EMC Test report

FCC ID: BRWAPRNTCSV1

Test Report

Download: PDF
FCCID_4033915

EMC TEST REPORT Report No.: 18070891-FCC-E Supersede Report No: N/A Applicant Horizon Hobby, LLC Product Name Receiver Model No. EFLR310013 Serial No. N/A Test Standard FCC Part 15 Subpart B Class B, ANSI C63.4: 2014 Test Date August 10 to September 11, 2018 Issue Date October 12, 2018 Test Result Pass Fail Equipment complied with the specification Equipment did not comply with the specification Evans He David Huang Test Engineer Checked By This test report may be reproduced in full only Test result presented in this test report is applicable to the tested sample only Issued by: SIEMIC (SHENZHEN-CHINA) LABORATORIES Zone A, Floor 1, Building 2 Wan Ye Long Technology Park South Side of Zhoushi Road, Bao’ an District, Shenzhen, Guangdong China 518108 Phone: +86 0755 2601 4629801 Email: China@siemic.com.cn

Test Report 18070891-FCC-E Page No. 2 of 18 Laboratories Introduction SIEMIC, headquartered in the heart of Silicon Valley, with superior facilities in US and Asia, is one of the leading independent testing and certification facilities providing customers with one-stop shop services for Compliance Testing and Global Certifications. In addition to testing and certification, SIEMIC provides initial design reviews and compliance management throughout a project. Our extensive experience with China, Asia Pacific, North America, European, and International compliance requirements, assures the fastest, most cost effective way to attain regulatory compliance for the global markets. Accreditations for Conformity Assessment Country/Region Scope USA EMC, RF/Wireless, SAR, Telecom Canada EMC, RF/Wireless, SAR, Telecom Taiwan EMC, RF, Telecom, SAR, Safety Hong Kong RF/Wireless, SAR, Telecom Australia EMC, RF, Telecom, SAR, Safety Korea EMI, EMS, RF, SAR, Telecom, Safety Japan EMI, RF/Wireless, SAR, Telecom Singapore EMC, RF, SAR, Telecom Europe EMC, RF, SAR, Telecom, Safety

Test Report 18070891-FCC-E Page No. 3 of 18 This page has been left blank intentionally.

Test Report 18070891-FCC-E Page No. 4 of 18 CONTENTS 1. REPORT REVISION HISTORY.............................................................................................................................5 2. CUSTOMER INFORMATION ................................................................................................................................5 3. TEST SITE INFORMATION ...................................................................................................................................5 4. EQUIPMENT UNDER TEST (EUT) INFORMATION .........................................................................................6 5. TEST SUMMARY ....................................................................................................................................................7 6. MEASUREMENTS, EXAMINATION AND DERIVED RESULTS .....................................................................8 6.1 AC POWER LINE CONDUCTED EMISSIONS ........................................................................................ 8 6.2 RADIATED EMISSIONS ......................................................................................................................................... 10 ANNEX A. TEST INSTRUMENT ................................................................................................................................. 15 ANNEX B. TEST SETUP AND SUPPORTING EQUIPMENT ................................................................................ 16 ANNEX C. USER MANUAL / BLOCK DIAGRAM / SCHEMATICS / PARTLIST/ DECLARATION OF SIMILARITY..................................................................................................................................................................... 18

Test Report 18070891-FCC-E Page No. 5 of 18 1. Report Revision History Report No. Report Version Description Issue Date 18070891-FCC-E NONE Original September 17, 2018 Updated the test data from “ August 10 to September 16, 18070891-FCC-E V1 October 12, 2018 2018” to “ August 10 to September 11, 2018” 2. Customer information Applicant Name Horizon Hobby, LLC Applicant Add 4105 Fieldstone Road, Champaign IL, USA 61822 Manufacturer Horizon Hobby, LLC Manufacturer Add 4105 Fieldstone Road, Champaign IL, USA 61822 3. Test site information Lab performing tests SIEMIC (Shenzhen-China) LABORATORIES Zone A, Floor 1, Building 2 Wan Ye Long Technology Park Lab Address South Side of Zhoushi Road, Bao’ an District, Shenzhen, Guangdong China 518108 FCC Test Site No. 535293 IC Test Site No. 4842E-1 Test Software of Radiated Emission Program-To Shenzhen v2.0 Radiated Emission Test Software of EZ-EMC(ver.Icp-03A1) Conducted Emission

Test Report 18070891-FCC-E Page No. 6 of 18 4. Equipment under Test (EUT) Information Description of EUT: Receiver Main Model: EFLR310013 Serial Model: N/A Antenna 0: 2dBi Antenna Gain: Antenna 1: 2dBi Antenna Type: Internal/external antenna Equipment Category： JAB Type of Modulation: FHSS RF Operating Frequency (ies): 2404MHz-2476MHz Number of Channels: 23CH Input Power: 5V Port: Please refer to the user’ s manual Trade Name : E-flite FCC ID: BRWAPRNTCSV1 Date EUT received: August 10, 2018 Test Date(s): August 10 to September 11, 2018

Test Report 18070891-FCC-E Page No. 7 of 18 5. Test Summary The product was tested in accordance with the following specifications. All testing has been performed according to below product classification: FCC Rules Description of Test Result §15.107; ANSI C63.4: 2014 AC Power Line Conducted Emissions N/A §15.109; ANSI C63.4: 2014 Radiated Emissions Compliance Measurement Uncertainty Parameter Uncertainty AC Power Line Conducted Emissions ±3.11dB (150kHz~30MHz) Radiated Emission(30MHz~1GHz) ±5.12dB Radiated Emission(1GHz~6GHz) ±5.34dB

Test Report 18070891-FCC-E Page No. 8 of 18 6. Measurements, Examination And Derived Results 6.1 AC Power Line Conducted Emissions Temperature -- Relative Humidity -- Atmospheric Pressure -- Test date : -- Tested By : -- Requirement(s): Spec Item Requirement Applicable For Low-power radio-frequency devices that is designed to be connected to the public utility (AC) power line, the radio frequency voltage that is conducted back onto the AC power line on any frequency or frequencies, within the band 150 kHz to 30 MHz, shall not exceed the limits in the following table, as measured using a 50 47CFR§15. [mu] H/50 ohms line impedance stabilization network (LISN). The a) 107 lower limit applies at the boundary between the frequencies ranges. Frequency ranges Limit (dBµV) (MHz) QP Average 0.15 ~ 0.5 66 – 56 56 – 46 0.5 ~ 5 56 46 5 ~ 30 60 50 Test Setup 1. The EUT and supporting equipment were set up in accordance with the requirements of the standard on top of a 1.5m x 1m x 0.8m high, non-metallic table. Procedure 2. The power supply for the EUT was fed through a 50Ω /50mH EUT LISN, connected to filtered mains.

Test Report 18070891-FCC-E Page No. 9 of 18 3. The RF OUT of the EUT LISN was connected to the EMI test receiver via a low-loss coaxial cable. 4. All other supporting equipment were powered separately from another main supply. 5. The EUT was switched on and allowed to warm up to its normal operating condition. 6. A scan was made on the NEUTRAL line (for AC mains) or Earth line (for DC power) over the required frequency range using an EMI test receiver. 7. High peaks, relative to the limit line, The EMI test receiver was then tuned to the selected frequencies and the necessary measurements made with a receiver bandwidth setting of 10 kHz. 8. Step 7 was then repeated for the LIVE line (for AC mains) or DC line (for DC power). Remark Result Pass Fail N/A Test Data Yes N/A Test Plot Yes (See below) N/A

Test Report 18070891-FCC-E Page No. 10 of 18 6.2 Radiated Emissions Temperature 26oC Relative Humidity 55% Atmospheric Pressure 1020mbar Test date : September 11, 2018 Tested By : Evans He Requirement(s): Spec Item Requirement Applicable Except higher limit as specified elsewhere in other section, the emissions from the low-power radio-frequency devices shall not exceed the field strength levels specified in the following table and the level of any unwanted emissions shall not exceed the level of the fundamental emission. The tighter limit applies at the band 47CFR§15. a) edges 109(d) Frequency range (MHz) Field Strength (µV/m) 30 – 88 100 88 – 216 150 216 - 960 200 Above 960 500 Test Setup 1. The EUT was switched on and allowed to warm up to its normal operating condition. 2. The test was carried out at the selected frequency points obtained from the EUT characterization. Maximization of the emissions, was carried out by rotating the EUT, Procedure changing the antenna polarization, and adjusting the antenna height in the following manner: a. Vertical or horizontal polarization (whichever gave the higher emission level

Test Report 18070891-FCC-E Page No. 11 of 18 over a full rotation of the EUT) was chosen. b. The EUT was then rotated to the direction that gave the maximum emission. c. Finally, the antenna height was adjusted to the height that gave the maximum emission. 3. The resolution bandwidth and video bandwidth of test receiver/spectrum analyzer is 120 kHz for Quasiy Peak detection at frequency below 1GHz. 4. The resolution bandwidth of test receiver/spectrum analyzer is 1MHz and video bandwidth is 3MHz with Peak detection for Peak measurement at frequency above 1GHz. The resolution bandwidth of test receiver/spectrum analyzer is 1MHz and the video bandwidth with Peak detection for Average Measurement as below at frequency above 1GHz. ■ 1 kHz (Duty cycle < 98%) □ 10 Hz (Duty cycle > 98%) 5. Steps 2 and 3 were repeated for the next frequency point, until all selected frequency points were measured. Remark Result Pass Fail Test Data Yes N/A Test Plot Yes (See below) N/A

Test Report 18070891-FCC-E Page No. 12 of 18 Test Mode : Normal Working Mode Below 1GHz Test Data Horizontal Polarity Plot @3m No. P/L Frequency Reading Ant_F PA_G Cab_L Result Limit Margin Height Degree (dBuV/ (MHz) (dBuV/m) (dB/m) (dB) (dB) (dBuV/m) (dB) (cm) (º) m) 1 H 779.6068 29.67 21.16 21.19 2.92 32.56 46.00 -13.44 100 49 2 H 480.5276 31.07 17.31 21.85 2.31 28.84 46.00 -17.16 100 200 3 H 287.9904 36.37 13.07 22.29 1.77 28.92 46.00 -17.08 100 315 4 H 219.0753 34.88 11.83 22.35 1.60 25.96 46.00 -20.04 200 122 5 H 114.9169 28.50 13.01 22.35 1.17 20.33 43.50 -23.17 100 52 6 H 44.2752 26.31 11.08 22.29 0.76 15.86 40.00 -24.14 100 153

Test Report 18070891-FCC-E Page No. 13 of 18 Below 1GHz Test Data Vertical Polarity Plot @3m No. P/L Frequency Reading Ant_F PA_G Cab_L Result Limit Margin Height Degree (dBuV/ (MHz) (dBuV/m) (dB/m) (dB) (dB) (dBuV/m) (dB) (cm) (º) m) 1 V 211.5265 35.81 11.94 22.36 1.58 26.97 43.50 -16.53 100 15 2 V 282.9852 37.18 12.85 22.29 1.76 29.50 46.00 -16.50 100 352 3 V 480.5276 33.18 17.31 21.85 2.31 30.95 46.00 -15.05 200 13 4 V 739.6605 32.37 20.68 21.28 2.80 34.57 46.00 -11.43 100 302 5 V 90.5374 31.49 8.13 22.32 0.95 18.25 43.50 -25.25 100 85 6 V 31.2893 30.74 20.41 22.27 0.66 29.54 40.00 -10.46 100 157

Test Report 18070891-FCC-E Page No. 14 of 18 Above 1GHz Frequency Read_level Height Polarity Level Factors Limit Margin Detector Azimuth (MHz) (dBµV/m) (cm) (H/V) (dBµV/m) (dB) (dBµV/m) (dB) (PK/AV) 2481.7 67.22 191 100 V -14.02 48.29 74 -25.71 PK 3182.53 69.97 100 100 V -12.97 45.15 74 -28.85 PK 1136.12 65.54 291 100 V -19.85 47.21 74 -26.79 PK 2224.77 64.49 285 100 H -15 45.41 74 -28.59 PK 4223.52 63.13 128 100 H -9.01 49.38 74 -24.62 PK 2975.87 61.44 31 100 H -13.51 46.25 74 -27.75 PK Note1: The highest frequency of the EUT is 2476 MHz, so the testing has been conformed to 5*2476MHz =12,380MHz. Note2: The frequency that above 3GHz is mainly from the environment noise. Note3: The AV measurement performed, more than 20dB below limit so AV test data was not presented.

Test Report 18070891-FCC-E Page No. 15 of 18 Annex A. TEST INSTRUMENT Instrument Model Serial # Cal Date Cal Due In use AC Line Conducted Emissions EMI test receiver ESCS30 8471241027 09/15/2017 09/14/2018 Line Impedance LI-125A 191106 09/23/2017 09/22/2018 Stabilization Network Line Impedance LI-125A 191107 09/23/2017 09/22/2018 Stabilization Network ISN ISN T800 34373 09/23/2017 09/22/2018 Transient Limiter LIT-153 531118 08/29/2018 08/28/2019 Radiated Emissions EMI test receiver E SL6 100262 09/15/2017 09/14/2018 OPT 010 AMPLIFIER 8447E 2727A02430 08/29/2018 08/28/2019 (0.1-1300MHz) Microwave Preamplifier 8449B 3008A02402 03/22/2018 03/21/2019 (1～26.5GHz) Bilog Antenna JB6 A110712 09/19/2017 09/18/2018 (30MHz~6GHz) Double Ridge Horn AH-118 71259 09/22/2017 09/21/2018 Antenna

m S’PE M l C Test Report 18070891—FCC—E A Bureau Veritas Group Company Page 16 of 18 Annex B. TEST SETUP AND SUPPORTING EQUIPMENT Annex B.i. TEST SET UP BLOCK Block Configuration Diagram for Radiated Emissions Test Table \ I 80cm above ground plane d=3meter v Receiving Antenna

Test Report 18070891-FCC-E Page No. 17 of 18 Annex C. iI. SUPPORTING EQUIPMENT DESCRIPTION The following is a description of supporting equipment and details of cables used with the EUT. Supporting Equipment: Equipment Manufacturer Model Serial No Description N/A Power supply N/A N/A Supporting Cable: Cable type Shield Type Ferrite Core Length Serial No - - - - -

Test Report 18070891-FCC-E Page No. 18 of 18 Annex C. User Manual / Block Diagram / Schematics / Partlist/ DECLARATION OF SIMILARITY Please see the attachment


Document Created: 2019-10-15 19:11:49
Document Modified: 2019-10-15 19:11:49
© 2025 FCC.report
This site is not affiliated with or endorsed by the FCC