TEST REPORT

FCC ID: L73EDFCCON

Test Report

Download: PDF
FCCID_1911077

FCC Part 15 Subpart C Requirement Measurement and Test Report For Sanwa Electronic Instrument Co., Ltd 1-2-50, Yoshida Honmachi, Higashi-Osaka, Osaka 578-0982, Japan FCC ID: L73EDFCCON February 26, 2013 This Report Concerns: Equipment Type: Original Report EDFC Active Control Unit Test Engineer: Daomen Report Number: SE13B-193F Test Date: February 20 to 23, 2013 Reviewed By: Karbon Y.Chung (Senior Manager) Prepared By: S&E Technologies Laboratory Ltd Room 407, Block A Shennan Garden, Hi-Tech Industrial Park, Shenzhen 518057, P.R. China. Tel: 86-755-26636573, 26630631 Fax: 86-755-26630557 Note: This test report is limited to the above client company and the product model only. It may not be duplicated without prior written consent of S&E Technologies Laboratory Ltd.

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON Table of Contents 1-TEST RESULT CERTIFICATION .................................................................................................... 3 2- EUT DESCRIPTION ....................................................................................................................... 4 3-TEST SYSTEM ................................................................................................................................ 5 3.1 TEST MODE ................................................................................................................................................... 5 3.2 TEST SETUP DIAGRAM .................................................................................................................................. 5 3.3 BLOCK DIAGRAM OF EUT SYSTEM............................................................................................................... 5 3.4 LIST OF CABLES ............................................................................................................................................ 5 4- TEST EQUIPMENT AND CALIBRATION ...................................................................................... 6 5- LABORATORY ACCREDITATIONS AND MEASUREMENT UNCERTAINTY ............................. 7 5.1 LABORATORY ACCREDITATION ...................................................................................................................... 7 5.2 MEASUREMENT UNCERTAINTY ..................................................................................................................... 7 6- TECHNICAL REQUIREMENTS AND RESULTS........................................................................... 8 6.1 RADIATED EMISSION MEASUREMENT ........................................................................................................... 8 Report No.:SE13B-193F Page 2 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON 1- Test Result Certification Applicant: Sanwa Electronic Instrument Co., Ltd 1-2-50, Yoshida Honmachi, Higashi-Osaka, Osaka 578-0982, Japan Equipment Under Test: EDFC Active Control Unit Trade Mark: EDFC Model Number.: EDC01-P7369 Type of Modulation: GFSK Operation Frequency: 2405MHz, 2424MHz, 2449MHz, 2479MHz Number of Channels: 4 Antenna Designation: Non-user replaceable (fixed) Power Supply: DC12.0V [ from a car battery] Date of Test: February 20 to 23, 2013 Applicable Standards Standard Test Result FCC 47 CFR Part 15 Subpart C, §15.249 No non-compliance noted We hereby certify that: The above equipment was tested at laboratory of Guangdong Galanz Enterprises Co., Ltd. The test data, data evaluation, test procedures, and equipment configurations shown in this report were made in accordance with the procedures given in ANSI C63.4-2003. The energy emitted by the sample EUT tested as described in this report is in compliance with conducted and radiated emission limits of FCC Rules Part 15C: 2007, §15.249. The test results of this report relate only to the tested sample identified in this report. Report No.:SE13B-193F Page 3 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON 2- EUT Description Product Name: EDFC Active Control Unit Trade Mark: EDFC Model Number: EDC01-P7369 Model Difference: N/A Type of Modulation:: GFSK Frequency Range: 2405MHz, 2424MHz, 2449MHz, 2479MHz Number of Channels: 4 Power Supply: 12.0V DC supplied by regulated DC power supply Antenna Designation: Non-user replaceable (fixed) Remark: This submittal test report is intended for FCC ID: L73EDFCCON filing to comply with Section 15.249 of the FCC Part 15, Subpart C Rules. Report No.:SE13B-193F Page 4 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON 3-Test System 3.1 Test Mode The compliance test was performed under test modes: Mode 1: Transmitting at 2405MHz. Mode 2: Transmitting at 2449MHz. Mode 3: Transmitting at 2479MHz. The EUT is designed both of horizontally placed and vertically placed. In radiated emission measurement, each condition was conducted. As a result, the below operation that produce the maximum emission were reported. Radiated emission measurement --- Mode 1, Mode 2, Mode 3 3.2 Test Setup Diagram . Radiated Emisison 3.3 Block Diagram of EUT System 3.4 List of Cables No Cable Name Shielded (Y/N) Length (m) Spec. Remark 28AWG 80oC For power supply 1 AWM2464 Y 1.5 300V and signal Report No.:SE13B-193F Page 5 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON 4- Test Equipment and Calibration Equipment type Manufacturer Model Serial Number Calibration Due Biconilog Antenna ETS 3142C 00042672 2013/09 Receiver SCHAFFNER SMR4503 11725 2013/07 Spectrum Analyzer R/S FSP30 100755 2013/11 Double-Ridged-Wave- ETS 3115 6587 2013/08 guide Horn Antenna Double-Ridged-Wave- ETS 3160 00052486 2013/08 guide Horn Antenna Amplifier Agilent 83017A MY39500438 2013/11 Band-pass Filter Micro-Tronic BRM50702 S/N-030 2013/11 DC Power Supply Jiangbo JB-305 A0412374 2013/10 HF Loop Antenna TESEQ HLA6120 26348 2013/10 Chamber ETS N/A N/A 2013/05 Report No.:SE13B-193F Page 6 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON 5- Laboratory Accreditations and Measurement Uncertainty 5.1 Laboratory Accreditation FCC-Registration No.: 580210 Guangdong Galanz Enterprises Co., Ltd EMC Laboratory has been registered and fully described in a report filed with the FCC (Federal Communications Commission). The acceptance letter from the FCC is maintained in our files. Registration no. 580210, Listing date November 28, 2012. 5.2 Measurement Uncertainty of+/-4.5dB for Radiated Emissions Report No.:SE13B-193F Page 7 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON 6- Technical Requirements and Results 6.1 Radiated Emission Measurement Applicable Standard: Fundamental and Harmonics Emission Limit According to §15.249(a), the field strength of emissions from intentional radiators operated within these frequency bands shall comply with the following: Fundamental Frequency Field Strength of Fundamental Field Strength of Harmonics MHz (mV/m @3m) (dBuV/m @3m) (uV/m @3m) (dBuV/m @3m) 2400-2483.5 50 94(Average) 500 54(Average) 114(Peak) 74(Peak) General Radiated Emission Limit According to §15.249(d),emissions radiated outside of the specified frequency bands, except for harmonics, shall be attenuated by at least 50 dB below the level of the fundamental or to the general radiated emission limits in Section 15.209, whichever is the lesser attenuation. Test Procedure: 1. The EUT was placed on a turn table which is 0.8m above ground plane. 2. The turn table shall rotate 360 degrees to determine the position of maximum emission level. 3. EUT is set 3m away from the receiving antenna which varied from 1m to 4m to find out the highest emissions. 4. Maximum procedure was performed on the six highest emissions to ensure EUT compliance. 5. And also, each emission was to be maximized by changing the polarization of receiving antenna both horizontal and vertical. 6. Repeat above procedures until all frequency measurement were completed. 7. Emissions were investigated to the 10th harmonic of the fundamental frequency. The field strength is calculated by adding the Antenna Factor and Cable Factor and subtracting the Amplifier Gain and Duty Cycle Correction Factor(if any) from the measured reading. The basic equation with a sample calculation is as follows: FS = RA + AF + CL - AG Where FS = Field Strength CL = Cable Attenuation Factor (Cable Loss) RA = Reading Amplitude AG = Amplifier Gain AF = Antenna Factor Report No.:SE13B-193F Page 8 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON Test Configuration between 9K and1 GHz: Or Loop antenna Test Configuration above 1 GHz: Test Results: Temperature: 25oC Humidity: 53% EUT Operation: Transmitting Test Date: February 23, 2013 Report No.:SE13B-193F Page 9 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON Spurious Emission In the Frequency Rang 9KHz to 1GHz: Fc= 2405MHz Transmitting Operation Detector Ant./CL/ Actual Freq. Ant.Pol. Reading Limit 3m Margin Mode Amp.CF FS (MHz) (H/V) (dBuV) (dBuV/m) (dB) (PK/QP) (dB) (dBuV/m) 30.00 H QP 4.3 16.7 21.0 40.0 -19.0 100.68 H QP 20.2 8.4 28.6 43.5 -14.9 30.84 V QP 3.6 16.8 20.4 40.0 -19.6 100.56 V QP 23.3 8.4 31.7 43.5 -11.8 Fc= 2449MHz Transmitting Operation Detector Ant./CL/ Actual Freq. Ant.Pol. Reading Limit 3m Margin Mode Amp.CF FS (MHz) (H/V) (dBuV) (dBuV/m) (dB) (PK/QP) (dB) (dBuV/m) 30.00 H QP 4.6 16.7 21.3 40.0 -18.7 100.62 H QP 19.8 8.4 28.2 43.5 -15.3 30.78 V QP 3.8 16.8 20.6 40.0 -19.4 100.60 V QP 24.7 8.4 33.1 43.5 -10.4 Fc= 2479MHz Transmitting Operation Detector Ant./CL/ Actual Freq. Ant.Pol. Reading Limit 3m Margin Mode Amp.CF FS (MHz) (H/V) (dBuV) (dBuV/m) (dB) (PK/QP) (dB) (dBuV/m) 30.12 H QP 4.1 16.7 20.8 40.0 -19.2 100.74 H QP 18.9 8.4 27.3 43.5 -16.2 30.55 V QP 4.4 16.8 21.2 40.0 -18.8 100.52 V QP 23.8 8.4 32.2 43.5 -11.3 Note: For emission measurement, the compliance tests were performed both of horizontally placed and vertically placed in EUT (X position, Y position, Z position). As a result, the data of operation mode that produce the maximum emission were reported. The other emissions are more than 20dB below the limit or the field strength is too small to be measured. Report No.:SE13B-193F Page 10 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON Spurious Emission In the Frequency Rang above 1GHz: Fc= 2405MHz Transmitting Operation Detector Ant./CL/ Actual Freq. Ant.Pol. Reading Limit 3m Margin Mode Amp.CF FS (MHz) (H/V) (dBuV) (dBuV/m) (dB) (PK/AV) (dB) (dBuV/m) 2405.00 H PK 97.17 -2.61 94.56 114.00 -19.44 2405.00 H AV 64.68 -2.61 62.07 94.00 -31.93 2400.00 H PK 69.86 -2.61 67.25 74.00 -6.75 2400.00 H AV 34.04 -2.61 31.43 54.00 -22.57 4812.00 H PK 51.33 0.92 52.25. 74.00 -21.75 4812.00 H AV 29.76 0.92 30.68 54.00 -23.32 2405.00 V PK 93.92 -2.61 91.31 114.00 -22.69 2405.00 V AV 63.30 -2.61 60.69 94.00 -33.31 2400.00 V PK 66.61 -2.61 64.00 74.00 -10.00 2400.00 V AV 33.52 -2.61 30.91 54.00 -23.09 4810.00 V PK 51.10 0.92 52.02 74.00 -21.98 4810.00 V AV 29.58 0.92 30.50 54.00 -23.50 Note: For emission measurement, the compliance tests were performed both of horizontally placed and vertically placed in EUT (X position, Y position, Z position). As a result, the data of operation mode that produce the maximum emission were reported. The other emissions are more than 20dB below the limit or the field strength is too small to be measured. Report No.:SE13B-193F Page 11 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON Fc= 2449MHz Transmitting Operation Detector Ant./CL/ Actual Freq. Ant.Pol. Reading Limit 3m Margin Mode Amp.CF FS (MHz) (H/V) (dBuV) (dBuV/m) (dB) (PK/AV) (dB) (dBuV/m) 2449.00 H PK 97.76 -2.10 95.66 114.00 -18.34 2449.00 H AV 66.35 -2.10 64.25 94.00 -29.75 2483.50 H PK 53.52 -1.86 51.66 74.00 -22.34 2483.50 H AV 32.70 -1.86 30.84 54.00 -23.16 4902.00 H PK 50.71 0.92 51.63 74.00 -22.37 4902.00 H AV 29.34 0.92 30.26 54.00 -23.74 2449.00 V PK 94.38 -2.10 92.28 114.00 -21.72 2449.00 V AV 64.30 -2.10 62.20 94.00 -31.80 2483.50 V PK 49.65 -1.86 47.79 74.00 -26.21 2483.50 V AV 30.01 -1.86 28.15 54.00 -25.85 4900.00 V PK 49.90 0.92 50.82 74.00 -23.18 4900.00 V AV 29.20 0.92 30.12 54.00 -23.88 Note: For emission measurement, the compliance tests were performed both of horizontally placed and vertically placed in EUT (X position, Y position, Z position). As a result, the data of operation mode that produce the maximum emission were reported. The other emissions are more than 20dB below the limit or the field strength is too small to be measured. Report No.:SE13B-193F Page 12 of 13 FCC Part 15.249 Report

Sanwa Electronic Instrument Co., Ltd FCC ID: L73EDFCCON Fc= 2479MHz Transmitting Operation Detector Ant./CL/ Actual Freq. Ant.Pol. Reading Limit 3m Margin Mode Amp.CF FS (MHz) (H/V) (dBuV) (dBuV/m) (dB) (PK/AV) (dB) (dBuV/m) 2479.00 H PK 97.03 -1.90 95.13 114.00 -18.87 2479.00 H AV 64.75 -1.90 62.85 94.00 -31.15 2483.50 H PK 69.36 -1.86 67.50 74.00 -6.50 2483.50 H AV 37.77 -1.86 35.91 54.00 -18.09 4958.00 H PK 49.95 0.92 50.87 74.00 -23.13 4958.00 H AV 29.43 0.92 30.35 54.00 -23.65 2479.00 V PK 93.47 -1.90 91.57 114.00 -22.43 2479.00 V AV 62.67 -1.90 60.77 94.00 -33.23 2483.50 V PK 69.36 -1.86 65.47 74.00 -8.53 2483.50 V AV 36.33 -1.86 34.47 54.00 -19.53 4958.00 V PK 49.54 0.92 50.46 74.00 -23.54 4958.00 V AV 29.32 0.92 30.24 54.00 -23.76 Note: For emission measurement, the compliance tests were performed both of horizontally placed and vertically placed in EUT (X position, Y position, Z position). As a result, the data of operation mode that produce the maximum emission were reported. The other emissions are more than 20dB below the limit or the field strength is too small to be measured. Report No.:SE13B-193F Page 13 of 13 FCC Part 15.249 Report


Document Created: 2013-03-02 17:00:08
Document Modified: 2013-03-02 17:00:08
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC