Test Report

FCC ID: NDPEM-300

Test Report

Download: PDF
FCCID_3334854

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 RADIO TEST REPORT Applicant : Partner Tech Corp. 10FL, 233-2, Baoqiao Road, Xindian, Address : New Taipei City, Taiwan Equipment : Mobile POS Terminal Model No. : EM-300 Trade Name : PARTNER FCC ID : NDPEM-300 I HEREBY CERTIFY THAT : The sample was received on Jan. 24, 2017 and the testing was carried out on Feb. 08, 2017 at Cerpass Technology Corp. The test result refers exclusively to the test presented test model / sample. Without written approval of Cerpass Technology Corp., the test report shall not be reproduced except in full. Approved by: Tested by: Mark Liao / Assistant Manager Spree Yei / Engineer Laboratory Accreditation: Cerpass Technology Corporation Test Laboratory Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 1 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 Contents 1. Summary of Test Procedure and Test Results.................................................................................4 1.1. Applicable Standards .................................................................................................................4 2. Test Configuration of Equipment under Test ...................................................................................5 2.1. Feature of Equipment under Test...............................................................................................5 2.2. Carrier Frequency of Channels ..................................................................................................5 2.3. Test Mode and Test Software.....................................................................................................5 2.4. Description of Test System.........................................................................................................5 2.5. General Information of Test........................................................................................................6 3. Test Equipment and Ancillaries Used for Tests ...............................................................................7 4. Antenna Requirements.......................................................................................................................8 4.1. Standard Applicable ...................................................................................................................8 4.2. Antenna Construction and Directional Gain...............................................................................8 5. Test of AC Power Line Conducted Emission ...................................................................................9 5.1. Test Limit ....................................................................................................................................9 5.2. Test Procedures .........................................................................................................................9 5.3. Typical Test Setup ....................................................................................................................10 5.4. Test Result and Data ................................................................................................................ 11 5.5. Test Photographs .....................................................................................................................13 6. Test of Radiated Emission ...............................................................................................................14 6.1. Test Limit ..................................................................................................................................14 6.2. Test Procedures .......................................................................................................................15 6.3. Typical Test Setup Layout of Radiated Emission .....................................................................16 6.4. Test Result and Data ................................................................................................................17 6.5. Test Photographs (30MHz ~ 1GHz) .........................................................................................24 6.6. Test Photographs (1GHz ~ 10GHz) .........................................................................................25 7. Frequency Stability ...........................................................................................................................26 7.1. Test Procedure .........................................................................................................................26 7.2. Test Setup Layout ....................................................................................................................26 7.3. Test Result and Data ................................................................................................................27 Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 2 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 History of this test report Report No. Issue Date Description TEFO1611252 Feb. 15, 2017 Original Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 3 of 27 FCC ID : NDPEM-300

o Lo CERPASS TECHNOLOGY CORP. Report No.: TEFO1G11252 1. Summary of Test Procedure and Test Results 1.1. Applicable Standards ansi conarzore FCC Rules and Regulations Part 15 Subpart C §15.249 FCC Ruta Description of Test Resut 15.203 Antenna Requirement pass 15.207 Conducted Emission pass 15205 1 adiated E Emission Rediated P ass 15.225(e) Frequency Stabilty Pass Corpass Technology Corg. Issued date Feb. 15, 2017 Torase8 4220808 FarBGs3 9220—001 Page No. a of2r ree NoreM.soo

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 2. Test Configuration of Equipment under Test 2.1. Feature of Equipment under Test Frequency Range 2402-2480 MHz Modulation Type ASK Antenna Type / gain Printed Antenna / 1.0 dBi 2.2. Carrier Frequency of Channels Channel Frequency(MHz) *1 13.56 Note: Channel remarked “*” is selected to perform test. 2.3. Test Mode and Test Software a. During testing, the interface cables and equipment positions were varied according to ANSI C63.4. b. The complete test system included EUT for RF test. c. An executive program,”RFDemo V2.03” was executed to transmit and receive data via NFC. d. The test mode of RF test as follow: Test Mode 1. 13.56MHz 2.4. Description of Test System The EUT was tested alone. No support devices are needed for testing. Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 5 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 2.5. General Information of Test Cerpass Technology Corporation Test Laboratory Address: No.10, Ln. 2, Lianfu St., Luzhu Dist., Taoyuan City 33848, Taiwan (R.O.C.) Tel:+886-3-3226-888 Fax:+886-3-3226-881 Test Site Address: No.68-1, Shihbachongsi, Shihding Township, New Taipei City 223, Taiwan, R.O.C. Tel: +886-2-2663-8582 FCC TW1079, TW1061,390316, 228391, 641184 IC 4934E-1, 4934E-2 T-2205 for Telecommunication Test C-4663 for Conducted emission test VCCI R-4399, R-4218 for Radiated emission test G-812, G-813 for radiated disturbance above 1GHz Cerpass Technology (Suzhou) Co., Ltd Address: No.66,Tangzhuang Road, Suzhou Industrial Park, Jiangsu 215006, China Tel: +86-512-6917-5888 Fax: +86-512-6917-5666 Test Site FCC 916572, 331395 IC 7290A-1, 7290A-2 T-1945 for Telecommunication Test C-2919 for Conducted emission test VCCI R-2670 for Radiated emission test G-227 for radiated disturbance above 1GHz Frequency Range Investigated: Conducted: from 150kHz to 30 MHz Radiation: from 30 MHz to 10,000MHz The test distance of radiated emission from antenna to Test Distance: EUT is 3 M. Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 6 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 3. Test Equipment and Ancillaries Used for Tests Instrument Model No. Manufacturer Serial No. Calibration Date Valid Date EMI Receiver R&S ESCI3 100443 2016/03/28 2017/03/27 LISN Schwarzbeck NSLK 8127 8127-740 2016/08/30 2017/08/29 LISN Schwarzbeck NSLK 8127 8127-516 2016/09/06 2017/09/05 Pulse Limiter R&S ESH3-Z2 101934 2016/03/09 2017/03/08 Bilog Antenna Schwarzbeck VULB9168 369 2016/03/22 2017/03/21 Active Loop EMCO 6507 40855 2016/05/11 2017/05/10 Antenna Horn Antenna EMCO 3115 31601 2016/09/05 2017/09/04 Horn Anrenna EMCO 3116 31970 2016/03/18 2017/03/17 EXA Signal KEYSIGHT N9010A MY54200207 2016/03/16 2017/03/15 Analyzer Preamplifier EM EM330 60660 2016/03/16 2017/03/15 EMC EMC051845S Preamplifier 980333 2016/09/13 2017/09/12 INSTRUMENTS E Preamplifier Agilent 8449B 3008A01954 2016/03/04 2017/03/03 AMF-7D-0010 Preamplifier MITEQ 1860212 2016/03/16 2017/03/15 100-30-10P EMC Preamplifier EMC184045 980065 2016/11/04 2017/11/03 INSTRUMENTS MXG MW Analog Signal KEYSIGHT N5183A MY50142931 2016/03/18 2017/03/17 Generator Spectrum R&S FSP40 100219 2016/09/01 2017/08/31 Analyzer BLUETOOTH R&S CBT 101133 2016/03/18 2017/03/17 TESTER Attenuator KEYSIGHT 8491B MY39250703 2016/03/07 2017/03/06 Rotary Agilent 8494B MY42154466 2016/03/08 2017/03/07 Attenuator Rotary Agilent 8495B MY42146680 2016/03/08 2017/03/07 Attenuator Temp & Humi T-MACHINE TMJ-9712 T-12-040111 2016/09/05 2017/09/04 chamber Series Power Anritsu ML2495A 1224005 2016/03/03 2017/03/02 Meter Power Sensor Anritsu MA2411B 1207295 2016/03/03 2017/03/02 HUBER SUCOFLEX Cable 28422/2 2016/03/15 2017/03/14 SUHNER 102 HUBER SUCOFLEX Cable 28418/2 2016/03/16 2017/03/15 SUHNER 102 HUBER SUCOFLEX Cable 28417/2 2016/03/04 2017/03/03 SUHNER 102 Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 7 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 4. Antenna Requirements 4.1. Standard Applicable For intentional device, according to FCC 47 CFR Section 15.203, an intentional radiator shall be designed to ensure that no antenna other than that furnished by the responsible party shall be used with the device. And according to FCC 47 CFR Section 15.249, if transmitting antennas of directional gain greater than 6dBi are used, the power shall be reduced by the amount in dB that the directional gain of the antenna exceeds 6dBi. 4.2. Antenna Construction and Directional Gain Antenna Type Antenna Gain Printed Antenna 1.0 dBi Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 8 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 5. Test of AC Power Line Conducted Emission 5.1. Test Limit Conducted Emissions were measured from 150 kHz to 30 MHz with a bandwidth of 9 KHz, according to the methods defined in ANSI C63.4-2014. The EUT was placed on a nonmetallic stand in a shielded room 0.8 meters above the ground plane. The interface cables and equipment positioning were varied within limits of reasonable applications to determine the position produced maximum conducted emissions. Frequency Quasi Peak Average (MHz) (dB µ V) (dB µ V) 0.15 – 0.5 66-56* 56-46* 0.5 – 5.0 56 46 5.0 – 30.0 60 50 *Decreases with the logarithm of the frequency. 5.2. Test Procedures a. The EUT was placed 0.4 meter from the conducting wall of the shielding room was kept at least 80 centimeters from any other grounded conducting surface. b. Connect EUT to the power mains through a line impedance stabilization network (LISN). c. All the support units are connecting to the other LISN. d. The LISN provides 50 ohm coupling impedance for the measuring instrument. e. The FCC states that a 50 ohm, 50 micro-Henry LISN should be used. f. Both sides of AC line were checked for maximum conducted interference. g. The frequency range from 150 kHz to 30 MHz was searched. h. Set the test-receiver system to Peak Detect Function and Specified Bandwidth with Maximum Hold Mode. Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 9 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 5.3. Typical Test Setup 10cm EUT Adapter 80cm 80cm AC Line 80cm 40cm LISN LISN 40cm Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 10 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 5.4. Test Result and Data Power : AC 120V Pol/Phase : LINE Test Mode : Mode 1 Temperature : 19 °C Test Date : Feb. 08, 2017 Humidity : 62 % Note: Level = Reading + Factor Margin = Level – Limit Factor = (LISN, ISN, PLC or current probe) Factor + Cable Loss+ Attenuator Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 11 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 Power : AC 120V Pol/Phase : NEUTRAL Test Mode : Mode 1 Temperature : 19 °C Test Date : Feb. 08, 2017 Humidity : 62 % Note: Level = Reading + Factor Margin = Level – Limit Factor = (LISN, ISN, PLC or current probe) Factor + Cable Loss+ Attenuator Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 12 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 6. Test of Radiated Emission 6.1. Test Limit (a) The field strength of any emissions within the band 13.553-13.567 MHz shall not exceed 15,848 microvolts/meter at 30 meters. (b) Within the bands 13.410-13.553 MHz and 13.567-13.710 MHz, the field strength of any emissions shall not exceed 334 microvolts/meter at 30 meters. (c) Within the bands 13.110-13.410 MHz and 13.710-14.010 MHz the field strength of any emissions shall not exceed 106 microvolts/meter at 30 meters. (d) The field strength of any emissions appearing outside of the 13.110-14.010 MHz band shall not exceed the general radiated emission limits in §15.209. Frequency (MHz) Distance Limit (μV/ m) 0.09 ~ 0.490 300m 2400/F(kHz) 0.490 ~ 1.705 30m 24000/ F(kHz) 1.705 ~ 30 30m 30 30 ~ 88 3m 100 88 ~ 216 3m 150 216 ~ 960 3m 200 Above 960 3m 500 15.215 Additional provisions to the general radiated emission limitations.: (c) Intentional radiators operating under the alternative provisions to the general emission limits, as contained in §§15.217 through 15.257 and in subpart E of this part, must be designed to ensure that the 20 dB bandwidth of the emission, or whatever bandwidth may otherwise be specified in the specific rule section under which the equipment operates, is contained within the frequency band designated in the rule section under which the equipment is operated. Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 14 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 6.2. Test Procedures a. The EUT was placed on a rotatable table top 0.8 meter above ground. b. The EUT was set 3 meters from the interference receiving antenna which was mounted on the top of a variable height antenna tower. c. The table was rotated 360 degrees to determine the position of the highest radiation. d. The antenna is a broadband antenna and its height is varied between one meter and four meters above ground to find the maximum value of the field strength both horizontal polarization and vertical polarization of the antenna are set to make the measurement. e. For each suspected emission the EUT was arranged to its worst case and then tune the antenna tower (from 1 M to 4 M) and turn table (from 0 degree to 360 degrees) to find the maximum reading. f. Set the test-receiver system to Peak or CISPR quasi-peak Detect Function and specified bandwidth with Maximum Hold Mode. g. If the emission level of the EUT in peak mode was 3 dB lower than the limit specified, then testing will be stopped and peak values of EUT will be reported, otherwise, the emissions which do not have 3 dB margin will be repeated one by one using the quasi-peak method and reported. h. “Cone of radiation” has been considered to be 3dB beamwidth of the measurement antenna. NOTE: 1. The resolution bandwidth of test receiver/spectrum analyzer is 300Hz or CISPS 200Hz(QP detector) at frequency Below 150 kHz. 2. The resolution bandwidth of test receiver/spectrum analyzer is 10KHz or CISPS 9KHz(QP detector) at frequency 150 kHz to 30 MHz. 3. The resolution bandwidth and video bandwidth of test receiver/spectrum analyzer is 120kHz for Peak detection (PK) and Quasi-peak detection (QP) at frequency below 1GHz. Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 15 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 6.3. Typical Test Setup Layout of Radiated Emission Below 30MHz test setup Antenna Equipment under Test 1m * 3m 0.8M Turn Ground Plane Receiver Below 1GHz Test Setup Antenna Equipment under Test * 3m 0.8M Turn Table Ground Plane Receiver 1.5M Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 16 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 6.4. Test Result and Data 6.4.1. Test Result of Fundamental Emission Power : AC 120V Pol/Phase : OPEN Test Mode : Mode 1 Temperature : 23°C Test Date : Feb. 02, 2017 Humidity : 65 % Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 17 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 Power : AC 120V Pol/Phase : CLOSE Test Mode : Mode 1 Temperature : 23°C Test Date : Feb. 02, 2017 Humidity : 65 % Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 18 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 6.4.2. Test Result of Unwanted Spurious emission (9KHz ~ 30MHz) Power : AC 120V Pol/Phase : OPEN Test Mode : Mode 1 Temperature : 23°C Test Date : Feb. 02, 2017 Humidity : 65 % Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 19 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 Power : AC 120V Pol/Phase : CLOSE Test Mode : Mode 1 Temperature : 23°C Test Date : Feb. 02, 2017 Humidity : 65 % Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 20 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 6.4.3. Test Result of Unwanted Spurious emission (30GHz ~ 1GHz) Power : AC 120V Pol/Phase : VERTICAL Test Mode : Mode 1 Temperature : 24°C Test Date : Jan. 24, 2017 Humidity : 68 % Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 21 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 Power : AC 120V Pol/Phase : HORIZONTAL Test Mode : Mode 1 Temperature : 24°C Test Date : Jan. 24, 2017 Humidity : 68 % Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 22 of 27 FCC ID : NDPEM-300

Lo CERPASS TECHNOLOGY CORP. Report No.: TEFO1G11252 84.4. 200B Bandwidth BW Frequency range Frequency range Frequency |20dB Bandwidth MHz (20d8 Down) MHiz (20dB Down) cane wrta 1. > 19553 MHz th < 13.507 MHz Tase pee Tamser Ta.sese0 2008 Bandwitth 1356 viie #® ce d w maree s io a =patm c ah oo meflo L—— Gerpass Technotogy Corp. Iosued date Feb. 1s, 2ot7 Torsse00020000 Fexeoso.ozrscet Page No. 2o ofer Foo D NoreM.soo

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 7. Frequency Stability 7.1. Test Procedure 1. The EUT was placed inside the Temperature and Humidity chamber. 2. The transmitter output was connected to spectrum analyzer. 3. Turn the EUT on and couple its output to a spectrum analyzer. 4. Turn the EUT off and set the chamber to the highest temperature specified. 5. Allow sufficient time (approximately 30 min) for the temperature of the chamber to stabilize, turn the EUT on and measure the operating frequency after 2, 5, and 10 minutes. 6. Repeat step 2 and 3 with the temperature chamber set to the lowest temperature. 7. The test chamber was allowed to stabilize at +20 degree C for a minimum of 30 minutes. The supply voltage was then adjusted on the EUT from 85% to 115% and the frequency record. 7.2. Test Setup Layout Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 26 of 27 FCC ID : NDPEM-300

CERPASS TECHNOLOGY CORP. Report No.: TEFO1611252 7.3. Test Result and Data Operating frequency: 13.56 MHz Power 2 minute 5 minute 10 minute Temperature supply (C) (MHz) (%) (MHz) (%) (MHz) (%) (V) 102 13.5609 0.006973 13.5609 0.006965 13.5609 0.068475 50 120 13.5610 0.007670 13.5610 0.007375 13.5610 0.072271 138 13.5610 0.007286 13.5612 0.008660 13.5609 0.065384 102 13.5609 0.006974 13.5608 0.006128 13.5608 0.062123 40 120 13.5609 0.006758 13.5609 0.006763 13.5608 0.062116 138 13.5609 0.006795 13.5608 0.006195 13.5609 0.064700 102 13.5610 0.007193 13.5608 0.006042 13.5610 0.073413 30 120 13.5610 0.007548 13.5609 0.006726 13.5610 0.074601 138 13.5608 0.006202 13.5610 0.007414 13.5608 0.059959 102 13.5608 0.005959 13.5610 0.007048 13.5610 0.072957 20 120 13.5610 0.007227 13.5610 0.007080 13.5610 0.073746 138 13.5609 0.006944 13.5609 0.006444 13.5608 0.059052 102 13.5608 0.006174 13.5608 0.005949 13.5610 0.073820 10 120 13.5609 0.006765 13.5608 0.006076 13.5610 0.071149 138 13.5610 0.007162 13.5609 0.006377 13.5609 0.068439 102 13.5610 0.007537 13.5610 0.007190 13.5608 0.060271 0 120 13.5609 0.006617 13.5610 0.007303 13.5610 0.074512 138 13.5610 0.007595 13.5609 0.006985 13.5608 0.061518 102 13.5609 0.006534 13.5610 0.007567 13.5610 0.071803 -10 120 13.5608 0.006258 13.5609 0.006960 13.5609 0.070014 138 13.5610 0.007480 13.5610 0.007150 13.5609 0.062865 102 13.5609 0.006748 13.5609 0.006304 13.5610 0.074932 -20 120 13.5609 0.006520 13.5608 0.006100 13.5609 0.064712 138 13.5610 0.007614 13.5608 0.006114 13.5609 0.069847 102 13.5610 0.007093 13.5609 0.006753 13.5609 0.065990 -30 120 13.5610 0.007375 13.5610 0.007670 13.5610 0.075221 138 13.5609 0.006717 13.5609 0.006495 13.5609 0.067021 Cerpass Technology Corp. Issued date : Feb. 15, 2017 Tel:886-3-3226-888 Fax:886-3-3226-881 Page No. : 27 of 27 FCC ID : NDPEM-300


Document Created: 2017-03-14 17:19:34
Document Modified: 2017-03-14 17:19:34
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC