TEST REPORT

FCC ID: KE3-320084

Test Report

Download: PDF
FCCID_821059

Radio Systems Corporation FCC Part 15, Certification Application PetSafe PAC00-11045 Low Power Transmitter UST Project: 07-0036 Issue Date: June 21, 2007 3505 Francis Circle Alpharetta, GA 30004 PH: 770-740-0717 Fax: 770-740-1508 www.ustech-lab.com Page 1 of 27

I certify that I am authorized to sign for the manufacturer and that all of the statements in this report and in the Exhibits attached hereto are true and correct to the best of my knowledge and belief: UNITED STATES TECHNOLOGIES, INC. (AGENT RESPONSIBLE FOR TEST): By: Name: Louis A. Feudi __________ Title: VP / Operations & Engineering Date: June 21, 2007 _ Radio Systems Corporation 10427 Electric Avenue Knoxville, TN 37932 By: Name: Title: Date: This report shall not be reproduced except in full. This report may be copied in part only with the prior written approval of U.S. Technologies. The results contained in this report are subject to the adequacy and representative character of the sample provided. 3505 Francis Circle Alpharetta, GA 30004 PH: 770-740-0717 Fax: 770-740-1508 www.ustech-lab.com Page 2 of 27

FCC ID: KE3-320084 MEASUREMENT/TECHNICAL REPORT COMPANY NAME: Radio Systems Corporation MODEL: PetSafe PAC00-11045 FCC ID: KE3-320084 DATE: June 21, 2007 This report concerns (check one): Original grant X Class II change_____ Equipment type: Low Power 433.92 MHz Transmitter Deferred grant requested per 47 CFR 0.457(d)(1)(ii)? yes_____ No X If yes, defer until:_________________ date N.A. agrees to notify the Commission by N.A. date of the intended date of announcement of the product so that the grant can be issued on that date. Report prepared by: United States Technologies, Inc. 3505 Francis Circle Alpharetta, GA 30004 Phone Number: (770) 740-0717 Fax Number: (770) 740-1508 Page 3 of 27

FCC ID: KE3-320084 TABLE OF CONTENTS SECTION 1 GENERAL INFORMATION 1.1 Product Description 1.2 Related Submittal(s) SECTION 2 TESTS AND MEASUREMENTS 2.1 Configuration of Tested EUT 2.2 Test Facility 2.3 Test Equipment 2.4 Modifications 2.5 Antenna Description 2.6 Fundamental, Peak, and Average Radiated Spurious Emissions 2.7 Minimum 20 dB Bandwidth 2.8 20 dB Bandwidth 2.9 Power Line Conducted Emissions for Transmitter 2.10 Radiated Emissions for Digital Device & Receiver 2.11 Power Line Conducted for Digital Device & Receiver SECTION 3 LABELING INFORMATION SECTION 4 BLOCK DIAGRAM(S)/ SCHEMATIC(S) SECTION 5 PHOTOGRAPHS SECTION 6 THEORY OF OPERATION SECTION 7 USER'S MANUAL Page 4 of 27

FCC ID: KE3-320084 LIST OF FIGURES AND TABLES FIGURES 1) Test Configuration 2) Photograph(s) for Spurious and Conducted Emissions 3) Peak Radiated Emissions 4) 20 dB Bandwidth TABLES 1) EUT and Peripherals 2) Test Instruments 3) Peak Radiated Emissions 4) 20 dB Bandwidth 5) Conducted Emissions 6) Radiated Emissions for Digital Device and Receiver Page 5 of 27

FCC ID: KE3-320084 SECTION 1 GENERAL INFORMATION Page 6 of 27

FCC ID: KE3-320084 GENERAL INFORMATION 1.1 Product Description The Equipment Under Test (EUT) is an Radio Systems Corporation, Model PetSafe PAC00-11045 Low Power Transmitter. The EUT is a 433.92 MHz Low Power Transmitter is to be used with the PPA111079 (large), PPA11-710 (medium), and PPA11-10711 (small) SmartDoor electronic pet door receiver products. Page 7 of 27

FCC ID: KE3-320084 1.2 Related Submittal(s)/Grant(s) The EUT will be used to send data. The Low Frequency Transmitter presented in this report will be used with the PPA111079 (large), PPA11-710 (medium), and PPA11- 10711 (small) SmartDoor electronic pet door receiver products: The EUT is subject to the following authorizations: a) Certification as a low power Frequency Transmitter under 15.209 b) Verification as a digital device The information contained in this report is presented for the certification & verification authorization(s) for the EUT. Page 8 of 27

FCC ID: KE3-320084 SECTION 2 TESTS AND MEASUREMENTS Page 9 of 27

FCC ID: KE3-320084 TEST AND MEASUREMENTS 2.1 Configuration of Tested System The sample was tested per ANSI C63.4, Methods of Measurement from Low-Voltage Electrical and Electronic Equipment in the Range of 9 kHz to 40 GHz (2003). Conducted and radiated emissions data were taken with the test receiver or spectrum analyzer's resolution bandwidth adjusted to 9 kHz and 120 kHz, respectively. All measurements are peak unless stated otherwise. The video filter associated with the spectrum analyzer was off throughout the evaluation process. Block diagrams of the tested systems are shown in Figures 1. Test configuration photographs for spurious and fundamental emissions are shown in Figure 2a -g. The sample used for testing was received by U.S. Technologies on March 23, 2007 in good condition. 2.2 Test Facility Testing was performed at US Tech's measurement facility at 3505 Francis Circle, Alpharetta, GA. This site has been fully described and submitted to the FCC, and accepted in their letter marked 31040/SIT. Additionally this site has also been fully described and submitted to Industry Canada (IC), and has been approved under file number IC2982. 2.3 Test Equipment Table 2 describes test equipment used to evaluate this product. 2.4 Modifications No modifications were made by US Tech to bring the EUT into compliance with FCC Part 15, Class B Limits for the transmitter portion of the EUT or the Class B Digital Device Requirements. Radio Systems provided a modification to reduce Spurious emissions. A 0.5 pf capacitor was added to the EUT as signified in the Schematics. Page 10 of 27

FCC ID: KE3-320084 FIGURE 1 TEST CONFIGURATION EUT Page 11 of 27

FCC ID: KE3-320084 TABLE 1 Test Date: March 29, 2007 UST Project: 07-0036 Customer: Radio Systems Corporation Model: PetSafe PAC00-11045 EUT and Peripherals PERIPHERAL MODEL SERIAL FCC ID: CABLES MANU. NUMBER NUMBER P/D Radio Systems PetSafe None None None Corporation PAC00- (EUT) 11045 Page 12 of 27

FCC ID: KE3-320084 TABLE 2 TEST INSTRUMENTS EQUIPMENT MODEL MANUFACTURER SERIAL DATE OF NUMBER NUMBER LAST CALIBRATION SPECTRUM ANALYZER 8558B HEWLETT-PACKARD 2332A10055 3/28/07 SPECTRUM ANALYZER 8593E HEWLETT-PACKARD 3205A00124 7/3/06 SIGNAL GENERATOR 8648B HEWLETT-PACKARD 3642U01679 10/13/06 RF PREAMP 8447D HEWLETT-PACKARD 2944A06291 Dailey Calibration BICONICAL ANTENNA 3110B EMCO 9307-1431 10/11/06 LOG PERIODIC 3146 EMCO 3110-3236 9/15/05 2 Yr. HORN ANTENNA 3115 EMCO 9107-3723 10/16/06 2 Yr. PREAMP 8449B HEWLETT PACKARD 3008A00480 8/10/06 CALCULATION N/A N/A Ver. 6.0 N/A PROGRAM Note: The calibration interval of the above test instruments is 12 months unless stated otherwise and all calibrations are traceable to NIST/USA. Page 13 of 27

FCC ID: KE3-320084 2.5 Antenna Description (Paragraph 15.203) An intentional radiator shall be designed to ensure that no antenna other than that furnished by the responsible party shall be used with the device. The use of a permanently attached antenna or of an antenna that uses a unique coupling to the intentional radiator shall be considered sufficient to comply with the provisions of this section. Radio Systems Corporation will sell the Model PetSafe PAC00-11045 with a trace antenna integrally mounted on the pwb. Page 14 of 27

FCC ID: KE3-320084 2.6 Fundamental, Peak, and Average Radiated Spurious Emissions in the Frequency Range 30 -25000 MHz (FCC Section 15.209) The EUT was placed into a continuous transmit mode of operation. A preliminary scan was performed on the EUT to determine frequencies that were caused by the transmitter portion of the product. Significant emissions that fell within restricted bands were then measured on an OATS site. Radiated measurements below 1 GHz were tested with a RBW = 120 kHz. Radiated measurements above 1 GHz were measured using a RBW = VBW = 1 MHz. The results of peak radiated fundamental frequencies and spurious emissions falling within restricted bands are given in Table 3a –3b and Figure 3a – 3b. Average values were not calculated since peak values met average limits Page 15 of 27

FCC ID: KE3-320084 Table 3a. PEAK FUNDAMENTAL EMISSIONS Radiated Emissions Client: Radio Systems Corporation L.F. Project: 07-0036 Class: Model: PetSafe PAC00-11045 Frequency Test AF Test AF+CA Results Limits Distance / Margin PK = n Data Data -AMP (MHz) (dBm) Table (dBuV) (dB) (uV/m) (uV/m) Polarity (dB) / QP 433.858 -83.1 2lp3mh 23.9 20.5 166.2 200.0 3m./HORZ 1.6 QP 433.863 -83.4 2lp3mv 23.6 20.1 153.5 200.0 3m./VERT 2.3 QP SAMPLE CALCULATION: RESULTS (uV/m @ 3m) = Antilog ((-83.1 + 20.5 + 107)/20) = 166.2 CONVERSION FROM dBm TO dBuV = 107 dB Tester Signature: Name: Louis A. Feudi Page 16 of 27

FCC ID: KE3-320084 Figure 3a Peak Radiated Emission 15.209(c) Fundamental Page 17 of 27

FCC ID: KE3-320084 Table 3b. PEAK RADIATED SPURIOUS EMISSIONS Radiated Emissions Client: Radio Systems Corporation G.R.. Project: 07-0036 Class: Model: PetSafe PAC00-11045 Frequency Test Data AF Test AF+CA- Results Limits Distance / Margin PK = n Data AMP (MHz) (dBm) Table (dBuV) (dB) (uV/m) (uV/m) Polarity (dB) / QP 866.87 -95.4 2lp3mh 11.6 28.5 100.9 166.0 3m./HORZ 4.3 PK 1301.5 -58.8 1HN3mv 48.2 -6.9 116.4 166.0 3m./VERT 3.1 PK 1735.405 -66.6 1HN3mv 40.4 -5.0 58.8 166.0 3m./VERT 9.0 PK Limit set at fundamental to illustrate harmonics do not exceed fundamental field strength. SAMPLE CALCULATION: RESULTS (uV/m @ 3m) = Antilog ((-95.4 + 11.6 + 107)/20) = 100.9 CONVERSION FROM dBm TO dBuV = 107 dB Tester Signature: Name: Gersop Riera Page 18 of 27

FCC ID: KE3-320084 Figure 3b Peak Radiated Spurious Emission 15.209(c) Worst Case Harmonic Page 19 of 27

FCC ID: KE3-320084 2.8 20 dB Bandwidth per FCC Section 15.209(a)(1)(ii) The antenna port was connected to a spectrum analyzer that was set for a 50 Ω impedance with the RBW > approximately 1/100 of the manufacturers claimed RBW & VBW > RBW. The results of this test are given in Table 4 and Figure 5. Page 20 of 27

FCC ID: KE3-320084 TABLE 4 20 dB Bandwidth Test Date: March 29, 2007 UST Project: 07-0036 Customer: Radio Systems Corporation Model: PetSafe PAC00-11045 Frequency 20 dB Bandwidth MAXIMUM FCC LIMIT (GHz) (MHz) (MHz) 433.843 1.0 0.320 . Tester Signature: Name: Louis A. Feudi Page 21 of 27

FCC ID: KE3-320084 Figure 4 20 dB Bandwidth per FCC Section 15.209(a)(1)(ii) Page 22 of 27

FCC ID: KE3-320084 2.9 Power Line Conducted Emissions for Transmitter FCC Section 15.207 The conducted voltage measurements have been carried out in accordance with FCC Section 15.207, with a spectrum analyzer connected to a LISN and the EUT placed into a continuous mode of transmit. The results are given in Table 5a. Page 23 of 27

FCC ID: KE3-320084 TABLE 5 CONDUCTED EMISSIONS DATA CLASS B Test Date: March 29, 2007 UST Project: 07-0036 Customer: Radio Systems Corporation Model: PetSafe PAC00-11045 Conducted Emissions Test By: Test: FCC Part 15B Client: Radio Systems Corporation LAF Project: 07-0036 Class: B Model: PetSafe PAC00-11045 Frequency Test AF Test AF+CA- Results Limits Margin PK = n Data Data AMP (MHz) (dBm) Table (dBuV) (dB) (dBuV) (dBuV) (dB) / QP Not Applicable EUT is Battery Powered Tester Signature: Name: Louis A. Feudi Page 24 of 27

FCC ID: KE3-320084 2.10 Radiated Emissions for Digital Device & Receiver (47 CFR 15.109a) Radiated emissions were evaluated from 30 to 14500 MHz while the EUT was placed into a Receive mode of operation. Measurements were made with the analyzer's bandwidth set to 120 kHz measurements made less than 1 GHz and 1 MHz for measurements made greater than or equal to 1 GHz. The results for less than 1 GHz are shown in Table 6. Page 25 of 27

FCC ID: KE3-320084 TABLE 6 RADIATED EMISSIONS DATA (Digital Device & Receiver) CLASS B Test Date: March 29, 2007 UST Project: 07-0036 Customer: Radio Systems Corporation Product: PetSafe PAC00-11045 Radiated Emissions Client: Radio Systems Corporation L.A.F. Project: 07-0036 Class: B Model: PetSafe PAC00-11045 Frequency Test Data AF Test AF+CA- Results Limits Margin PK = n Data AMP (MHz) (dBm) Table (dBuV) (dB) (uV/m) (uV/m) (dB) / QP No emissions seen within 20 dB of the FCC Limit. Tester Signature: Name: Louis A. Feudi Page 26 of 27

FCC ID: KE3-320084 2.11 Power Line Conducted Emissions for Digital Device and Receiver FCC Section 15.107 The conducted voltage measurements have been carried out in accordance with FCC Section 15.107, with a spectrum analyzer connected to a LISN and the EUT placed into an idle condition or a continuous mode of receive. Similar results were seen as compared to the EUT in a transmit mode of operation. Therefore, please refer to the results as shown in Table 5. Page 27 of 27


Document Created: 2007-07-20 19:54:23
Document Modified: 2007-07-20 19:54:23
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC