compliance ............................................................................................... 5 Test Methodology ................................................................................................................... 6 Radiated Emission ............................................................................................................................................... 6 Field Strength Calculation .................................................................................................................................. 6 Test Setup Diagram ................................................................................................................ 7 Test Facility ............................................................................................................................. 8 Test Laboratory Information ............................................................................................................................... 8 List of Test and Measurement Instruments .......................................................................... 9 Measurement Uncertainty .................................................................................................... 10 Results FCC Part 15 – Subpart C ........................................................................................ 11 FCC 15.203 – Antenna Requirement 1 ........................................................................................... Pass ........ 11 FCC 15.204 – Antenna Requirement 2 ........................................................................................... Pass ........ 11 FCC 15.207 – Conducted Emission on AC Mains ......................................................................... N/A........... 11 Subclause 15.215 (c) – 20 dB Bandwidth ...................................................................................... Pass ........ 11 Subclause 15.249 (a) – Field Strength of Fundamental and Harmonics .................................... Pass ........ 12 Subclause 15.249 (d), 15.205 – Out Of Band Radiated Emission ................................................ Pass ........ 14 Appendix 1 – Test protocols ...................................................................................................................... 3 pages Appendix 2 – Test setup ............................................................................................................................ 3 pages Appendix 3 – EUT External Photos ........................................................................................................... 4 pages Test Report No.: 50216463 001 Date: 22.02.2019 Page 2 of 14

www.tuv.com Appendix 4 – EUT Internal Photos ............................................................................................................ 3 pages Appendix 5 – RF exposure information .................................................................................................... 2 pages Test Report No.: 50216463 001 Date: 22.02.2019 Page 3 of 14

www.tuv.com Product information Manufacturers declarations Transmitter Operating frequency range 2403 - 2481MHz Type of modulation GFSK Number of channels 79 Type of antenna Wire Antenna Power level fix Connection to public utility power line No Nominal voltage 3.0V, 2 x 1.5V AAA size battery Product function and intended use The equipment under test (EUT) is a radio control toy transmitter operating at 2.4GHz. It is powered by battery only. FCC ID: NLB24057TX Models Product description Short Range Device - Radio Controlled Toy Transmitter 24057 (2.4GHz) Submitted documents Circuit Diagram Block Diagram Technical Description User manual Label Independent Operation Modes The basic operation modes are: - Transmitting mode. For further information refer to User Manual Related Submittal(s) Grants This is a single application for certification of the transmitter. Remark The test results in this test report are only relevant to the tested sample and does not involve any assessment in the production. Test Report No.: 50216463 001 Date: 22.02.2019 Page 4 of 14

www.tuv.com Test Set-up and Operation Mode Principle of Configuration Selection Emission: The equipment under test (EUT) was configured to measure its highest possible radiation level. The test modes were adapted accordingly in reference to the instructions for use. Test Operation and Test Software Test operation should refer to test methodology. - During test, RF channel & power was set and loaded into the RF IC by the customer. These settings shall be fixed on the firmware of the final end product. Special Accessories and Auxiliary Equipment - Nil. Countermeasures to achieve EMC Compliance - Nil. Test Report No.: 50216463 001 Date: 22.02.2019 Page 5 of 14

www.tuv.com Test Methodology Radiated Emission The radiated emission measurements of the transmitter part were performed according to the procedures in ANSI C63.10-2013. For measurement below 1GHz - the equipment under test (EUT) was placed at the middle of the 80 cm height turntable. For measurement above 1GHz - the EUT was placed at the middle of the 1.5 m height turntable and RF absorbing material was placed on ground plane between turntable and measuring antenna. During the testing, the EUT was operated standalone and arranged for maximum emissions. The EUT was tested in three orthogonal planes. The investigation is performed with the EUT rotated 360 ﾟ, the antenna height scanned between 1m and 4m, and the antenna rotated to repeat the measurements for both the horizontal and vertical antenna polarizations. Repeat the measurement steps until the maximum emissions were obtained. All radiated tests were performed at an antenna to EUT with 3 meters distance, unless stated otherwise in particular parts of this test report. Field Strength Calculation The field strength at 3 m was established by adding the meter reading of the spectrum analyzer to the factors associated with antenna correction factor, cable loss, preamplifiers and filter attenuation. The equation is expressed as follow: FS = R + AF + CF + FA – PA Where FS = Field Strength in dBuV/m at 3 meters. R = Reading of Spectrum Analyzer in dBuV. AF = Antenna Factor in dB. CF = Cable Attenuation Factor in dB. FA = Filter Attenuation Factor in dB. PA = Preamplifier Factor in dB. FA and PA are only be used for the measuring frequency above 1 GHz. Test Report No.: 50216463 001 Date: 22.02.2019 Page 6 of 14

www.tuv.com Test Setup Diagram Diagram of Measurement Configuration for Radiation Test Note: Measurements above 1 GHz are done with a table height of 1.5m. In addition, there is RF absorbing material on the floor of the test site for above 1GHz measurement. Diagram of Measurement Equipment Configuration for Mains Conduction Measurement (if applicable) Test Report No.: 50216463 001 Date: 22.02.2019 Page 7 of 14

www.tuv.com Test Facility Test Laboratory Information TÜV Rheinland Hong Kong Ltd. Address: 3-4, 11/F., Fou Wah Industrial Building, 10-16 Pun Shan Street, Tsuen Wan, N.T., Hong Kong Tel.: +852 2192 1000 Fax: +852 2192 1001 Email service-gc@tuv.com Web: www.tuv.com The test facility is recognized or accredited by the following organizations: FCC Type : Accredited Test Firm Designation Number : HK0013 Test Firm Registration Number : 371735 Scope : Intentional Radiators Industry Canada The 10m Semi-anechoic chamber used by TÜV Rheinland Hong Kong Ltd at Hong Kong Productivity Council has been registered by Certification and Engineering Bureau of Industry Canada for radio equipment testing Test Site Registration Number : 4780A-1 Test Report No.: 50216463 001 Date: 22.02.2019 Page 8 of 14

www.tuv.com List of Test and Measurement Instruments Hong Kong Productivity Council (FCC Registration number: 90656) Radiated Emission Cal. Due Equipment Manufacturer Type S/N Cal. Date Date Semi-anechoic Frankonia Nil Nil 23 Apr 2018 23 Apr 2019 Chamber Test Receiver R&S ESU40 100190 12 Jun 2018 12 Jun 2019 Bi-conical Antenna R&S HK116 100241 21 Mar 2018 21 Mar 2020 Log Periodic Antenna R&S HL223 841516/017 22 Mar 2018 22 Mar 2020 CNM- Cable with I-Joint Huber+Suhner NMCMILX800- A2803 #0001 11 Dec 2017 11 Dec 2019 Conector 473 Active Loop Antenna EMCO 6502 9107-2651 25 Oct 2018 25 Oct 2019 Semi-anechoic Chamber Frankonia Nil Nil 17 May 2018 17 May 2019 (SiteVSWR) Double-Ridged EMCO 3116 00109210 05 Oct 2018 05 Oct 2020 Waveguide Horn Double-Ridged EMCO 3117 00094998 30 Aug 2018 29 Aug 2020 Waveguide Horn Microwave amplifer 0.5-26.5GHz, 25dB HP 83017A 3950M00241 18 Jul 2018 17 Jul 2020 gain Preamplifier 18GHz to 40GHz with cable A.H. Systems, Inc. PAM-1840VH 168 29 Jan 2019 29 Jan 2020 (EMC656) High Pass Filter (cutoff freq. Trilithic 23042 9829213 30 Oct 2017 30 Oct 2019 =1000MHz) High Frequency PE3VNA4001- 20160707C0 Pasternack 29 Jan 2019 29 Jan 2020 Cable 3M 2493 Horn Antenna EMCO 3115 9002-3347 28 Mar 2018 28 Mar 2020 TÜV Rheinland Hong Kong Ltd Radio Test Cal. Due Equipment Manufacturer Type S/N Cal. Date Date Spectrum Analyzer R&S FSP30 100610 03 May 2018 02 May 2019 Test Report No.: 50216463 001 Date: 22.02.2019 Page 9 of 14

www.tuv.com Measurement Uncertainty The estimated combined standard uncertainty for power-line conducted emissions measurements is ±2.42dB. The estimated combined standard uncertainty for radiated emissions measurements is ±4.81dB (9kHz to 30MHz) and ±4.62dB (30MHz to 200MHz) and ±5.67dB (200MHz to 1000MHz) and is ±5.07dB (1GHz to 8.2GHz) and ±4.58dB (8.2GHz to 12.4GHz) and ±4.78dB (12.4GHz to 18GHz) The reported expanded uncertainty of measurement is stated as the standard uncertainty of measurement multiplied by the coverage factor of k=2, which for the level of confidence is approximately 95%. Test Report No.: 50216463 001 Date: 22.02.2019 Page 10 of 14

www.tuv.com Results FCC Part 15 – Subpart C FCC 15.203 – Antenna Requirement 1 Pass FCC requirement: No antenna other than that furnished by the responsible party shall be used with the device Results: a) Antenna type: Fixed Integral wire antenna b) Manufacturer and model no: N/A c) Peak Gain: 1.0 dBi Verdict: Pass FCC 15.204 – Antenna Requirement 2 Pass FCC requirement: An intentional radiator may be operated only with the antenna with which it is authorized. If an antenna is marketed with the intentional radiator, it shall be of a type which is authorized with the intentional radiator. Results: Only one integral antenna can be used. Verdict: Pass FCC 15.207 – Conducted Emission on AC Mains N/A There is no AC power input or output ports on the EUT. Subclause 15.215 (c) – 20 dB Bandwidth Pass Test specification : ANSI C63.10 – 2013 Test date : 10.01.2019 Mode of operation : Tx mode Port of testing : Temporary antenna port Supply voltage : 3.0V, 2 x 1.5V AAA size battery Temperature : 23ºC Humidity : 50% Requirement: The intentional radiators must be designed to ensure that the 20dB bandwidth of the emission, is contained within the frequency band designated in the rule section under which the equipment is operated. Results: Pre-scan has been conducted to determine the worst-case mode from all possible combinations between available modulations and packet types. For test protocols refer to Appendix 1. Frequency 20 dB left Limit 20 dB right Limit (MHz) (MHz) (MHz) (MHz) (MHz) 2403 2402.400 > 2400 2404.570 < 2483.5 2441 2439.650 > 2400 2441.690 < 2483.5 2481 2479.420 > 2400 2481.720 < 2483.5 Test Report No.: 50216463 001 Date: 22.02.2019 Page 11 of 14

www.tuv.com Subclause 15.249 (a) – Field Strength of Fundamental and Harmonics Pass Test specification : ANSI C63.10 – 2013 Test date : 17.01.2019 Mode of operation : Tx mode Port of testing : Enclosure Frequency range : 9kHz – 25GHz Supply voltage : 3.0V, 2 x 1.5V AAA size battery Temperature : 23ºC Humidity : 50% Requirement: The field strength of emissions from intentional radiators operated within these frequency bands shall comply with the following limit. Results: PASS. Fundamental Frequency 2403MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2403.198 86.6 114.0 / PK 2403.198 75.8 94.0 / AV Fundamental Frequency 2403MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2403.179 82.8 114.0 / PK 2403.179 72.1 94.0 / AV Harmonics 2403MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 4805.846 55.2 74.0 / PK 4805.846 41.0 54.0 / AV Harmonics 2403MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 4805.846 54.6 74.0 / PK 4805.846 40.4 54.0 / AV 7208.576 51.3 74.0 / PK 7208.576 36.3 54.0 / AV Fundamental Frequency 2441MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2441.043 85.4 114.0 / PK 2441.043 74.6 94.0 / AV Fundamental Frequency 2441MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2441.182 84.9 114.0 / PK 2441.182 74.0 94.0 / AV Test Report No.: 50216463 001 Date: 22.02.2019 Page 12 of 14

www.tuv.com Harmonics 2441MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 4881.857 54.2 74.0 / PK 4881.857 40.2 54.0 / AV Harmonics 2441MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 4881.852 55.2 74.0 / PK 4881.852 41.0 54.0 / AV 7322.666 51.7 74.0 / PK 7322.666 36.5 54.0 / AV Fundamental Frequency 2481MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2481.179 81.5 114.0 / PK 2481.179 70.6 94.0 / AV Fundamental Frequency 2481MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2481.195 82.7 114.0 / PK 2481.195 71.8 94.0 / AV Harmonics 2481MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 4961.855 55.1 74.0 / PK 4961.855 40.8 54.0 / AV Harmonics 2481MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 4961.855 56.8 74.0 / PK 4961.855 42.5 54.0 / AV 7442.679 51.1 74.0 / PK 7442.679 36.3 54.0 / AV Test Report No.: 50216463 001 Date: 22.02.2019 Page 13 of 14

www.tuv.com Subclause 15.249 (d), 15.205 – Out Of Band Radiated Emission Pass Test specification : ANSI C63.10 – 2013 Test date : 17.01.2019 Mode of operation : Tx mode Port of testing : Enclosure Frequency range : 9kHz – 25GHz Supply voltage : 3.0V, 2 x 1.5V AAA size battery Temperature : 23ºC Humidity : 50% Requirement: Emissions radiated outside of the specified frequency bands, except for harmonics, shall be attenuated by at least 50dB below the level of the fundamental or to the general radiated emission limits in Section 15.209, whichever is the lesser attenuation. Results: All three transmit frequency modes comply with the field strength limit of section 15.209. There is no spurious found below 30MHz. Tx frequency 2403MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2400.000 51.3 74.0 / PK 2400.000 25.7 54.0 / AV Tx frequency 2403MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2400.000 47.1 74.0 / PK 2400.000 24.2 54.0 / AV Tx frequency 2441MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m No peak found --- 74.0 / PK No peak found --- 54.0 / AV Tx frequency 2441MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m No peak found --- 74.0 / PK No peak found --- 54.0 / AV Tx frequency 2481MHz Vertical Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2483.500 53.3 74.0 / PK 2483.500 25.0 54.0 / AV Tx frequency 2481MHz Horizontal Polarization Freq Level Limit/ Detector MHz dBuV/m dBuV/m 2483.500 53.1 74.0 / PK 2483.500 25.1 54.0 / AV Test Report No.: 50216463 001 Date: 22.02.2019 Page 14 of 14


Document Created: 2019-02-22 16:19:47
Document Modified: 2019-02-22 16:19:47
© 2025 FCC.report
This site is not affiliated with or endorsed by the FCC