TEST REPORT

FCC ID: BY33129-49SV

Test Report

Download: PDF
FCCID_873711

849 NW State Road 45 Newberry, Fl 32669 USA Phone: 888.472.2424 or 352.472.5500 Fax: 352.472.2030 Email: info@timcoengr.com Website: www.timcoengr.com FCC PART 15 B SUBPART B RECEIVER TEST REPORT Applicant SCIENTIFIC TOYS, LTD. Address RM. 1108, 11/F., BLOCK B, NEW MANDARIN PLAZA 14 SCIENCE MUSEUM ROAD TST KOWLOON HONG KONG FCC ID BY33129-49SV Product Description 49 MHZ REMOTE CONTROL RECEIVER Date Sample Received 11/19/2007 Date Tested 11/28/2007 Tested By RICHARD BLOCK Approved By MARIO DE ARANZETA Report Number 3614UT7TestReport.doc Test Results PASS FAIL THE ATTACHED REPORT SHALL NOT BE REPRODUCED EXCEPT IN FULL WITHOUT THE WRITTEN APPROVAL OF TIMCO ENGINEERING, INC. Certificate # 0955-01

TABLE OF CONTENTS GENERAL REMARKS................................................................................................. 3 REPORT SUMMARY................................................................................................... 4 TEST ENVIRONMENT ................................................................................................ 4 TEST SETUP SUMMARY ............................................................................................ 4 DUT SPECIFICATION................................................................................................. 5 TEST EQUIPMENT LIST............................................................................................. 6 TEST PROCEDURES ................................................................................................. 7 RADIATED SPURIOUS EMISSIONS............................................................................ 8 POWER LINE CONDUCTED INTERFERENCE........................................................... 10 RADIATED EMISSIONS TEST SETUP PHOTO .......................................................... 11 APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 2 of 11 mdea 09.20.2007

GENERAL REMARKS The attached report shall not be reproduced except in full without the written permission of Timco Engineering Inc. Summary The device under test does: fulfill the general approval requirements as identified in this test report not fulfill the general approval requirements as identified in this test report Attestations This equipment has been tested in accordance with the standards identified in this test report. To the best of my knowledge and belief, these tests were performed using the measurement procedures described in this report. All instrumentation and accessories used to test products for compliance to the indicated standards are calibrated regularly in accordance with ISO 17025 requirements. Certificate # 0955-01 I attest that the necessary measurements were made, under my supervision, at: Timco Engineering Inc. 849 NW State Road 45 Newberry, Fl 32669 Authorized Signatory Name: Mario de Aranzeta Mario de Aranzeta C.E.T. Compliance Engineer/ Lab. Supervisor Date: 11/28/07 APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 3 of 11 mdea 09.20.2007

REPORT SUMMARY Disclaimer The test results only relate to the item tested. Applicable Rule(s) Pt 15.109, Pt 15.107, ANSI C63.4: 2003 Related Report None TEST ENVIRONMENT Test Facility Timco Engineering, Inc. 849 NW State Road 45 Newberry, FL 32669 USA. Test Condition in the Temperature: 26ºC laboratory Relative humidity: 50% TEST SETUP SUMMARY Test Setup Diagram/ The DUT was placed on the turntable per setup per ANSI Description C63.4: 2003. A test set up photo is provided for clarification. Deviation from the No deviation standard/procedure Modification of DUT No modification APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 4 of 11 mdea 09.20.2007

DUT SPECIFICATION The test results relate only to the items tested. DUT Description 49 MHZ REMOTE CONTROL RECEIVER FCC ID BY33129-49SV DUT Power Source 110–120Vac/50– 60Hz DC Power Battery Operated Exclusively Test Item Prototype Pre-Production Production Type of Equipment Fixed Mobile Portable Laboratory Temperature: 26ºC Test Conditions Humidity: 55% Modifications to DUT: No Yes (explanation below) APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 5 of 11 mdea 09.20.2007

TEST EQUIPMENT LIST Device Manufacturer Model Serial Cal/Char Due Date Number Date 3/10-Meter TEI N/A N/A Listed 3/19/10 OATS 3/20/07 3-Meter TEI N/A N/A Listed 1/10/09 OATS 1/11/06 3-Meter Panashield N/A N/A Listed 5/10/10 Semi- 5/11/07 Anechoic Chamber Antenna: Eaton 94455-1 1057 CAL 12/12/07 Biconnical 12/12/05 Antenna: Eaton 94455-1 1096 CAL 10/11/08 Biconnical 10/11/06 Antenna: Electro- BIA-25 1171 CAL 7/18/09 Biconnical Metrics 7/18/07 Analyzer HP 85650A 2811A01279 CAL 5/17/09 Blue Tower 5/17/07 Quasi-Peak Adapter Analyzer HP 85685A 2926A00983 CAL 5/17/09 Blue Tower 5/17/07 RF Preselector Analyzer HP 8568B 2928A04729 CAL 5/17/09 Blue Tower 2848A18049 5/17/07 Spectrum Analyzer LISN Electro- ANS-25/2 2604 CAL 10/5/08 Metrics 10/5/06 LISN Electro- EM-7820 2682 CAL 7/23/09 Metrics 7/23/07 Antenna: Eaton 96005 1243 CAL 12/14/07 Log- 12/14/05 Periodic APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 6 of 11 mdea 09.20.2007

TEST PROCEDURES Power line conducted Emission: The test procedure used was ANSI C63.4-2003. The spectrum was scanned from 0.15 to 30 MHz. Radiation Interference: The test procedure used was ANSI C63.4-2003 using a spectrum analyzer with a preselector. The bandwidth of the spectrum analyzer was 100 kHz with an appropriate sweep speed. The analyzer was calibrated in dB above a microvolt at the output of the antenna. The video bandwidth was always greater than or equal to the RBW. The frequency was scanned from 30 MHz to 1.0 GHz. When an emission was found, the table was rotated to produce the maximum signal strength. The DUT was measured in three (3) orthogonal planes when necessary. Formula Of Conversion Factors: The field strength at 3m was established by adding the meter reading of the spectrum analyzer (which is set to read in units of dBuV) to the antenna correction factor supplied by the antenna manufacturer. The antenna correction factors are stated in terms of dB. The gain of the preselector was accounted for in the spectrum analyzer meter reading. Example: Freq (MHz) Meter Reading + ACF +CL = FS 33 20 dBuV + 10.36 dB/m +0.40 dB =30.36 dBuV/m @ 3m ANSI C63.4-2003 Measurement Procedures: The unit under test was placed on a table 80 cm high and with dimensions of 1mby 1.5m. The table used for radiated measurements is capable of continuous rotation. When an emission was found, the table was rotated to produce the maximum signal strength. At this point, the antenna was raised and lowered from 1m to 4m. The antenna was placed in both the horizontal and verticals planes. APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 7 of 11 mdea 09.20.2007

RADIATED SPURIOUS EMISSIONS Rules Part No.: 15.109 Requirements: Frequency MHz Limits 30 – 88 40.0 dBµV/m measured @ 3 meters 80 – 216 43.5 dBµV/m measured @ 3 meters 216 – 960 46.0 dBµV/m measured @ 3 meters Above 960 54.0 dBµV/m measured @ 3 meters Test Data: Tuned Emission Meter Ant. Coax Correction Field Margin Frequency Frequency Reading Polarity Loss Factor Strength dB MHz MHz dBuV dB dB dBuV/m 49.9 47.56 20.0 V 0.49 10.56 31.05 8.95 49.9 52.11 18.1 V 0.51 10.93 29.54 10.46 49.9 55.42 16.7 V 0.52 11.05 28.27 11.73 49.9 80.23 16.8 V 0.60 7.52 24.92 15.08 49.9 81.73 18.8 V 0.60 7.67 27.07 12.93 49.9 83.26 18.0 V 0.61 7.83 26.44 13.56 49.9 84.79 23.4 V 0.61 7.98 31.99 8.01 49.9 85.46 16.1 V 0.61 8.10 24.81 15.19 49.9 86.19 19.0 V 0.62 8.26 27.88 12.12 49.9 86.58 16.8 V 0.62 8.35 25.77 14.23 49.9 87.37 17.1 V 0.62 8.52 26.24 13.76 49.9 87.74 18.7 V 0.62 8.60 27.92 12.08 49.9 88.09 16.9 V 0.62 8.68 26.20 17.30 49.9 88.50 17.1 V 0.62 8.77 26.49 17.01 49.9 88.89 16.0 V 0.62 8.86 25.48 18.02 49.9 89.29 18.4 V 0.62 8.94 27.96 15.54 49.9 89.65 16.6 V 0.62 9.02 26.24 17.26 49.9 90.79 21.4 V 0.63 9.32 31.35 12.15 49.9 91.19 17.1 V 0.63 9.43 27.16 16.34 49.9 91.58 16.0 V 0.63 9.54 26.17 17.33 49.9 91.94 16.2 V 0.63 9.64 26.47 17.03 49.9 92.31 19.0 V 0.63 9.75 29.38 14.12 49.9 92.69 16.9 V 0.63 9.85 27.38 16.12 49.9 93.12 16.5 V 0.63 9.97 27.10 16.40 APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 8 of 11 mdea 09.20.2007

TEST DATA CONTD. Tuned Emission Meter Ant. Coax Correction Field Margin Frequency Frequency Reading Polarity Loss Factor Strength dB MHz MHz dBuV dB dB dBuV/m 49.9 93.83 18.9 V 0.63 10.17 29.70 13.80 49.9 182.67 15.3 H 0.83 16.67 32.80 10.70 49.9 191.38 18.2 H 0.87 17.27 36.34 7.16 49.9 191.47 18.1 V 0.87 17.61 36.58 6.92 49.9 196.74 17.3 H 0.89 17.13 35.32 8.18 49.9 197.11 17.0 V 0.89 17.23 35.12 8.38 49.9 201.77 17.0 H 0.90 12.05 29.95 13.55 49.9 201.85 17.4 V 0.90 11.91 30.21 13.29 49.9 224.70 15.8 H 0.95 11.45 28.20 17.80 49.9 227.64 17.2 V 0.96 11.23 29.39 16.61 49.9 229.04 18.2 H 0.96 11.49 30.65 15.35 49.9 237.22 15.5 H 0.97 11.86 28.33 17.67 49.9 237.70 15.3 V 0.98 11.84 28.12 17.88 APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 9 of 11 mdea 09.20.2007

POWER LINE CONDUCTED INTERFERENCE Rules Part No.: Part 15.107 Requirements: Frequency Quasi Peak Limits Average Limits (MHz) (dBuv) (dBuV) 0.15 – 0.5 66 – 56 * 56 – 46 * 0.5 – 5.0 56 46 5.0 – 30 60 50 * Decrease with logarithm of frequency Test Data: Not applicable. Battery operated device. APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 10 of 11 mdea 09.20.2007

RADIATED EMISSIONS TEST SETUP PHOTO APPLICANT: SCIENTIFIC TOYS LTD. FCC ID: BY33129-49SV REPORT: W:\S\SCIENTIF\3614UT7\3614UT7TestReport.doc Page 11 of 11 mdea 09.20.2007


Document Created: 2007-11-28 14:30:07
Document Modified: 2007-11-28 14:30:07
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC