EMC Test Report MaxRad

FCC ID: KBCIX260A750MPIBT

Test Report

Download: PDF
FCCID_366537

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 DECLARATION OF COMPLIANCE FCC PART 24(E) EMC MEASUREMENTS Test Lab Applicant Information CELLTECH LABS INC. ITRONIX CORPORATION Testing and Engineering Services 801 South Stevens Street 1955 Moss Court Spokane, WA 99204 Kelowna, B.C. Canada V1Y 9L3 Phone: 250-448-7047 Fax: 250-448-7046 e-mail: info@celltechlabs.com web site: www.celltechlabs.com FCC Rule Part(s): 47 CFR §24(E), §2 IC Rule Part(s): RSS-133 Issue 2 Test Procedure(s): FCC 47 CFR §24(E), §2; ANSI TIA/EIA-603-A-2001 FCC Device Classification: Part 24 Licensed Transmitter (PCB) IC Device Classification: 2GHz Personal Communication Services Device Type: Rugged Laptop PC with Sierra Wireless AirCard 750 PCS GSM/GPRS Modem (co-located with Cisco Systems MPI-350 Mini-PCI DSSS WLAN Card & Mitsumi WML-C11 Bluetooth Transmitter), Vehicle Cradle, & Mobile Antenna FCC ID: KBCIX260A750MPIBT Model(s): IX260 Tx Frequency Range: 1850.2 - 1909.8 MHz Max. RF Output Power: 0.385 Watts EIRP (25.85 dBm) Conducted Power Tested: 27.9 dBm Peak (1850.2 MHz) 27.9 dBm Peak (1880.0 MHz) 27.8 dBm Peak (1909.8 MHz) Modulation: GMSK Emission Designator: 271KGXW Antenna Type: Mobile Vehicle Antenna (MaxRad P/N: WMLPVDB800/1900 - 3 dBi Gain) Power Supply: 12V Vehicle Battery This equipment has demonstrated compliance with the applicable technical standards as indicated in the measurement report, and was tested in accordance with the measurement procedures specified in FCC 47 CFR §24(E), §2, Industry Canada RSS-133 Issue 2, and ANSI TIA/EIA-603-A-2001. I attest to the accuracy of data. All measurements reported herein were performed by me or were made under my supervision and are correct to the best of my knowledge and belief. I assume full responsibility for the completeness of these measurements and vouch for the qualifications of all persons taking them. This test report shall not be reproduced partially, or in full, without the prior written approval of Celltech Labs Inc. The results and statements contained in this report pertain only to the device(s) evaluated. Russell Pipe Senior Compliance Technologist Celltech Labs Inc. © 2003 Celltech Labs Inc. 1 of 11

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 TABLE OF CONTENTS 1.1 SCOPE 3 1.2 GENERAL INFORMATION - §2.1033(a) 3 2.1 MEASUREMENT PROCEDURES 4 2.2 RF Output Power - §2.1046 4 2.3 Effective Isotropic Radiated Power Output - §24.232(b) 4 2.4 Field Strength of Spurious Radiation - §2.1053 4 2.5 Radiated Measurement Test Setup 4 3.1 TEST DATA 5 3.2 Effective Isotropic Radiated Power Output - §24.232(b) 5 3.3 Field Strength of Spurious Radiation - §2.1053 6-8 4.1 LIST OF TEST EQUIPMENT 9 5.1 CONCLUSION 10 APPENDIX A - Radiated Test Setup Photographs 11 © 2003 Celltech Labs Inc. 2 of 11

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 FCC PART 24(E) EMC MEASUREMENT REPORT 1.1 SCOPE Measurement and determination of electromagnetic emissions (EME) from radio frequency devices for compliance with the technical rules and regulations of the Federal Communications Commission and Industry Canada. 1.2 GENERAL INFORMATION - §2.1033(a) APPLICANT ITRONIX CORPORATION 801 South Stevens Street Spokane, WA 99204 FCC ID KBCIX260A750MPIBT Model(s) IX260 Serial No. Pre-production Rugged Laptop PC with Sierra Wireless AirCard 750 PCS GSM/GPRS Modem EUT Type (co-located with Cisco MPI-350 Mini-PCI DSSS WLAN Card & Mitsumi WML-C11 Bluetooth Transmitter) Vehicle Cradle, & Mobile Vehicle-Mount Antenna FCC 47 CFR §24(E), §2 Rule Part(s) IC RSS-133 Issue 2 FCC Classification Part 24 Licensed Transmitter (PCB) IC Classification 2GHz Personal Communication Services Tx Frequency Range 1850.2 - 1909.8 MHz Max. RF Output Power 0.385 Watts EIRP (25.85 dBm) 27.9 dBm Peak (1850.2 MHz) RF Conducted Output 27.9 dBm Peak (1880.0 MHz) Power Tested 27.8 dBm Peak (1909.8 MHz) Emission Designator 271KGXW Frequency Tolerance 0.1 PPM Power Supply 12V Vehicle Battery Mobile Vehicle-Mount Antenna Antenna Type (MaxRad P/N: WMLPVDB800/1900 - 3 dBi Gain) © 2003 Celltech Labs Inc. ITRONIX CORPORATION FCC ID: KBCIX260A750MPIBT (Model: IX260) 3 of 11 Rugged Laptop PC with PCS GSM/GPRS Modem, Cradle, & Vehicle-Mount Antenna

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 2.1 MEASUREMENT PROCEDURES 2.2 RF OUTPUT POWER MEASUREMENT - §2.1046 The peak conducted power was measured with a Gigatronics 8650A Universal Power Meter in burst average power mode. An offset was entered into the power meter to correct for the losses of the attenuator and cable installed before the sensor input. The transmitter terminal was coupled to the power meter and the EUT was placed into test mode via internal software. All subsequent tests were performed using the same tune-up procedures. 2.3 EFFECTIVE ISOTROPIC RADIATED POWER OUTPUT - §24.232(b) EIRP measurements were performed using the Signal Substitution Method in accordance with ANSI TIA/EIA-603-A-2001 on a 3-meter open area test site. The EUT was placed on a turntable 3-meters from the receive antenna and tested with the EUT transmitting continuously on 4 time slots in GPRS mode via internal software at a full rated power. The field of maximum intensity was found by rotating the EUT 360 degrees and changing the height of the receive antenna from 1 to 4 meters. Once a peak was found the spectrum analyzer was set to peak hold and the value of the emission was extracted. The field strength was recorded for each channel being tested, and for both EUT antenna polarizations and modes. A standard gain horn antenna was substituted in place of the EUT. The antenna was fed through a directional coupler and the power at the coupler port was monitored. A signal generator and power amplifier controlled the signal to the antenna, and the input level of the antenna was adjusted to the same field strength level as the EUT. The feed point for the antenna was then connected to a calibrated power meter and the power adjusted to read the same as the coupler port previously recorded, this is to account for any mismatch in impedance, which may occur at the horn antenna. The conducted power at the antenna feed point was recorded. The forward conducted power for the horn antenna was then determined and the EIRP level was determined by adding the horn forward conducted power and the antenna gain in dB. 2.4 FIELD STRENGTH OF SPURIOUS RADIATION - §2.1053 Radiated spurious emissions were measured on a 3-meter open area test site using the Signal Substitution Method in accordance with ANSI TIA/EIA-603-A-2001. The EUT was tested with the EUT transmitting continuously on 4 time slots in GPRS mode via internal software at a full rated power. The EUT was placed on the turntable with the transmitter transmitting into a non-radiating load. A receiving antenna located 3 meters from the turntable received any signal radiated from the transmitter and its operating accessories. The receiving antenna was varied in height from 1 to 4 meters and the polarization was varied (horizontal and vertical) to determine the worst-case emission level. A standard gain horn antenna was substituted in place of the EUT. A modulated signal was fed through a directional coupler to the antenna and the power at the coupler port was monitored. A signal generator and power amplifier controlled the antenna, and the input level of the antenna was adjusted to the same field strength level as the EUT. The antenna feed point was then connected to a calibrated power meter and the power was adjusted to read the same power at the coupler port previously recorded, to account for any mismatch in impedance which may occur at the horn antenna. The conducted power at the antenna feed point was then recorded. The forward conducted power for the horn antenna was determined by measuring the power at the horn antenna feed point and reproducing the coupler power previously measured. The EIRP level was determined by adding the horn forward conducted power and the horn antenna gain. All spurious emissions from the lowest radio frequency generated in the equipment to the tenth harmonic of the carrier were investigated. The test data is shown on pages 7-9. 2.5 RADIATED MEASUREMENT TEST SETUP Spectrum Analyzer 3 Meters Device Under Test Turntable 1 Meter Figure 1. Radiated Measurement Test Setup Diagram © 2003 Celltech Labs Inc. ITRONIX CORPORATION FCC ID: KBCIX260A750MPIBT (Model: IX260) 4 of 11 Rugged Laptop PC with PCS GSM/GPRS Modem, Cradle, & Vehicle-Mount Antenna

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 3.1 TEST DATA 3.2 EFFECTIVE ISOTROPIC RADIATED POWER OUTPUT - §24.232(b) EIRP of EUT EUT Maximum EUT & Horn Horn Gain Freq. Peak Field Horn Horn Forward + Tuned Conducted Strength Antenna Gain Conducted Horn Forward Power of EUT Polariz. Power Conducted Power MHz dBm dBm H/V dBi dBm dBm Watts 1850.2 27.9 -13.82 V 6.55 17.99 24.54 0.284 1880.0 27.9 -13.20 V 6.58 19.27 25.85 0.385 1909.8 27.8 -14.44 V 6.61 18.40 25.01 0.317 © 2003 Celltech Labs Inc. ITRONIX CORPORATION FCC ID: KBCIX260A750MPIBT (Model: IX260) 5 of 11 Rugged Laptop PC with PCS GSM/GPRS Modem, Cradle, & Vehicle-Mount Antenna

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 3.3 FIELD STRENGTH OF SPURIOUS RADIATION - §2.1053 Operating Frequency (MHz): 1850.2 Channel: 512 (Low) EUT Conducted Pwr. (dBm): 27.90 Measured EIRP (dBm): 24.54 Modulation: GMSK Distance: 3 Meters Limit: 43 + 10 log (W) = 37.53 dBc Field Strength Horn Forward Standard Frequency of Cond. Pwr. Gain Horn POL EIRP ERP dBc Spurious Antenna Gain Radiation MHz dBm dBm dBi H/V dBm dBm 3700.40 -87.89 -55.00 6.6 V -48.40 -50.54 75.08 5550.60 -87.31 -49.51 7.8 V -41.71 -43.85 68.39 7400.80 -85.16 -48.58 7.8 V -40.78 -42.92 67.46 9251.00 -85.77 -47.75 7.6 V -40.15 -42.29 66.83 11101.20 -84.06 -47.70 8.5 V -39.20 -41.34 65.88 12951.40 -80.20 -42.32 8.8 V -33.52 -35.66 60.20 14801.60 -82.59 -44.71 9.6 V -35.11 -37.25 61.79 16651.80 -82.89 -45.06 9.0 V -36.06 -38.20 62.74 18502.00 -83.43 -47.22 9.3 V -37.92 -40.06 64.60 Notes: 1. Radiated spurious measurements were performed using the Signal Substitution Method per ANSI/TIA/EIA-603-A-2001. 2. All other spurious emissions generated from the lowest frequency of the EUT to the tenth harmonic were investigated and found to be below the magnitude of each harmonic level. 3. Spurious emissions more than 20 dB below the limit are reported, though not required per §2.1051. © 2003 Celltech Labs Inc. ITRONIX CORPORATION FCC ID: KBCIX260A750MPIBT (Model: IX260) 6 of 11 Rugged Laptop PC with PCS GSM/GPRS Modem, Cradle, & Vehicle-Mount Antenna

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 FIELD STRENGTH OF SPURIOUS RADIATION - §2.1053 Operating Frequency (MHz): 1880.0 Channel: 661 (Mid) EUT Conducted Pwr. (dBm): 27.90 Measured EIRP (dBm): 25.85 Modulation: GMSK Distance: 3 Meters Limit: 43 + 10 log (W) = 38.85 dBc Field Strength Horn Forward Standard Frequency of Cond. Pwr. Gain Horn POL EIRP ERP dBc Spurious Antenna Gain Radiation MHz dBm dBm dBi H/V dBm dBm 3760.00 -86.97 -54.08 6.6 V -47.48 -49.62 75.47 5640.00 -85.22 -47.42 7.8 V -39.62 -41.76 67.61 7520.00 -82.94 -46.36 7.8 V -38.56 -40.70 66.55 9400.00 -84.92 -46.90 7.6 V -39.30 -41.44 67.29 11280.00 -84.85 -48.49 8.5 V -39.99 -42.13 67.98 13160.00 -84.46 -46.58 8.8 V -37.78 -39.92 65.77 15040.00 -81.73 -43.85 9.6 V -34.25 -36.39 62.24 16920.00 -82.74 -44.91 9.0 V -35.91 -38.05 63.90 18800.00 -82.02 -45.81 9.3 V -36.51 -38.65 64.50 Notes: 1. Radiated spurious measurements were performed using the Signal Substitution Method per ANSI/TIA/EIA-603-A-2001. 2. All other spurious emissions generated from the lowest frequency of the EUT to the tenth harmonic were investigated and found to be below the magnitude of each harmonic level. 3. Spurious emissions more than 20 dB below the limit are reported, though not required per §2.1051. © 2003 Celltech Labs Inc. ITRONIX CORPORATION FCC ID: KBCIX260A750MPIBT (Model: IX260) 7 of 11 Rugged Laptop PC with PCS GSM/GPRS Modem, Cradle, & Vehicle-Mount Antenna

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 FIELD STRENGTH OF SPURIOUS RADIATION - §2.1053 Operating Frequency (MHz): 1909.8 Channel: 810 (High) EUT Conducted Pwr. (dBm): 27.80 Measured EIRP (dBm): 25.01 Modulation: GMSK Distance: 3 Meters Limit: 43 + 10 log (W) = 38.01 dBc Field Strength Horn Forward Standard Frequency of Cond. Pwr. Gain Horn POL EIRP ERP dBc Spurious Antenna Gain Radiation MHz dBm dBm dBi H/V dBm dBm 3819.60 -87.01 -54.12 6.6 V -47.52 -49.66 74.67 5729.40 -86.31 -48.51 7.8 V -40.71 -42.85 67.86 7639.20 -84.29 -47.71 7.8 V -39.91 -42.05 67.06 9549.00 -85.76 -47.74 7.6 V -40.14 -42.28 67.29 11458.80 -84.09 -47.73 8.5 V -39.23 -41.37 66.38 13368.60 -84.96 -47.08 8.8 V -38.28 -40.42 65.43 15278.40 -81.41 -43.53 9.6 V -33.93 -36.07 61.08 17188.20 -81.82 -43.99 9.0 V -34.99 -37.13 62.14 19098.00 -82.74 -46.53 9.3 V -37.23 -39.37 64.38 Notes: 1. Radiated spurious measurements were performed using the Signal Substitution Method per ANSI/TIA/EIA-603-A-2001. 2. All other spurious emissions generated from the lowest frequency of the EUT to the tenth harmonic were investigated and found to be below the magnitude of each harmonic level. 3. Spurious emissions more than 20 dB below the limit are reported, though not required per §2.1051. © 2003 Celltech Labs Inc. ITRONIX CORPORATION FCC ID: KBCIX260A750MPIBT (Model: IX260) 8 of 11 Rugged Laptop PC with PCS GSM/GPRS Modem, Cradle, & Vehicle-Mount Antenna

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 4.1 TEST EQUIPMENT LIST TEST EQUIPMENT LIST Equipment Type Model Serial No. Calibration Due Date HP Signal Generator 8648D (9kHz-4.0GHz) 3847A00611 Feb 2004 Rohde & Schwarz Signal Generator SMR40 (10MHz-40GHz) 835537/022 Nov 2003 Gigatronics Power Meter 8652A 1835272 Feb 2004 Gigatronics Power Sensor 80701A (0.05-18GHz) 1833535 Feb 2004 Gigatronics Power Sensor 80701A (0.05-18GHz) 1833542 Feb 2004 Amplifier Research Power Amp. 5S1G4 (5W, 800MHz-4.2GHz) 26235 N/A Microwave System Amplifier HP 83017A (0.5-26.5GHz) 3123A00587 N/A Network Analyzer HP 8753E (30kHz-3GHz) US38433013 Feb 2004 Audio Analyzer HP 8903B 3729A18691 Nov 2003 Modulation Analyzer HP 8901A 3749A07154 July 2003 Frequency Counter HP 53181A (3GHz) 3736A05175 May 2003 DC Power Supply HP E3611A KR83015294 N/A Multi-Device Controller EMCO 2090 9912-1484 N/A Mini Mast EMCO 2075 0001-2277 N/A Turntable EMCO 2080-1.2/1.5 0002-1002 N/A Double Ridged Horn Antenna ETS 3115 (1-18GHz) 6267 Oct. 2003 Double Ridged Horn Antenna ETS 3115 (1-18GHz) 6276 Oct. 2003 Horn Antenna Chase BBHA 9120-A (0.7-4.8GHz) 9120A-239 Sept 2003 Horn Antenna Chase BBHA 9120-A (0.7-4.8GHz) 9120A-240 Sept 2003 Roberts Dipoles Compliance Design (2 sets) 3121C June 2003 Spectrum Analyzer HP 8594E 3543A02721 Feb 2004 Spectrum Analyzer HP E4408B US39240170 Nov 2003 Shielded Screen Room Lindgren R.F. 18W-2/2-0 16297 N/A Environmental Chamber ESPEC ECT-2 (Temperature/Humidity) 0510154-B Feb 2004 © 2003 Celltech Labs Inc. ITRONIX CORPORATION FCC ID: KBCIX260A750MPIBT (Model: IX260) 9 of 11 Rugged Laptop PC with PCS GSM/GPRS Modem, Cradle, & Vehicle-Mount Antenna

Test Report S/N: 071603-406KBC FCC Part 24 EMC Measurements Test Date(s): February 18, 2003 5.1 CONCLUSION The data in this measurement report shows that the ITRONIX CORPORATION Model: IX260 FCC ID: KBCIX260A750MPIBT Rugged Laptop PC with Sierra Wireless AirCard 750 PCS GSM/GPRS PCMCIA Modem Card (co-located with Cisco Systems MPI-350 Mini-PCI DSSS WLAN Card and Bluetooth Transmitter Module), Vehicle Cradle, and MaxRad Mobile Vehicle-Mount Antenna (P/N: WMLPVDB800/1900) complies with the requirements of FCC Rule Parts §24(E) and §2. © 2003 Celltech Labs Inc. ITRONIX CORPORATION FCC ID: KBCIX260A750MPIBT (Model: IX260) 10 of 11 Rugged Laptop PC with PCS GSM/GPRS Modem, Cradle, & Vehicle-Mount Antenna


Document Created: 2003-10-11 17:12:35
Document Modified: 2003-10-11 17:12:35
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC