FCC Report

FCC ID: HYQ1EA

Test Report

Download: PDF
FCCID_1922549

Test report No. : 10005487H—B—R1 Page : 1 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQIEA RADIO TEST REPORT Test Report No. : 10005487H—B—R1 Applicant $ DENSO CORPORATION Type of Equipment f Electronic Key Model No. $ 1EA Test regulation $ FCC Part 15 Subpart C: 2012 FCC ID $ HYQIEA Test Result s Complied This test report shall not be reproduced in full or partial, without the written approval of UL Japan, Inc. in p o p The results in this report apply only to the sample tested. This sample tested is in compliance with above regulation. The test results in this report are traceable to the national or international standards. This test report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. 6. This report is a revised version of 10005487H—B. 10005487H—B is replaced with this report. Date of test: March 9 and 10, 2013 %V/jé/tg Representative test engineer: Katsunori Okai Engineer of WiSE Japan, UL Verification Service Approved by: % * MasanorW Manager of WiSE Japan, UL Verification Service This laboratory is accredited by the NVLAP LAB CODE ® 200572—0, U.S.A. The tests reported herein have been performed in accordance with its terms of accreditation. *As for the range of Accreditation in NVLAP, you may Nv Z&@ refer to the WEB address, http://www.ul.com/japan/jpn/pages/services/eme/about/ma rk1/index.jsp#nvlap NVLAP LAB CODE: 200572—0 UL Japan, Inc. Head Office EMC Lab. 4383—326 Asama—cho, Ise—shi, Mie—ken 516—0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 13—EM—FO429

Test report No. : 10005487H-B-R1 Page : 2 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA REVISION HISTORY Original Test Report No.: 10005487H-B Revision Test report No. Date Page Contents revised - 10005487H-B March 15, 2013 - - (Original) 1 10005487H-B-R1 March 21, 2013 P,19 Correction of Modulation UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 3 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA CONTENTS PAGE SECTION 1: Customer information ·············································································· 4 SECTION 2: Equipment under test (E.U.T.) ···································································· 4 SECTION 3: Test specification, procedures & results························································· 5 SECTION 4: Operation of E.U.T. during testing ······························································· 8 SECTION 5: Radiated emission (Electric Field Strength of Fundamental and Spurious Emission) 9 SECTION 6: Automatically deactivate ········································································· 10 SECTION 7: -20dB and 99% Occupied Bandwidth ························································· 10 APPENDIX 1: Data of EMI test ·················································································· 11 Automatically deactivate................................................................................................................... 11 Radiated Emission (Electric Field Strength of Fundamental and Spurious Emission) ..................... 13 -20dB and 99% Occupied Bandwidth ............................................................................................... 15 Duty Cycle ........................................................................................................................................ 17 APPENDIX 2:Test Instruments ··················································································· 22 APPENDIX 3: Photographs of test setup ······································································· 23 Radiated emission ............................................................................................................................. 23 Worst case position ........................................................................................................................... 24 UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 4 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA SECTION 1: Customer information Company Name : DENSO CORPORATION Address : 1-1 Showa-cho, Kariya-shi, Aichi-ken, 448-8661 Japan Telephone Number : +81-566-61-7076 Facsimile Number : +81-566-25-4792 Contact Person : TAKAHIDE KITAHARA SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : Electronic Key Model No. : 1EA Serial No. : Refer to Clause 4.2 Rating : DC 3.0V Receipt Date of Sample : February 23, 2013 Country of Mass-production : Japan, United States of America, China Condition of EUT : Engineering prototype (Not for Sale: This sample is equivalent to mass-produced items.) Modification of EUT : No Modification by the test lab 2.2 Product Description Model No: 1EA (referred to as the EUT in this report) is the Electronic Key. The EUT (1EA) transmits radio wave signals of FSK and ASK. The radio wave signals of FSK and ASK are not transmitted simultaneously. Either one of FSK and ASK is transmitted by operator's action. End users cannot control which of FSK and ASK to be transmitted. General Specification Clock frequency(ies) in the system : 16 MHz RC oscillator (IC clock) 13.08 MHz Crystal (RF) Radio Specification Radio Type : Transceiver Frequency of Operation : 433.92MHz Modulation : FSK (F1D) / ASK (A1D) Power Supply (radio part input) : DC 3.0V Type of Battery : One lithium battery Antenna type : Built-in type (Fixed) UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 5 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA SECTION 3: Test specification, procedures & results 3.1 Test Specification Test Specification : Test specification: FCC Part 15 Subpart C: 2012, final revised on December 27, 2012 and effective January 28, 2013 Title : FCC 47CFR Part15 Radio Frequency Device Subpart C Intentional Radiators Section 15.231 Periodic operation in the band 40.66 - 40.70MHz and above 70MHz 3.2 Procedures and results Item Test Procedure Specification Worst margin Results Remarks FCC: ANSI C63.4:2003 FCC: Section 15.207 7. AC powerline conducted emission measurements Conducted emission N/A N/A*1) - IC: RSS-Gen 7.2.4 IC: RSS-Gen 7.2.4 FCC: ANSI C63.4:2003 FCC: Section 15.231(a)(1) 13. Measurement of Automatically Deactivate intentional radiators N/A Complied Radiated IC: - IC: RSS-210 A1.1.1 FCC: ANSI C63.4:2003 FCC: Section 15.231(b) [FSK] 13. Measurement of 10.1dB intentional radiators 433.920MHz IC: RSS-Gen 4.8 IC: RSS-210 A1.1.2 Horizontal Electric Field Strength PK with Duty factor Complied Radiated of Fundamental Emission [ASK] 6.1dB 433.920MHz Horizontal PK with Duty factor FCC: ANSI C63.4:2003 FCC: Section 15.205 [FSK] 13. Measurement of Section 15.209 8.3dB intentional radiators Section 15.231(b) 3037.440MHz IC: RSS-Gen 4.9 IC: RSS-210 A1.1.2, 2.5.1 Horizontal Electric Field Strength RSS-Gen 7.2.5 PK with Duty factor Complied Radiated of Spurious Emission [ASK] 7.8dB 3037.440MHz Vertical PK with Duty factor FCC: ANSI C63.4:2003 FCC: Section 15.231(c) 13. Measurement of intentional radiators -20dB Bandwidth KDB 926416 N/A Complied Radiated IC: - IC: Reference data Note: UL Japan, Inc.’s EMI Work Procedures No. 13-EM-W0420 and 13-EM-W0422. *1) The test is not applicable since the EUT does not have AC Mains. UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 6 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA FCC 15.31 (e) This test was performed with the New Battery (DC 3.0V) and the constant voltage was supplied to the EUT during the tests. Therefore, the EUT complies with the requirement. FCC Part 15.203 Antenna requirement It is impossible for end users to replace the antenna, because the antenna is mounted inside of the EUT. Therefore, the equipment complies with the antenna requirement of Section 15.203. 3.3 Addition to standard Item Test Procedure Specification Worst margin Results Remarks 99% Occupied IC: RSS-Gen 4.6.1 IC: RSS-Gen 4.6.1 N/A Complied Radiated Bandwidth Other than above, no addition, exclusion nor deviation has been made from the standard. 3.4 Uncertainty EMI The following uncertainties have been calculated to provide a confidence level of 95% using a coverage factor k=2. Test room Radiated emission (semi- (3m*)(+dB) (1m*)(+dB) (0.5m*)(+dB) anechoic 9kHz 30MHz 300MHz 1GHz 10GHz 18GHz 26.5GHz chamber) -30MHz -300MHz -1GHz -10GHz -18GHz -26.5GHz -40GHz No.1 4.3dB 5.0dB 5.1dB 4.9dB 5.8dB 4.4dB 4.3dB No.2 4.3dB 5.2dB 5.1dB 5.0dB 5.7dB 4.3dB 4.2dB No.3 4.6dB 5.0dB 5.1dB 5.0dB 5.7dB 4.5dB 4.2dB No.4 4.8dB 5.2dB 5.0dB 5.0dB 5.7dB 5.2dB 4.2dB *3m/1m/0.5m = Measurement distance Radiated emission test(3m) [FSK] The data listed in this test report has enough margin, more than the site margin. [ASK] The data listed in this test report has enough margin, more than the site margin. UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 7 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA 3.5 Test Location UL Japan, Inc. Head Office EMC Lab. *NVLAP Lab. Code: 200572-0 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124 FCC IC Registration Width x Depth x Size of Other Registration Number Height (m) reference ground plane (m) / rooms Number horizontal conducting plane No.1 semi-anechoic 313583 2973C-1 19.2 x 11.2 x 7.7m 7.0 x 6.0m No.1 Power chamber source room No.2 semi-anechoic 655103 2973C-2 7.5 x 5.8 x 5.2m 4.0 x 4.0m - chamber No.3 semi-anechoic 148738 2973C-3 12.0 x 8.5 x 5.9m 6.8 x 5.75m No.3 chamber Preparation room No.3 shielded room - - 4.0 x 6.0 x 2.7m N/A - No.4 semi-anechoic 134570 2973C-4 12.0 x 8.5 x 5.9m 6.8 x 5.75m No.4 chamber Preparation room No.4 shielded room - - 4.0 x 6.0 x 2.7m N/A - No.5 semi-anechoic - - - 6.0 x 6.0 x 3.9m 6.0 x 6.0m chamber No.6 shielded - - 4.0 x 4.5 x 2.7m 4.75 x 5.4 m - room No.6 measurement - - 4.75 x 5.4 x 3.0m 4.75 x 4.15 m - room No.7 shielded room - - 4.7 x 7.5 x 2.7m 4.7 x 7.5m - No.8 measurement - - 3.1 x 5.0 x 2.7m N/A - room No.9 measurement - - 8.0 x 4.5 x 2.8m 2.0 x 2.0m - room No.10 measurement - - 2.6 x 2.8 x 2.5m 2.4 x 2.4m - room No.11 measurement - - 3.1 x 3.4 x 3.0m 2.4 x 3.4m - room * Size of vertical conducting plane (for Conducted Emission test) : 2.0 x 2.0m for No.1, No.2, No.3, and No.4 semi-anechoic chambers and No.3 and No.4 shielded rooms. 3.6 Test set up, Data of EMI, Test instruments. Refer to APPENDIX. UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 8 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA SECTION 4: Operation of E.U.T. during testing 4.1 Operating Modes Test Item* Mode Automatically Deactivate Transmitting mode, FSK/ASK, 433.92MHz Duty Cycle Electric Field Strength of Fundamental Emission Transmitting mode, FSK/ASK, 433.92MHz *1) Electric Field Strength of Spurious Emission -20dB & 99% Occupied Bandwidth * The system was configured in typical fashion (as a customer would normally use it) for testing. *1) The software of this mode is the same as one of normal product, except that EUT continues to transmit when transceiver button is being pressed (For Normal use mode, EUT stops when transceiver button is being pressed.) End users cannot change the settings of the output power of the product. 4.2 Configuration and peripherals A:EUT * Test data was taken under worse case conditions. Description of EUT No. Item Model number Serial number Manufacturer Remarks A Electronic Key 1EA 001 DENSO EUT CORPORATION UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 9 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA SECTION 5: Radiated emission (Electric Field Strength of Fundamental and Spurious Emission) Test Procedure and conditions EUT was placed on a urethane platform of nominal size, 0.5m by 1.0m, raised 0.8m above the conducting ground plane. The EUT was set on the center of the tabletop. Test was made with the antenna positioned in both the horizontal and vertical planes of polarization. The measurement antenna was varied in height above the conducting ground plane to obtain the maximum signal strength. Photographs of the set up are shown in Appendix 1. [Transmitting mode] (Below 30MHz) The noise level was checked by moving a search-coil (Loop Antenna) close to the EUT. (Above 30MHz) The Radiated Electric Field Strength has been measured on Semi anechoic chamber with a ground plane and at a distance of 3m. The measuring antenna height was varied between 1 and 4m and EUT was rotated a full revolution in order to obtain the maximum value of the electric field strength. The measurements were performed for both vertical and horizontal antenna polarization. The radiated emission measurements were made with the following detector function of the test receiver/spectrum analyzer. - The carrier level (or, noise levels) was (or were) measured at each position of all three axes X, Y and Z, and the position that has the maximum noise was determined. Noise levels of all the frequencies were measured at the position. *The result is rounded off to the second decimal place, so some differences might be observed. Test Antennas are used as below; Frequency Below 30MHz 30MHz to 300MHz 300MHz to 1GHz Above 1GHz Antenna Type Loop Biconical Logperiodic Horn From 9kHz From 90kHz From From From Above 1GHz to 90kHz and to 110kHz 150kHz 490kHz 30MHz From 110kHz to 490kHz to 30MHz to 1GHz to 150kHz Detector Peak Peak Peak Peak Peak and Peak and Peak with Type Peak with Duty factor Duty factor IF 200Hz 200Hz 9.1kHz 9.1kHz 120kHz PK: S/A:RBW 1MHz, Bandwidth VBW 3MHz - The carrier level was measured at each position of all three axes X, Y and Z, and the position that has the maximum noise was determined. Noise levels of all the frequencies were measured at the position. This EUT has two modes which mechanical key is inserted or not. The worst case was confirmed with and without mechanical key, as a result, the test with mechanical key was the worst case. Therefore the test with mechanical key was performed only. *The result is rounded off to the second decimal place, so some differences might be observed. Measurement range : 9kHz-4.4GHz Test data : APPENDIX Test result : Pass UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 10 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA SECTION 6: Automatically deactivate Test Procedure The measurement was performed with Electric field strength using a spectrum analyzer. Test data : APPENDIX Test result : Pass SECTION 7: -20dB and 99% Occupied Bandwidth Test Procedure The measurement was performed in the antenna height to gain the maximum of Electric field strength. Test Span RBW VBW Sweep Detector Trace Instrument used 20dB Bandwidth 300kHz 3kHz 9.1kHz Auto Peak Max Hold Spectrum Analyzer 99% Occupied Enough width to display 1 % of Span Three times Auto Peak *1) Max Hold Spectrum Analyzer Bandwidth 20dB Bandwidth of RBW *1) *1) The measurement was performed with Peak detector, Max Hold since the duty cycle was not 100%. Test data : APPENDIX Test result : Pass UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 11 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA APPENDIX 1: Data of EMI test Automatically deactivate Test place No.2 Semi Anechoic Chamber Report No. 10005487H Date 03/09/2013 Temperature/ Humidity 24 deg. C / 33% RH Engineer Motoya Imura Mode Transmitting mode, FSK (433.92MHz) Time of Limit Result Transmitting [sec] [sec] 0.250 5.00 Pass UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 12 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA Automatically deactivate Test place No.2 Semi Anechoic Chamber Report No. 10005487H Date 03/09/2013 Temperature/ Humidity 24 deg. C / 33% RH Engineer Motoya Imura Mode Transmitting mode, ASK (433.92MHz) Time of Limit Result Transmitting [sec] [sec] 0.250 5.00 Pass UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 13 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA Radiated Emission (Electric Field Strength of Fundamental and Spurious Emission) Test place Head Office EMC Lab. No.2 Semi Anechoic Chamber Report No. 10005487H Date 03/09/2013 / 03/10/2013 Temperature/ Humidity 24 deg. C / 33% RH / 23 deg. C / 30% RH Engineer Motoya Imura / Katsunori Okai Mode Transmitting mode, FSK (433.92MHz) PK Frequency Detector Reading Ant Loss Gain Duty Result Limit Margin Remark [dBuV] Factor Factor [dBuV/m] [dB] Inside or Outside [MHz] Hor Ver [dB/m] [dB] [dB] [dB] Hor Ver [dBuV/m] Hor Ver of Restricted Bands 433.920 PK 81.3 81.1 17.6 9.5 28.5 - 79.9 79.7 100.8 20.9 21.1 Carrier 867.840 PK 31.7 33.1 22.2 11.2 27.9 - 37.2 38.6 80.8 43.6 42.2 Outside 1301.760 PK 48.5 48.7 24.8 1.7 36.3 - 38.7 38.9 73.9 35.2 35.0 Inside 1735.680 PK 56.0 57.3 26.0 2.0 35.9 - 48.1 49.4 80.8 32.7 31.4 Outside 2169.600 PK 47.3 46.0 26.9 2.2 35.7 - 40.7 39.4 80.8 40.1 41.4 Outside 2603.520 PK 58.7 57.0 26.9 2.5 35.6 - 52.5 50.8 80.8 28.3 30.0 Outside 3037.440 PK 66.6 65.4 27.6 2.7 35.2 - 61.7 60.5 80.8 19.1 20.3 Outside 3471.360 PK 48.6 48.7 28.1 2.9 34.9 - 44.7 44.8 80.8 36.1 36.0 Outside 3905.280 PK 44.4 44.1 28.9 3.1 34.6 - 41.8 41.5 73.9 32.1 32.4 Inside 4339.200 PK 42.4 42.5 29.5 3.3 34.7 - 40.5 40.6 73.9 33.4 33.3 Inside Result = Reading + Ant Factor + Loss (Cable+Attenuator+Filter) - Gain(Amprifier) PK with Duty factor Frequency Detector Reading Ant Loss Gain Duty Result Limit Margin Remark [dBuV] Factor Factor [dBuV/m] [dB] [MHz] Hor Ver [dB/m] [dB] [dB] [dB] Hor Ver [dBuV/m] Hor Ver 433.920 PK 81.3 81.1 17.6 9.5 28.5 -9.2 70.7 70.5 80.8 10.1 10.3 Carrier 867.840 PK 31.7 33.1 22.2 11.2 27.9 -9.2 28.0 29.4 60.8 32.8 31.4 Outside 1301.760 PK 48.5 48.7 24.8 1.7 36.3 -9.2 29.5 29.7 53.9 24.4 24.2 Inside 1735.680 PK 56.0 57.3 26.0 2.0 35.9 -9.2 38.9 40.2 60.8 21.9 20.6 Outside 2169.600 PK 47.3 46.0 26.9 2.2 35.7 -9.2 31.5 30.2 60.8 29.3 30.6 Outside 2603.520 PK 58.7 57.0 26.9 2.5 35.6 -9.2 43.3 41.6 60.8 17.5 19.2 Outside 3037.440 PK 66.6 65.4 27.6 2.7 35.2 -9.2 52.5 51.3 60.8 8.3 9.5 Outside 3471.360 PK 48.6 48.7 28.1 2.9 34.9 -9.2 35.5 35.6 60.8 25.3 25.2 Outside 3905.280 PK 44.4 44.1 28.9 3.1 34.6 -9.2 32.6 32.3 53.9 21.3 21.6 Inside 4339.200 PK 42.4 42.5 29.5 3.3 34.7 -9.2 31.3 31.4 53.9 22.6 22.5 Inside Result = Reading + Ant Factor + Loss (Cable+Attenuator+Filter) - Gain(Amprifier) + Duty factor (Refer to Duty factor data sheet) *Other frequency noises omitted in this report were not seen or had enough margin (more than 20dB). UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 14 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA Radiated Emission (Electric Field Strength of Fundamental and Spurious Emission) Test place Head Office EMC Lab. No.2 Semi Anechoic Chamber Report No. 10005487H Date 03/09/2013 / 03/10/2013 Temperature/ Humidity 24 deg. C / 33% RH / 23 deg. C / 30% RH Engineer Motoya Imura / Katsunori Okai Mode Transmitting mode, ASK (433.92MHz) PK Frequency Detector Reading Ant Loss Gain Duty Result Limit Margin Remark [dBuV] Factor Factor [dBuV/m] [dB] Inside or Outside [MHz] Hor Ver [dB/m] [dB] [dB] [dB] Hor Ver [dBuV/m] Hor Ver of Restricted Bands 433.920 PK 91.1 90.8 17.6 9.5 28.5 - 89.7 89.4 100.8 11.1 11.4 Carrier 867.840 PK 39.7 40.1 22.2 11.2 27.9 - 45.2 45.6 80.8 35.6 35.2 Outside 1301.760 PK 54.1 56.7 24.8 1.7 36.3 - 44.3 46.9 73.9 29.6 27.0 Inside 1735.680 PK 57.5 62.0 26.0 2.0 35.9 - 49.6 54.1 80.8 31.2 26.7 Outside 2169.600 PK 60.8 60.0 26.9 2.2 35.7 - 54.2 53.4 80.8 26.6 27.4 Outside 2603.520 PK 64.9 63.7 26.9 2.5 35.6 - 58.7 57.5 80.8 22.1 23.3 Outside 3037.440 PK 72.6 72.9 27.6 2.7 35.2 - 67.7 68.0 80.8 13.1 12.8 Outside 3471.360 PK 55.2 55.2 28.1 2.9 34.9 - 51.3 51.3 80.8 29.5 29.5 Outside 3905.280 PK 51.1 52.3 28.9 3.1 34.6 - 48.5 49.7 73.9 25.4 24.2 Inside 4339.200 PK 42.5 43.9 29.5 3.3 34.7 - 40.6 42.0 73.9 33.3 31.9 Inside Result = Reading + Ant Factor + Loss (Cable+Attenuator+Filter) - Gain(Amprifier) PK with Duty factor Frequency Detector Reading Ant Loss Gain Duty Result Limit Margin Remark [dBuV] Factor Factor [dBuV/m] [dB] [MHz] Hor Ver [dB/m] [dB] [dB] [dB] Hor Ver [dBuV/m] Hor Ver 433.920 PK 91.1 90.8 17.6 9.5 28.5 -15.0 74.7 74.4 80.8 6.1 6.4 Carrier 867.840 PK 39.7 40.1 22.2 11.2 27.9 -15.0 30.2 30.6 60.8 30.6 30.2 Outside 1301.760 PK 54.1 56.7 24.8 1.7 36.3 -15.0 29.3 31.9 53.9 24.6 22.0 Inside 1735.680 PK 57.5 62.0 26.0 2.0 35.9 -15.0 34.6 39.1 60.8 26.2 21.7 Outside 2169.600 PK 60.8 60.0 26.9 2.2 35.7 -15.0 39.2 38.4 60.8 21.6 22.4 Outside 2603.520 PK 64.9 63.7 26.9 2.5 35.6 -15.0 43.7 42.5 60.8 17.1 18.3 Outside 3037.440 PK 72.6 72.9 27.6 2.7 35.2 -15.0 52.7 53.0 60.8 8.1 7.8 Outside 3471.360 PK 55.2 55.2 28.1 2.9 34.9 -15.0 36.3 36.3 60.8 24.5 24.5 Outside 3905.280 PK 51.1 52.3 28.9 3.1 34.6 -15.0 33.5 34.7 53.9 20.4 19.2 Inside 4339.200 PK 42.5 43.9 29.5 3.3 34.7 -15.0 25.6 27.0 53.9 28.3 26.9 Inside Result = Reading + Ant Factor + Loss (Cable+Attenuator+Filter) - Gain(Amprifier) + Duty factor (Refer to Duty factor data sheet) *Other frequency noises omitted in this report were not seen or had enough margin (more than 20dB). UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 15 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA -20dB and 99% Occupied Bandwidth Test place Head Office EMC Lab. No.2 Semi Anechoic Chamber Report No. 10005487H Date 03/09/2013 Temperature/ Humidity 24 deg. C / 33% RH Engineer Motoya Imura Mode Transmitting mode, FSK / ASK (433.92MHz) Bandwidth Limit : Fundamental Frequency 433.92 MHz x 0.25% = 1084.80 kHz FSK -20dB Bandwidth Bandwidth Limit Result [kHz] [kHz] 85.203 1084.80 Pass ASK -20dB Bandwidth Bandwidth Limit Result [kHz] [kHz] 28.424 1084.80 Pass Bandwidth Limit : Fundamental Frequency 433.92 MHz x 0.25% = 1084.80 kHz FSK 99% Occupied Bandwidth Bandwidth Limit Result [kHz] [kHz] 84.55 1084.80 Pass ASK 99% Occupied Bandwidth Bandwidth Limit Result [kHz] [kHz] 98.64 1084.80 Pass UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 16 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA -20dB and 99% Occupied Bandwidth FSK ASK UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 17 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA Duty Cycle Test place Head Office EMC Lab. No.2 Semi Anechoic Chamber Report No. 10005487H Date 03/10/2013 Temperature/ Humidity 21 deg. C / 30% RH Engineer Katsunori Okai Mode Transmitting mode, FSK (433.92MHz) (Total) ON time Cycle Duty Duty [ms] [ms] (On time/Cycle) [dB] 34.620 100.00 0.3462 -9.21 Duty = 20log10 (ON time/100ms) A *A is intentional off time. UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 18 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA Duty Cycle 500mS UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 19 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA Duty Cycle Test place Head Office EMC Lab. No.2 Semi Anechoic Chamber Report No. 10005487H Date 03/10/2013 Temperature/ Humidity 21 deg. C / 30% RH Engineer Katsunori Okai Mode Transmitting mode, ASK (433.92MHz) ON time(One pulse) ON time(in 100ms) Type Times [ms] [ms] A 52 0.125 6.500 B 46 0.243 11.192 *1)ON time(in 100ms) = Times * ON time(One pulse) *2)The train of pulses was exceeding 100msec, and that sampled 100msec was the worst case against the pulse train. (Total) ON time Cycle Duty Duty [ms] [ms] (On time/Cycle) [dB] 17.692 100.00 0.1769 -15.04 *3)ON time = Type A's ON time (in 100ms) + Type B's ON time (in 100ms) *4)Duty = 20log10 (ON time/100ms) C *C is intentional off time. UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 20 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA Duty Cycle 20mS 20mS UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 21 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA Duty Cycle A B 2mS UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124

Test report No. : 10005487H-B-R1 Page : 22 of 25 Issued date : March 15, 2013 Revised date : March 21, 2013 FCC ID : HYQ1EA APPENDIX 2:Test Instruments EMI test equipment Control No. Instrument Manufacturer Model No Serial No Test Item Calibration Date * Interval(month) MAEC-02 Semi Anechoic TDK Semi Anechoic DA-06902 RE 2012/06/29 * 12 Chamber(NSA) Chamber 3m MOS-22 Thermo-Hygrometer Custom CTH-201 0003 RE 2013/02/26 * 12 MJM-14 Measure KOMELON KMC-36 - RE - COTS-MEMI EMI measurement TSJ TEPTO-DV - RE - program MRENT-95 Spectrum Analyzer Agilent E4440A MY46185823 RE 2012/06/19 * 12 MTR-03 Test Receiver Rohde & Schwarz ESCI 100300 RE 2012/04/03 * 12 MBA-02 Biconical Antenna Schwarzbeck BBA9106 VHA91032008 RE 2012/10/08 * 12 MLA-02 Logperiodic Antenna Schwarzbeck USLP9143 201 RE 2012/10/08 * 12 MCC-12 Coaxial Cable Fujikura/Agilent - - RE 2013/02/06 * 12 MAT-07 Attenuator(6dB) Weinschel Corp 2 BK7970 RE 2012/11/06 * 12 MPA-09 Pre Amplifier Agilent 8447D 2944A10845 RE 2012/09/11 * 12 MHA-06 Horn Antenna 1-18GHz Schwarzbeck BBHA9120D 254 RE 2013/02/15 * 12 MPA-10 Pre Amplifier Agilent 8449B 3008A02142 RE 2013/01/10 * 12 MCC-132 Microwave Cable HUBER+SUHNER SUCOFLEX104 336161/4(1m) / RE 2012/09/05 * 12 340639(5m) MSA-10 Spectrum Analyzer Agilent E4448A MY46180655 RE 2013/02/22 * 12 MLPA-06 Loop Antenna UL Japan - - RE Pre Check The expiration date of the calibration is the end of the expired month. All equipment is calibrated with valid calibrations. Each measurement data is traceable to the national or international standards. As for some calibrations performed after the tested dates, those test equipment have been controlled by means of an unbroken chains of calibrations. Test Item: RE: Radiated emission, 99% Occupied Bandwidth, -20dB bandwidth , Automatically deactivate and Duty cycle tests UL Japan, Inc. Head Office EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8116 Facsimile : +81 596 24 8124


Document Created: 2013-03-21 15:42:47
Document Modified: 2013-03-21 15:42:47
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC