Test Report

FCC ID: FIH11010533402

Test Report

Download: PDF
FCCID_16105

ROGERS Labs, Inc. 4405 West 259TH Terrace * Louisburg, KS 66053 + PHOCNE & FAX: (918) 837—3214 FCC CERTIFICATION REPORT ELECTROMAGNETIC INTERFERENCE [ TEST RESULTS For CFR 47 Part 1 5C I mntentional Radiators Pr 15.245 FOR IN JITERMEC TECHNOLOGIES CO RPORATION AMTECH SYSTEMS DIVI SION 8600 Jefferson Stree t, NE Albuquerque, NM 87 113 Phone : {(505) 85 6—8 054 Wes Mays, Manager of Microwave I)esigns MODEL: AH11l0O1l—OG( 1 HAND HELD READEE: FCC ID#: FIH110105]3 3402 Test Date: August 28, 1998 Certifying Enginee _ cotDfaga Scot D. Rogers | ROGERS LABS, INC. || | 4405 W. 259th Terrac | | | Louisburg, KS 66053 | | Phone: (913) §37—3214 | FPAX : (913) 837—3214 I This report shall not be reproduced @xcept in full, without the written approval of i he laboratory. This report must not|be used by the client to claim product endorsement by NVLAP or any agency of the U.S. Govern) ment.

NVLAP Accredited Laboratory NVLAP Lab Code: 200087—0 TABLES OF CONTENTS GENERAL INFORMATION 3 Name of Applicant: 3 Technical Information: 3 1) APPLICABLE STANDARDS & TEST PROCEDURES 3 2) EQUIPMENT TESTED 4 3) EQUIPMENT AND CABLE CONFIGURATION 4 Conducted Emission Test Procedure: 4 Radiated Emission Test Procedure: 4 4) LIST OF TEST EQUIPMENT 5 5) UNITS OF MEASUREMENT 5 6) TEST SITE LOCATION 6 7) MEASUREMENT PROCEDURES 6 Conducted EMI: 6 Radiated EMI: 7 8) DATA 9 Conducted (6 Highest Emissions): 9 Radiated (8 Highest Emissions): 9 Summary of Results: 10 9) SUBPART C INTENTIONAL RADIATORS 10 10) DATA 12 Radiated Emissions Intentional Radiator: 12 Radiated (8 Highest Emissions): 13 Summary of Results: 14 APPENDIX 15 ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPORATION AMTECH SYSTEMS DIVISION 4405 w. 259th Terrace MODEL: AHIllO1l—001l HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#: FIHK11010533402 Phone/Fax: (913) 837—3214 Test to:Part 15 C, Paragraph 15.245 Page 2 of 24

NVLAP Accredited Laboratory NVLAP Lab Code: 200087—0 GENERAL INFORMATION Name of Applic%nt: | INTERMEC TECHNOLOGIES CORPORATION AMTECH SYSTEMS DIVISION 8600 Jefferson Street, NE Albuquerque, |NM 87113 Technical Information: Model : AHI1O1—001 HANDHELD READER FPCC I.D.: FIH11010533402 Frequency Range: 902 to 928 MHz Bandwidth (99.5%) 40 kHz [ 1) Applicable Standards & Test Procedures a) In accordance with Part 1, Subpart G, Paragraphs 1.1103; |Part 2, Subpart J, Paragraphs 2.907, 2 .925, 2.926, 2.947 2.1031 through 2.1043, and Part 15, Subpart |C, Paragraphs 15.19( A) (3), 15.21, 15. 27 (C) , 15 .105 (A ) . 15.107, 15.109, 15. 201 (B ) , 15.203 15.205, 15,.209, |and 15.245 of the Code of Federal Regulations, dated Ogtober 1, 1997. The transition provisions in paragraph 15.37(d) are not being requested. Test procedures used are the established Methods of Measurement of Radio—Noise Emissions as described in the ANSI 63.4—1992 Document. ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPORATION AMTECH SYSTEMS DIVISION 4405 wW. 259th Terrace MODEL: AH1I101—001l HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#: FIH11010533402 Phone/Fax: (913) §837—3214 Test to:Part 15 C, Paragraph 15.245 Page 3 of 24 CERTIFICATION\AMTAHOO1 11/18/98

NVLAP Accredited Labo Fratory NVLAP Lab Code: 200087—0 2) Equipment Tested EUT PCC I .D.# AHLlOL1—O 01 FIH11L 010533402 PC—9000 FEKGPC 9000 KX—P1092 ACJI6 NKX—P1092 3) Equipment an d Cable Configuration Conducted Emilsion Test Procedure: The test setu P ¢ including the EUT, yvas arranged in a typical equipment con| figuration and placed on a 1 x 1.5 meter wooden bench, 0.8 me ters high located in a screen room. The power lines of the system were isolated f£1 rom the power source using a standard LI SN with a 50 uHy choke EMI was coupled to the spectrum anal yzer through a 0.1 uF éapacitor internal to the LISN. The LI SN was positioned on the floor beneath the wooden bench supporting the EUT. The power lines and cables were draped o ver the back edge of the table. Radiated Emissi on Test Procedure: The test setu P . including the EUT, was placed on top of a rotatable, 1 X 1.5 meter, wooden ta ble, 0.8 meters above the ground plane. The receiving antenna was located on a variable heig ht antenna mast 3 mete rs from the table supporting tH e EUT and test system. The antenna height was varied betwes n 1 and 4 meters above the ground plane and the ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORP RATION AMTECH SYSTEMS DIVISION 4405 wW.259th Terrace MODEL: AH1lO01—001 HANDHELI READER Louisburg, KS 66053 Test #: 980828—1 FCCID#: FIH11010533402 Phone/Fax : (913) 837—321 Test to:Part 15 C, Paragraph 15.245 Page 4 of 24 CERTIFICATION\AMTAHOOL 11/18/98

NVLAP Accredited Labo ratory NVLAP Lab Code: 200087—0 antenna polar fization was varied between horizontal and vertical. The ; measured radiated EMI level was maximized by equipment pla icement, cable location and table rotation before data w jas taken using a spectrum analyzer. 4) List of Test E¢ qjuipment A Hewlett Pag kard 8591EM and/or 8562A Spectrum Analyzer was used as the 1 easuring device for the emissions testing. The analyzer sett ings used are described in the following table. Refer to Appe ndix for a complete list of test equipment. HP 8591 EM ANALYZER SETTINGS CONDUCTED EMISSIONS: RBW AVG. BW DETECTOR FUNCTION 9 kHz 30 kHz Peak/Quasi Peak RADIATED EMISSF[ONS: RBW AVG. BW DETECTOR FUNCTION 120 kHE 300 kHz | Peak/Quasi Peak HP8562A ANALYZER SETTINGS RBW VIDEO BW DETECTOR FUNTION 100 kHzZ 100 kHz Peak 1 MHz 1 MHz Average 5) Units of Measurement Conducted EMI: Data is in dBuV; dB referenced to one microvolt. ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPDRATION AMTECH SYSTEMS DIVISION 4405 w. 259th Terrace MODEL: AH11lO1l—001l HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#:| FIH11010533402 Phone/Fax: (913) 837—3214 Test to:Part 15 C, Paragraph 15.245 Page 5 of 24 CERTIFICATION\AMTAHOO1 12/1/98

NVLAP Accredited Laboratory NVLAP Lab Code: 200087—0 Radiated EMI : Data is in dBuV/m; dB/m referenced to one microvolt per meter. Calculations : RFPS Radiated field strength (dBuV/m) @ 3m RFS FSM (dBuV) + A.F. (dB/m) — Amp. Gain (dB) RFS 33.3 (dBuV) + 9.2 (dB/m) — 35 (dB) RFS 7.5 (dBuV/m) 6) Test Site Locétion Conducted EMI: The AC powerline conducted emissions tests were performed in a shielded screen room located at ROGERS LABS, INC., 1 4 405 W. 259th Terrace, Louisburg, KS. Radiated EMI: The radiated emissions tests were performed at ROGERS LAB S, INC. 3 meter open area test site (OATS) located in Louisburg, KS . Site Approval: Refer to Appendix for FCC Site Approval Letter, Reference 31040/SIT 1300Fr2, Dated February 6, 1998. 7) Measurement Procedures Conducted EMI: The EUT was a rranged in a typical equipment confiqguration and placed on a 1 x 1.5 meter wooden bench 80 cm above the conducting gr ound plane, floor of a screen room. The bench was positione d 40 cm away from the wall of the screen room. The LISN was positioned on the floo of the screen room 80 cm ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPORATION AMTECH SYSTEMS DIVISION 4405 w. 259th Terrace MODEL: AH11l01—001l HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#:| FIH11010533402 Phone/Fax : (913) 837—321 4 Test to:Part 15 C, Paragraph 15.245 Page 6 of| 24 CERTIFICATION\AMTAHOO1 [12/1/98

NVLAP Accredited Laboratory NVLAP Lab Code: 200087—0 from the rear of the EUT. The power cord of the EUT was connected to |the LISN. _A second LISN was positioned on the floor of the |screen room 80 cm from the rear of the supporting equipment. All power cords except the EUT were then powered |from the second LISN. EMI was coupled to the spectrum anallyzer through a 0.1 uF capacitor, internal to the LISN. Power |line conducted emissions testing was carried out individually |for each current carrying conductor of the EUT. The excess length of lead between the system and the LISN receptacle wals folded back and forth to form a bundle not exceeding 40 |cm in length. The screen room, conducting ground plane, analyzer and LISN were bonded together to the protective ealrth ground. Preliminary testing was performed to identify the frequencies of the emissions that had the highest ampliitudes. The cables were |repositioned to obtain maximum ampliitude of measured EMI level. Once the worst case configuration| was identified, plots |were made of the EMI from 0 .15 MHz to 30 MHz then the data was recorded with maximum conducted emissions levels. Radiated EMI: The EUT was alrranged in a typical equipment configuration and operated through all of its various |modes. The interconnecting cables of the EUT and supporting equipment were manipulated such as to obtain maximum levels of radiated ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPORATION AMTECH SYSTEMS DIVISION 4405 w. 259th Terrace MODEL: AHI1101l—00l HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#: FIR11010533402 Phone/Fax: (913) 837—321 Test to:Part 15 C, Paragraph 15.245 Page 7 of 24 im CERTIPICATION\AMTAKOOL 11/18/98

NVLAP Accredited Labo ratory NVLAP Lab Code: 200087—0 emissions wit hin the range of likely configurations. Preliminary t esting was performed in a screen room with the EUT positione d 1 meter from the FSM. Radiated emissions measurements were performed to identify the frequencies that produced the highest emissions. Plots were made of the frequency spe ctrum from 30 MHz to 1000 MHz for the preliminary t esting. The EUT, supporting equipment and cable locations wer e noted and reconfigured at the open field test site. The hi ghest radiated emission was then re—maximized at this location before final radiated emissions measurements were performe d. Final data was taken with the EUT located at the open fiel d test site at a distance of 3 meters between the EUT and t he receiving antenna. The frequency spectrum from 30 MHz t o 1000 MHz was searchefi for radiated emissions. Measured emis sion levels were maximfized by EUT placement on the table, ch anging cable location, |rotating the turntable through 360 d eqgrees, varying the antenna height between 1 and 4 meters abov e the ground plane andichanging antenna polarization between horizontal and vertical. Antennas used were Broadban d Biconical from 30 MH# to 200 MHz, Biconilog from 30 MHz to 1000 MHz, Log Periodic from 200 MHz to 5 GHz and/or pyrami dal horn antennas from 5 to 40 GHz. ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPQRATION AMTECH SYSTEMS DIVISION 4405 W. 259th Terrace MODEL: AH11lO1l—001l HANDHELI) READER Louisburg, KS 66053 Test #: 980828—1 FCCID#: FIH11010533402 Phone/Fax: (913) 837—321 Test to:Part 15 C, Paragraph 15.245 Page 8 of 24 dn CERTIFICATION\AMTAHOO1 11/18/98

NVLAP Accredited Laboratory NVLAP Lab Code: 200087—0 8) DATA Conducted (6 Highest Emissions): 1 .4 29. 29. 60 .0 3.8 29. 27 .5 69.5 3.9 30. 31. 69.5 4. 26. 27. 69.5 w 12 .7 23. 4 28. 69 .5 in 20 .0 26.5 27. 69.5 w Other emissions present had amplitudes at least 10 dB below the limit. Radiated (8 Highest Emissions): 35 .0 35 40 .0 35 40 .0 35 43 .5 35 43 .5 9. 35 43.5 15. 35 46.0 16. 35 &0 COMPUTER SY$TEM 120 .0 53 57. 8 .8 35 27. 30. 43 .5 140.0 64 63. 10 .2 35 39. 38 . 43.5 155.5 53 48 . 10 .4 35 29. 24. 43 .5 160.0 48 53. 10. 35 23. 28 . 43 .5 180 .0 55 52. 9. 35 30. 27. 43 .5 265 .0 53 49. 12. 35 30. 27. 46.0 278 .2 47 50 .8 13.5 35 25 .5 29.3 46 .0 298 .6 49} 7 54 .9 13.5 35 28 .2 33. 4 46.0 Other emissions| present had amplitudes at |least 10 dB below the limit. ROGERS LABS, INC. INTERMEC TECHNOLOGIES CO RATION AMTECH SYSTEMS DIVISION 4405 w. 259th Terrace MODEL: AH11lOl—00l HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#:| FIH11010533402 Phone/Fax: (913) §37—32 Test to:Part 15 C, Paragraph 15.245 Page 9 of 24 CERTIFICATION\AMTAHOOL 11/18/98

NVLAP Accredited Labo ratory NVLAP Lab Code: 200087—0 Summary of Results: Conducted Emissions: The conductedl emissions for the EUT meets the requirements for FCC Part 15B Digital Devices with a 30.1 dB margin below the limit. 0 ther emissions were present with amplitudes at least 10 dB below the FCC CLASS A linmit. Radiated EmiTsions The radiated emissions for the EUT meets the requirements for FCC Part 15B Digital Devices with a 12.7 dB margin below the limit. Other emissions were present with amplitudes at least 10 dB below t he FCC CLASS A limit. Statement of Modifications No modificati ons to the EUT were required for the unit to meet the FCC Part 15B CLASS A emissions standards. There were no deviations to the specifications. 9) SubPart C Intentional Radiators As per CFR Part 15, SubPart C. The following information is submitted: 15.203 Antenna requirement: The antenna is etched on to the printed circuit board and can not be removed. Therefore, the antenna system is attached such that the requirements of Paragraph 15. 203 are met. ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPORATION AMTECH SYSTEMS DIVISION 4405 w. 259th Terrace MODEL: AHIlO1l—00l HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#:| FIH11010533402 Phone/Fax: (913) 837—321 4 Test to:Part 15 C, Paragraph 15.245 Page 10 of 24 CERTIFICATION\AMTAHOOL 12/1/98

NVLAP Accredited Laboratory NVLAP Lab Code: 200087—0 i ao 15.205 Restricted Band of Operation}t Spurious emissions falling into the restricted frequency bands of operation were measured at the OATS. The EUT utilizes frequency determining circuitry which generates harmonics falling into the restricted bands. These emissions were measured using log periodic and/or pyramidal horn antennas, amplification stages and a spectrum analyzer. No other significant emissijons were recorded which fell in the restricted bands of operatiion. . Frequency RES Horz. REFS FCC CLASS A . @ 3m vert. C Limit @ 3m (aBuy) _ (dBpvy/m) {(aBpV¥y/m) 54 .0 5481.0 40 .0 40 .2 41 .2 35 46.2 46. 4 54 .0 15.245 Operation within the Frequency Band 902—928 MHz: The field strength of emissions from the EUT was measured at the OATS at a distance of 3 meters.; The fundamental jand harmonics were investigated for thrée different freqfiencies and recorded in the following table. ROGERS LABS, INC. | INTERMEC TECHNOLOGIES CORPOQRATION AMTECH SYSTEMS DIVISION 4405 W. 259th Terrace ! MODEL: AHIllO1—00l HANDHELD READER | Louisburg, KS 66053 | Test #: 980828—1 FCCID#:]| FIH11010533402 Phone/Fax: (913) 837~32J(4 Test to:Part 15 C, Paragraph 15.245 Page 11 of 24 CERTIFICATION\AMTAHOO1 11/18/98

NVLAP Accredited Laboratory NVLAP Lab Code: 200087—0 10) DATA Radiated Emiss fons Intentional Radiator: ipgaes 913 .6 94 . 6 80 .1 22 .4 25 92 . 0 77 .5 1827 .4 39 .5 41 .1 27 .7 25 42 .2 43 .8 2741 .2 40 .0 40 .3 20 .6 25 35 .6 35 .9 3654 .8 41 .8 40 .8 20 .6 25 37 .4 36 .4 4568 .5 41 .6 40 . 6 20 .6 25 37 .2 36 .2 915 .0 96 .6 82 .7 22 .4 25 94 .0 80 .1 1830 .0 43 .3 44 .6 27 .7 25 46 .0 47 .3 2745 .0 43 .1 43 .3 20 .6 25 38 .7 38 .9 3660 .0 45 .1 45 .1 20 .6 25 40 .7 40 .7 4575 .0 4 4 .3 4 4 .1 20 .6 25 39 .9 37 .9 916 .7 96.3 82 .8 22 .4 25 93 . 7 80 .2 1833 .4 42 .3 43 .3 27 .7 25 45 .0 46 .0 2750 .1 41 .8 43 .3 20 .6 25 37 .4 38 .9 3666 .8 4 4 .3 42 .1 20 .6 25 39 .9 37 .7 4583 .5 44 .5 44 .1 20 .6 25 41 .1 39 .7 ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPORATION AMTECH SYSTEMS DIVISION 4405 w. 259th Terrace MODEL: AHI11l01—001l HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#: FIH11010533402 Phone/Fax: (913) 837—321 Test to:Part 15 C, Paragraph 15.245 Page 12 of 24 CERTIFICATION\AMTAKOOL 11/18/98

NVLAP Accredited Labokatory NVLAP Lab Code: 200087—0 Radiated (8 Highest Emissions): Limit G .0 35 7 . w s on o o .0 t 35 18 . w in n o & 0 35 20. s O w o 0 .0 35 26. c 0 o O a@ &0 35 31. J o t o |[B &1 35 26. oo N n i t . 0 15. 35 17. J O |.b |if 0 .0 16. 35 36. w J O &0 O COMPUTER SYSTEM 120. 53 4 57. 8 .8 35 27. 30. 43. 0 n 140. 64 1 63. 10. 35 39. 38 . 43. N on 155. 53 9 48 . 10. 35 29. 24 . 43 . on w 160. 48 3 53. 10. 35 23. 28 . 43. O on 180. 55 8 52. 9. 35 30. 27 . 43. o n 265. 53 5 49. 12. 35 30. 27 . 46. O _\ 278 . 47 0 50. 13. 35 25. 29. 46 . 0 O 298 .6 49 7 54. 13. 35 28 .2 33 .4 46. O w Other emissions|present had amplitudes at least 10 dB below the linmit. For frequenciles above 1000 MHz the average detector function was used. No/ emission had peak amplitude that exceeded the limits by 20 ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPQRATION AMTECH SYSTEMS DIVISION 4405 w. 259th Terrace MODEL: AHI1lO01—001 HANDHELD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#: FIK11010533402 Phone/Fax: (913) 8§37—3214 Test to:Part 15 C, Paragraph 15.245 Page 13 of 24 CERTIFICATION\AMTAHOOL 11/18/98

NVLAP Accredited Labokratory NVLAP Lab Code: 200087—0 Summary of Results: The radiated emissions for the EUT meet the requirements for FCC Part 15C Intentional Radiators. There are no measurable emissions in the restricted bands other than those recorded in this repor t. Statement of Modifications : No modificati ons were required for the EUT to meet the requirements of Part 15. There were no deviations to the specification S . ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORPQRATION AMTECH SYSTEMS DIVISION 4405 W. 259th Terrace MODEL: AH1I1lO01—001 HANDHELID READER Louisburg, KS 66053 Test #: 980828—1 FCCID#:| FIH11010533402 Phone/Fax: (913) §37—321 4 Test to:Part 15 C, Paragraph 15.245 Page 14 of 24 CERTIFICATION\AMTAHOO1 11/18/98

NVLAP Accredited Laboratory NVLAP Lab Code; 200087—0 APPENDIX Photos Conducted Emissions Setup Photos Radiated Emissions Setup Photos of Case Front and Back Photos Inside of Case Photos Printed Circuit Board Photo FCC Label Location Test Equipment List Rogers Qualifications ( PCC Site Approval Letter | | | | ROGERS LABS, INC. INTERMEC TECHNOLOGIES CORKORATION AMTECH SYSTEMS DIVISION 4405 W. 259th Terrace MODEL: AH11lOl—001l HANDHEIJD READER Louisburg, KS 66053 Test #: 980828—1 FCCID#:! FIH11010533402 Phone/Fax : (913) §37—3214 Test to:Part 15 C, Paragraph 15.245 Page 15 of 24 CERTIFICATION\AMTAHOOL 11/18/98


Document Created: 1998-12-14 11:44:44
Document Modified: 1998-12-14 11:44:44
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC