Test Report

FCC ID: HN2ABTM3-3

Test Report

Download: PDF
FCCID_381337

TEST REPORT In support of the Application for Grant of Equipment Authorisation of the Intermec Technologies Corporation Series 700C-SMC45 Handheld Computer Terminal FCC ID: EHA700C-SMC45 November 2002

BABT. Segensworth Road, Titchfield Fareham, Hampshire, United Kingdom, PO15 5RH Tel: +44(0)1329 443300, Fax: +44(0)1329 443331 www.tuvps.co.uk Equipment: 700C-SMC45 FCC ID: EHA700C-SMC45 Specification: 47 CFR 2 & 47 CFR 24 Applicant: Intermec Technologies Corporation Norand Mobile Systems Division 550 Second Street S.E. Cedar Rapids IOWA 52401 USA Manufacturer: As above Manufacturer’s Representative: Mr Scott Holub Approved by: M JENKINS Wireless Group Leader th Dated: 18 November 2002 th Start of Test: 11 October 2002 nd Completion of Test: 22 October 2002 Report Distribution: Intermec Technologies Corporation Mr S Holub Copy No. 1 BABT Copy No’s. 2 & 3 Copy No: 2 ENGINEERING STATEMENT I ATTEST: the measurements shown in this report were made in accordance with the procedures indicated, and that the emissions from this equipment were found to be within the applicable limits. I assume full responsibility for the accuracy and completeness of these measurements. On the basis of the measurements made, the equipment tested is capable of operation in accordance with the requirements of Part 2, and Part 24 of the FCC Rules under normal use and maintenance. Simon Bennett Test Manager REPORT NUMBER RO610071 PAGE 1 OF 30

FCC ID: EHA700C-SMC45 CONTENTS:- Page No. Introduction 3 Location of Testing 3 Test Equipment and Ancillaries Used For Test 3 Description of Equipment Under Test Configuration 5 List of Performed Measurements 5 The list of measured parameters covering Subclause Parameter to be measured 47 CFR2.1053 Radiated Emissions 6 47 CFR2.1046, 24.232 Power Output 10 Photographs of test sample(s) 11 For copyright details see Page 30 of 30 REPORT NUMBER RO610071 PAGE 2 OF 30

FCC ID: EHA700C-SMC45 Introduction The information contained within this report is intended to show verification of compliance of the Intermec Technologies Corporation 700C-SMC45 to the requirements of 47 CFR 2 and 47 CFR 24. Limited testing has been performed as the 700C-SMC45 contains a Transmitter Module which has previously gained approval to FCC Part 24. The FCC Identifier of this module was QIPMC45, the date of the FCC Grant was th 13 September 2002. Location Of Testing All testing was conducted at the premises of BABT, Segensworth Road, Fareham, Hampshire, PO15 5RH, by BABT Personnel, Simon Bennett , Phil Harrison and Steve Hartley . Radiated Emissions measurements were performed in a 3 metre Anechoic Chamber (OATS). A complete site description is on file with the FCC Laboratory Division, Registration Number: 90987. See Annex A. Test Equipment and Ancillaries Used For Test No Instrument/Ancillary Type Manufacturer EMC No. Cal Due 1 Screened Enclosure ---- Siemens/Matsushita 2533 -- 2 BilogAntenna CBL6143 Chase 2860 11Apr 04 3 Turntable & Controller HD050 Emco 2528 -- 4 Antenna Mast 2070 Emco -- -- 5 Antenna Controller 2090 Emco -- -- 6 EMI Receiver 8542E Hewlett Packard 2286 11 Dec 02 7 Low Noise Amplifier (8- AMF-4E-080180- Miteq 2430 -- 18GHz) 15-10P 8 Spectrum Analyser 8562A Hewlett Packard 1427 7 Jan 03 9 Horn 3115 EMCO 2297 29 Jun 03 10 Signal Generator 8672A Hewlett Packard 411 22 Dec 02 11 3GHz High Pass Filter F-100-3000-5-R RLC Electronics INV4467 -- 12 Signal Generator 2031 Marconi 1980 20 Aug 03 13 Spectrum Analyser FSEM Rohde & Schwarz INV4034 28 Dec 02 14 Digital Radio Test Set 6103E Racal INV4506 2 Aug 03 15 Attenuator HFP-50N Trilithic 1600 30 May 03 16 Combiner 1506A Weinschel Eng. INV4494 15 Jan 03 17 Cable 1 metre N-Type Reynolds CS0561 T/U 18 Thermohygrograph A1 Rotronic INV3227 2 Oct 03 19 Cable 1 metre SMA Reynolds CS0569 T/U Type 20 Attenuator HFP-50N Trilithic 1602 30 May 03 Table 1 REPORT NUMBER RO610071 PAGE 3 OF 30

FCC ID: EHA700C-SMC45 Test Equipment and Ancillaries Used For Test (continued) Note(s) 1) All items are calibrated annually except where labelled T/U (Tracebility Unscheduled). These items are calibrated within the test configurations using calibrated equipment. 2) Throughout the test report the test equipment used for each test is referenced using the number indicated in the table above. INSTRUMENTATION USED FOR EXERCISING THE EUT Instrument Manufacturer Type No INV No GSM Test Set Hewlett Packard 8922M 3803 DCS Test Set Hewlett Packard 83220E 3804 Table 2 REPORT NUMBER RO610071 PAGE 4 OF 30

FCC ID: EHA700C-SMC45 Description of Equipment Under Test The 700C-SMC45 is a handheld computer terminal with a tri band GSM/GPRS radio module used for inventory control purposes. The equipment under test is made up of the following component parts. Module Vendor Kit Number Serial Number Handheld Computer Terminal Intermec Technologies Corporation 700C-SMC45 350450410044088 Table 3 List of Performed Measurements using the configuration in Table 3 i) Power Output Module Vendor Kit Number Serial Number Handheld Computer Terminal Intermec Technologies Corporation 700C-SMC45 19927020017 Table 4 List of Performed Measurements using the configuration in Table 4 i) Radiated Emissions REPORT NUMBER RO610071 PAGE 5 OF 30

FCC ID: EHA700C-SMC45 Test Case Radiated Emissions tth Test Date 10 October 2002 Rule Parts 24.238 System Configuration During EMC Testing The Intermec 700C with GSM/GPRS Radio Module was powered by its own internal battery. A communication link was established between the EUT and a Digital Radiocommunications Test Set. Test Procedure Testing to the requirements of FCC Part 24, Section 24.238, Emission Limits, was carried out on the Measurement Test Facility detailed in Annex A. In order to determine the Radiated Emission Limits, measurements of transmitter power (P) were first carried out on top, middle and bottom channels using a peak detector and the results are shown in Table 5 below. A preliminary profile of the Radiated Electric Field Emissions was obtained by operating the Equipment Under Test (EUT) on a remotely controlled turntable within a semi-anechoic chamber; measurements were taken at a 3m distance. Measurements of emissions from the EUT were obtained with the Measurement Antenna in both Horizontal and Vertical Polarisations. The profiling produced a list of the worst case emissions together with the EUT azimuth and antenna polarisation. Using the information from the preliminary profiling of the EUT, a search was made in the frequency range 30MHz to 20GHz. The list of worst case emissions was then confirmed or updated under Open Site conditions. Emission levels were maximised by adjusting the antenna height, antenna polarisation and turntable azimuth. Emissions levels were then formally measured using a peak detector. The details of the worst case emissions were then recorded and are presented in Tables 6 and 7. The test was performed in accordance with ANSI C63.4. All measurements made at 3m REPORT NUMBER RO610071 PAGE 6 OF 30

FCC ID: EHA700C-SMC45 Test Case : Radiated Emissions (continued) th Test Date : 10 October 2002 Rule Parts : 24.238 TEST RESULTS Measurement of transmitter power (P) on top and bottom channels are detailed in Table 5 below. Freq Res Vid Ant Ant EUT Raw Cable loss Antenna Result BW BW Pol Hgt Arc PEAK / Amp gain Factor Peak MHz Hz Hz V/H cm Deg dBµV dB DB dBµV/m Tx Channel 512 1850.000 1M 3M V 165 180 96.33 2.17 27.4 125.9 1850.400 1M 3M H 100 080 999.50 2.17 27.4 129.1 Tx Channel 810 1909.600 1M 3M V 122 180 95.67 1.83 27.7 125.2 1909.570 1M 3M H 100 073 100.33 1.83 27.7 129.9 Table 5 The limit for spurious emissions in accordance with FCC 47CFR 24.238 is 43dB – 10Log(P) down on the carrier where P is the power in Watts As the manufacturer’s declared power is 1W the spurious limit is 43dB – 10Log(1) = 43dB down on the carrier Using the results obtained on the two channels the following limits were calculated: Bottom channel 512: 125.9dBµV/m – 43dB = 85.9dBµV/m Top channel 810: 125.2dBµV/m – 43dB = 85.2dBµV/m These figures have been used to determine Pass or Fail on the harmonics detailed in Tables 6 and 7: REPORT NUMBER RO610071 PAGE 7 OF 30

FCC ID: EHA700C-SMC45 Test Case : Radiated Emissions (continued) th Test Date : 10 October 2002 Rule Parts : 24.238 Tx Channel 512 Freq Res Vid Ant Ant EUT Raw Cable loss Antenna Result Pass / BW BW Pol Hgt Arc PEAK / Amp gain Factor Peak Fail MHz Hz Hz V/H cm Deg dBµV dB dB dBµV/m 1.93050 1M 3M V 100 270 44.50 -1.67 27.75 73.92 Pass 1.96800 1M 3M V 100 270 45.17 -1.83 28.00 75.00 Pass 3.70061 1M 3M V 130 180 44.50 +8.50 32.33 68.33 Pass 5.55039 1M 3M V 100 195 54.83 +23.5 35.00 66.33 Pass 7.40060 1M 3M H 100 195 53.67 +27.0 38.00 64.64 Pass 9.25050 1M 3M H 110 100 50.33 +23.0 39.0 66.33 Pass Table 6 All emissions measured over the frequency range <1GHz were greater than 49.4 dBµV/m below the limit shown above. Tx Channel 810 Freq Res Vid Ant Ant EUT Raw Cable loss Antenna Result Pass / BW BW Pol Hgt Arc PEAK / Amp gain Factor Peak Fail MHz Hz Hz V/H cm Deg dBµV dB dB dBµV/m 1.9673 1M 3M V 100 263 44.17 -1.83 28.00 74.00 Pass 1.9899 1M 3M V 100 251 44.33 -1.50 28.0 73.83 Pass 3.8196 1M 3M H 110 198 42.83 +11.33 32.67 64.17 Pass 5.7292 1M 3M H 100 195 58.0 +24.66 35.25 68.59 Pass 7.6389 1M 3M H 100 195 53.67 +26.16 38.67 66.18 Pass 9.5491 1M 3M V 135 265 53.67 +23.50 39.25 69.42 Pass 11.4584 1M 3M V 100 193 51.67 +21.33 39.75 70.09 Pass Table 7 All emissions measured over the frequency range <1GHz were greater than 47.7dBµV/m below the limit shown above. ABBREVIATIONS FOR ABOVE TABLE ERP Effective Radiated Power H Horizontal Polarisation V Vertical Polarisation Procedure Test Performed in accordance with ANSI C63.4. REPORT NUMBER RO610071 PAGE 8 OF 30

FCC ID: EHA700C-SMC45 TEST SETUP PHOTOGRAPH The photograph below shows the EUT configuration during Radiated Emission testing. REPORT NUMBER RO610071 PAGE 9 OF 30

FCC ID: EHA700C-SMC45 Test Case : RF Output Power nd Test Date : 22 October 2002 Rule Parts : 2.1046, 24.232 Measurement Method Using a spectrum analyser and attenuator(s), the output power of the EUT was measured at the antenna terminal. The carrier power was measured on each channel on Power Setting 0. The spectrum analyser RBW and VBW were set to 1MHz and the path loss measured and entered as a reference level offset. Results Maximum Power - Power Setting 0 Frequency Output Power Path Loss (dB) Result Result (MHz) (dBm) (dBm) (W) 1850.2 +2.33 27.79 +30.12 1.028 1880.0 +1.74 27.42 +29.16 0.824 1909.8 +1.91 27.44 +29.35 0.861 Minimum Power - Power Setting 7 Frequency Output Power Path Loss (dB) Result Result (MHz) (dBm) (dBm) (mW) 1850.2 -11.43 27.79 +16.36 0.043 1880.0 -11.87 27.42 +15.55 0.036 1909.8 -11.76 27.44 +15.68 0.037 Limit <100W or <+50dBm Remarks EUT complies with CFR 47 2.1046 and 24.232(b). The EUT does not exceed 2W or +33dBm at the measured frequencies. Test Equipment Used: 13, 14, 15, 16, 17, 18, 19, 20 ………………………………………….. REPORT NUMBER RO610071 PAGE 10 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Front REPORT NUMBER RO610071 PAGE 11 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Rear REPORT NUMBER RO610071 PAGE 12 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Side/End REPORT NUMBER RO610071 PAGE 13 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Side/Top REPORT NUMBER RO610071 PAGE 14 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Side/Top (SIM cover removed) REPORT NUMBER RO610071 PAGE 15 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Rear (battery removed) REPORT NUMBER RO610071 PAGE 16 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 1 REPORT NUMBER RO610071 PAGE 17 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 2 REPORT NUMBER RO610071 PAGE 18 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 3 REPORT NUMBER RO610071 PAGE 19 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 4 REPORT NUMBER RO610071 PAGE 20 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 5 REPORT NUMBER RO610071 PAGE 21 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 6 REPORT NUMBER RO610071 PAGE 22 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 7 REPORT NUMBER RO610071 PAGE 23 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 8 REPORT NUMBER RO610071 PAGE 24 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 9 REPORT NUMBER RO610071 PAGE 25 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 10 REPORT NUMBER RO610071 PAGE 26 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 11 REPORT NUMBER RO610071 PAGE 27 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Internal 12 REPORT NUMBER RO610071 PAGE 28 OF 30

FCC ID: EHA700C-SMC45 700C-SMC45 Antennas REPORT NUMBER RO610071 PAGE 29 OF 30

FCC ID: EHA700C-SMC45 0141 Group UKAS Accreditations do not cover opinions and interpretations and any expressed herein are outside the scope of any UKAS Accreditation. Results of tests not yet included in our UKAS Accreditation Schedule are marked NUA (Not UKAS Accredited).  2002 BABT This report must not be reproduced without the written permission of BABT REPORT NUMBER RO610071 PAGE 30 OF 30

FCC ID: EHA700C-SMC45 Annex A FCC Measurement Facility Compliance Letter (comprising of 1 page) REPORT NUMBER RO610071

1C45 C) B A B T FEDERAL COMMUNICATIONS COMMISSION Laboratory Division 7435 Oakiand Mills Road Columbia, MD 21046 October 18, 2002 Registration Number: 90987 TUV Product Service Lid Segensworth Road Titchficld Farcham, Hampshire, PO1S SRH United Kingdom Attention: Kevan Adsetts Re: Measurement facility located at Titchfield Anechoic chamber (3 meters) and 3 & 10 meter OATS Date of Listing: October 18, 2002 Gentlemen: Your request for registration ofthe subject measurement facility has been reviewed and found to be in compliance with the requirements ofSection 2.948 ofthe FCC rules. The information has, therefore, been placed on file and the name of your organization added to the list of facilities whose measurement data will be accepted in conjunction with applications for Certification under Parts 15 or 18 ofthe Commission‘s Rules. Please note that the file must be updated for any changes made to the facility and the registration must be renewed at least every three years. Measurement facilities that have indicated that they are available to the public to perform measurement services on a fee basis maybe found on the FCC website wwwr.fee.gov under E—Filing, OET Equipment Authorization Electronic Filing, Test Firms. th.stlly Sincerely, . Thomas W Phillips Electronics Engineer


Document Created: 2002-11-18 16:36:54
Document Modified: 2002-11-18 16:36:54
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC