Test Report

FCC ID: JPZ0109

Test Report

Download: PDF
FCCID_2481220

849 NW State Road 45 Newberry, FL 32669 USA Ph: 888.472.2424 or 352.472.5500 Fax: 352.472.2030 Email: info@timcoengr.com Website: www.timcoengr.com FCC PART 15.249 & IC RSS-210 (i8) ANNEX A2.9 UNLICENSED INTENTIONAL RADIATOR COMBINED TEST REPORT Applicant LUTRON ELECTRONICS CO., INC. 7200 SUTER ROAD Address COOPERSBURG PA 18036 USA FCC ID JPZ0109 IC Certification 2851A-JPZ0109 Number Model Number 0109 Product Description 802.15.14 ZIGBEE TX FCC Standard Applied 47 CFR §15.249 Industry Canada RSS-210 Issue 8 Annex A2.9 Standard Applied Date Sample Received 12/9/2014 Date Tested 12/9/2014 Tested By Cory Leverett Approved By Sid Sanders Report Number 2239AUT14TestReport.docx Test Results PASS FAIL THE ATTACHED REPORT SHALL NOT BE REPRODUCED EXCEPT IN FULL WITHOUT THE WRITTEN APPROVAL OF TIMCO ENGINEERING, INC.

TABLE OF CONTENTS GENERAL REMARKS ...................................................................................................... 3 GENERAL INFORMATION ................................................................................................ 4 TEST RESULTS SUMMARY .............................................................................................. 4 TEST PROCEDURES ....................................................................................................... 5 RADIATION INTERFERENCE............................................................................................ 6 20 dB BANDWIDTH ....................................................................................................... 9 DUTY CYCLE ................................................................................................................15 DUTY CYCLE ................................................................................................................16 EMC EQUIPMENT LIST ..................................................................................................17 APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 2 of 17

GENERAL REMARKS The attached report shall not be reproduced except in full without the written permission of Timco Engineering Inc. Summary The device under test does: fulfill the general approval requirements as identified in this test report not fulfill the general approval requirements as identified in this test report Attestations This equipment has been tested in accordance with the standards identified in this test report. To the best of my knowledge and belief, these tests were performed using the measurement procedures described in this report. All instrumentation and accessories used to test products for compliance to the indicated standards are calibrated regularly in accordance with ISO 17025: 2005 requirements. I attest that the necessary measurements were made, under my supervision, at: Timco Engineering Inc. 849 NW State Road 45 Newberry, Fl 32669 Authorized Signatory Name: Cory Leverett Engineering Project Manager Date: 12/5/2014 Table of Contents APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 3 of 17

GENERAL INFORMATION EUT Specification The test results relate only to the items tested. Applicable Standards FCC Part 15.249 & IC RSS-210 (i8), RSS-GEN (i3) EUT Description 802.15.14 ZIGBEE TX FCC ID JPZ0109 IC Certification Number 2851A-JPZ0109 Model Number 0109 Operating Frequency TX: 2405 - 2480 MHz RX: Same No. of Channels 15 Modulations CQPSK 110–120Vac/50– 60Hz when Charging EUT Power Source DC Power CR 2032 Coin Cell Battery Operated Exclusively Prototype Pre- Production Test Item Production Type of Equipment Fixed Mobile Portable FCC Rules require that the antenna connector be unique. Antenna Connector There is no antenna connector, it has an integrated PCB antenna Timco Engineering Inc. located at 849 NW State Road 45 Test Facility Newberry, FL 32669 USA. Conditions in the Test Temperature: 24-26ºC laboratory Relative humidity: 50-65% 100% Duty Cycle Tuned to Low, Middle, and High End of Test Exercise 2.4 GHz Band Revision History of EUT None TEST RESULTS SUMMARY FCC Rules Part No. Industry Canada Rules RESULTS – Pass/Fail/NA 15.249 Fundamental Emission RSS-210 (i8) ANNEX PASS A2.9, RSS-GEN (i3) 15.249 & 15.209 Harmonics & RSS-210 (i8) ANNEX PASS Spurious A2.9, RSS-GEN (i3) 15.205 & 2.202 Occupied RSS-GEN (i3), 4.6 PASS Bandwidth 15.249 & 15.205 Bandedge RSS-GEN (i3), 4.6 PASS Compliance 15.207 Power Line Emissions RSS-GEN (i3), 7.2.4 NA Table of Contents APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 4 of 17

TEST PROCEDURES Radiation Interference: ANSI C63.4-2003 using a spectrum analyzer, a preselector, a quasi-peak adapter, and an appropriate antenna. The analyzer was calibrated in dB above a microvolt at the output of the antenna. The resolution bandwidth was 100 kHz with an appropriate sweep speed and the video bandwidth was 300 kHz up to 1 GHz and 1 MHz with a video BW of 3 MHz above 1 GHz. When an emission was found, the table was rotated to produce the maximum signal strength. The antenna was placed in both the horizontal and vertical planes and the worst case emissions were reported. The spectrum was searched to at least the tenth (10) harmonic of the fundamental. Emissions were scanned from 30MHz to the tenth harmonic of the fundamental frequency at three places in the band. All emissions greater than 20 dB from the limit are not reported. Formula Of Conversion Factors: The field strength at 3m was established by adding the meter reading of the spectrum analyzer (which is set to read in units of dBuV) to the antenna correction factor supplied by the antenna manufacturer. The antenna correction factors are stated in terms of dB. The gain of the preselector was accounted for in the spectrum analyzer meter reading. Example: Freq (MHz) Meter Reading + ACF + CL = FS 33 20 dBuV + 10.36 dB + 0.5 = 30.86 dBuV/m @ 3m Power Line Conducted Interference: The procedure used was ANSI C63.4-2003 using a 50uH LISN. Both lines were observed. The bandwidth of the spectrum analyzer was 10kHz with an appropriate sweep speed. The spectrum was scanned from 0.15 to 30 MHz. Occupied Bandwidth: A small sample of the transmitter output was fed into the spectrum analyzer and the attached plot was printed. The vertical scale is set to -10 dBm per division. ANSI C63.4-2003 10.1 Measurement Procedures: The EUT was placed on a table 80 cm high and with dimensions of 1m by 1.5m. The EUT was placed in the center of the table (1.5m side). The table used for radiated measurements is capable of continuous rotation. When an emission was found, the table was rotated to produce the maximum signal strength. At this point, the antenna was raised and lowered from 1m to 4m. The antenna was placed in both the horizontal and vertical planes. Emissions attenuated more than 20 dB below the permissible value are not reported. Table of Contents APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 5 of 17

RADIATION INTERFERENCE Rules Part No.: FCC 15.249, 15.209 & IC RSS-210 (i8) ANNEX A2.9, RSS-GEN (i3) Requirements: Frequency Limits Part 15.209 & RSS-GEN (i3) 9 to 490 kHz 2400/F (kHz) µV/m @ 300 meters 490 to 1705 kHz 24000/F (kHz) µV/m @ 30 meters 1705 kHz to 30 MHz 29.54 dBµV/m @ 30 meters 30 – 88 40.0 dBµV/m @ 3 meters 80 – 216 43.5 dBµV/m @ 3 meters 216 – 960 46.0 dBµV/m @ 3 meters Above 960 54.0 dBµV/m @ 3 meters Part 15.249 & RSS-210 (i8) ANNEX A.2.9 Fundamental 902 – 928 MHz 94.0 dBµV/m @ 3 meters Fundamental 2.4 – 2.4835 GHz 94.0 dBµV/m @ 3 meters Harmonics 54.0 dBµV/m @ 3 meters Remarks: The EUT maximized EUT position was flat on the table, horizontal to the measuring antenna. The spectrum was scanned from 30 MHz to the Tenth harmonic of each fundamental frerquency. No emissions were found past the first harmonic. The Transmitter uses a diversity antenna system, antenna chain 1 & antenna chain 2. Before transmission it calculates which antenna it will use and only transmits from one antenna at a time The results foud on the following pages how results for each antenna chains APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 6 of 17

RADIATION INTERFERENCE Test Data: Averaged power Field Strength table. Peak detector used for all read levels ANT CHAIN 1 Emission Read Coax Correction Field Tuned Ant Duty Margin Freq Level Loss Factor Strength Freq MHz Polarity Cycle dB MHz dBuV dB dB/m dBuV/m 2,405.00 2,405.00 65.92 H 3.18 32.15 20 81.25 12.75 2,405.00 2,405.00 59.02 V 3.18 32.15 20 74.35 19.65 2,405.00 4,810.00 7.1 H 4.91 34.13 20 26.14 27.86 2,405.00 4,810.00 7.3 V 4.91 34.13 20 26.34 27.66 2,440.00 2,440.00 59.81 V 3.21 32.22 20 75.24 18.76 2,440.00 2,440.00 65.36 H 3.21 32.22 20 80.79 13.21 2,440.00 4,880.00 8 H 4.94 34.14 20 27.08 26.92 2440.00 4880.00 8.1 V 4.94 34.14 20 27.18 26.82 2,480.00 2,480.00 59.21 V 3.24 32.3 20 74.75 19.25 2,480.00 2,480.00 64.13 H 3.24 32.3 20 79.67 14.33 2,480.00 4,960.00 7.3 H 4.98 34.16 20 26.44 27.56 2,480.00 4,960.00 7.3 V 4.98 34.16 20 26.44 27.56 RESULTS: MEETS REQUIREMENTS Table of Contents APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 7 of 17

RADIATION INTERFERENCE Test Data: Averaged power Field Strength table. Peak detector used for all read levels ANT CHAIN 2 Emission Read Coax Correction Field Tuned Ant Duty Margin Freq Level Loss Factor Strength Freq MHz Polarity Cycle dB MHz dBuV dB dB/m dBuV/m 2,405.00 2,405.00 65.81 H 3.18 32.15 20 81.14 12.86 2,405.00 2,405.00 60.37 V 3.18 32.15 20 75.7 18.3 2,405.00 4,810.00 7.1 H 4.91 34.13 20 26.14 27.86 2,405.00 4,810.00 7.3 V 4.91 34.13 20 26.34 27.66 2,440.00 2,440.00 61.51 V 3.21 32.22 20 76.94 17.06 2,440.00 2,440.00 65.21 H 3.21 32.22 20 80.64 13.36 2,440.00 4,880.00 8 H 4.94 34.14 20 27.08 26.92 2440.00 4880.00 8.1 V 4.94 34.14 20 27.18 26.82 2,480.00 2,480.00 59.41 V 3.24 32.3 20 74.95 19.05 2,480.00 2,480.00 63.54 H 3.24 32.3 20 79.08 14.92 2,480.00 4,960.00 7.3 H 4.98 34.16 20 26.44 27.56 2,480.00 4,960.00 7.3 V 4.98 34.16 20 26.44 27.56 RESULTS: MEETS REQUIREMENTS Table of Contents APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 8 of 17

20 dB BANDWIDTH Test Data: Measured 20 dB OCC BW = 2.6 MHz APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 9 of 17

BAND EDGE Rules Part No.: 15.249 (d) & RSS-GEN (i3), 4.6 Requirements: The field strength of any emissions appearing outside the bandedges and up to 10 kHz above and below the band edges shall be attenuated at least 50 dB below the level of the carrier or to the general limits of 15.249 whichever is the lesser attenuation. Remarks: The EUT meets the general limits of 15.209, this was the lesser attenuation Test Data: Field Strength Table Lower Band Edge Tuned Emission ReadLevel Ant. Coax Correction Duty Field Margin Freq MHz Freq dBuV Polarity Loss Factor Cycle Strength dB MHz dB dB/m dBuV/m ANTENNA CHAIN 1 2,405.00 2,398.00 8 V 3.18 32.14 20 23.32 30.68 2,405.00 2,398.00 18.9 H 3.18 32.14 20 34.22 19.78 2,405.00 2,400.00 10.2 V 3.18 32.14 20 25.52 28.48 2,405.00 2,400.00 20.4 H 3.18 32.14 20 35.72 18.28 ANTENNA CHAIN 2 2,405.00 2,398.00 17.7 H 3.18 32.14 20 33.02 20.98 2,405.00 2,398.00 18.9 V 3.18 32.14 20 34.22 19.78 2,405.00 2,400.00 19.3 V 3.18 32.14 20 34.62 19.38 2,405.00 2,400.00 21.4 H 3.18 32.14 20 36.72 17.28 Upper Band Edge ANTENNA CHAIN 1 Tuned Emission ReadLevel Ant. Coax Correction Duty Field Margin Freq MHz Freq dBuV Polarity Loss Factor Cycle Strength dB MHz dB dB/m dBuV/m 2,480.00 2,483.50 12.1 V 3.24 32.31 20 27.65 26.35 2,480.00 2,483.50 21.8 H 3.24 32.31 20 37.35 16.65 2,480.00 2,485.00 9.6 V 3.24 32.31 20 25.15 28.85 2,480.00 2,485.00 18.7 H 3.24 32.31 20 34.25 19.75 ANTENNA CHAIN 2 2,480.00 2,483.50 11.4 V 3.24 32.31 20 26.95 27.05 2,480.00 2,483.50 20.8 H 3.24 32.31 20 36.35 17.65 2,480.00 2,485.00 8.3 V 3.24 32.31 20 23.85 30.15 2,480.00 2,485.00 16.4 H 3.24 32.31 20 31.95 22.05 Table of Contents APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 10 of 17

BAND EDGE Test Data: Band Edge Plots Lower Band Edge Antenna Chain 1 APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 11 of 17

BAND EDGE Test Data: Band Edge Plots Lower Band Edge Antenna Chain 2 APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 12 of 17

BAND EDGE Test Data: Band Edge Plots Upper Band Edge Antenna Chain 1 APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 13 of 17

BAND EDGE Test Data: Band Edge Plots Upper Band Edge Antenna Chain 2 (Peak Detector) APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 14 of 17

DUTY CYCLE Test Data: Plot of 100 ms span Normal Operational duty cycle (Rx Acknowledgment received) APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 15 of 17

DUTY CYCLE Test Data: Plot of 100 ms span Worst Case Reattempt mode (Rx Acknowledgment not received) Duty Cycle Calculation: Total # of pulses in 100 ms: 5 Duration of pulse: .2 ms maximum duration of pulse according to manufacturer. 20*log ((5X2)/100)=20*log (.1)= -20 dB Duty Cycle applied = 20 dB Table of Contents APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 16 of 17

EMC EQUIPMENT LIST Device Manufacturer Model Serial Cal/Char Due Date Number Date Antenna: Eaton 94455-1 1057 06/14/13 06/14/15 Biconnical Chamber Chamber Antenna: Eaton 96005 1243 05/31/13 05/31/15 Log- Periodic Chamber 3-Meter Panashield N/A N/A 12/31/13 12/31/15 Semi- Anechoic Chamber Antenna: ETS-Lindgren 3117 00035923 06/13/14 06/13/16 Double- Chamber Ridged Horn/ETS Horn 1 EMI Test Rohde & ESIB 40 100274 08/12/14 08/12/16 Receiver R Schwarz & S ESIB 40 *EMI RECEIVER SOFTWARE VERSION *EMI Test Receiver Firmware Version: 4.73 Service Pack 1 Table of Contents APPLICANT: LUTRON ELECTRONICS CO., INC. IC: 2851A-JPZ0109 FCC ID: JPZ0109 REPORT: L\LUTRON\2239AUT14\2239AUT14TestReport.docx Page 17 of 17


Document Created: 2014-12-22 11:49:04
Document Modified: 2014-12-22 11:49:04
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC