03 FCC Test Report_FDS

FCC ID: 2AON3-RCS05

Test Report

Download: PDF
FCCID_4253915

Test report No. : 12104474H-R2 Page : 1 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 RADIO TEST REPORT Test Report No. : 12104474H-R2 Applicant : KEYCOM CORPORATION Type of Equipment : Imaging Radar Model No. : RCS05 FCC ID : 2AON3-RCS05 Test regulation : FCC Part 95 Subpart M: 2017 Test Result : Complied (Refer to SECTION 3.2) 1. This test report shall not be reproduced in full or partial, without the written approval of UL Japan, Inc. 2. The results in this report apply only to the sample tested. 3. This sample tested is in compliance with the above regulation. 4. The test results in this report are traceable to the national or international standards. 5. This test report covers Radio technical requirements. It does not cover administrative issues such as Manual or non-Radio test related Requirements. (if applicable) 6. The all test items in this test report are conducted by UL Japan, Inc. Ise EMC Lab. 7. This test report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. 8. The information provided from the customer for this report is identified in SECTION 1. 9. This report is a revised version of 12104474H-R1. 12104474H-R1 is replaced with this report. Date of test: October 2 to November 9, 2018 Representative test engineer: Ryota Yamanaka Engineer Consumer Technology Division Approved by: Tsubasa Takayama Leader Consumer Technology Division This laboratory is accredited by the NVLAP LAB CODE 200572-0, U.S.A. The tests reported herein have been performed in accordance with its terms of accreditation. *As for the range of Accreditation in NVLAP, you may refer to the WEB address, http://japan.ul.com/resources/emc_accredited/ NVLAP LAB CODE: 200572-0 The testing in which "Non-accreditation" is displayed is outside the accreditation scopes in UL Japan. There is no testing item of "Non-accreditation". UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124 Report Cover Page - 13-EM-F0429 Issue # 14.0

Test report No. : 12104474H-R2 Page : 2 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 REVISION HISTORY Original Test Report No.: 12104474H Revision Test report No. Date Page Contents revised - (Original) 12104474H December 13, 2018 - - 1 12104474H-R1 February 26, 2019 P.1 Correction of Date of test of cover sheet 1 12104474H-R1 February 26, 2019 P.1 Addition of note No.8 1 12104474H-R1 February 26, 2019 P.4 Addition of note in SECTION 1. 1 12104474H-R1 February 26, 2019 P.4 Addition of a word to Receipt Date of Sample 1 12104474H-R1 February 26, 2019 P.5 Addition of notes from a) to d) 1 12104474H-R1 February 26, 2019 P.5 Addition of “Section 2.1046 to 2.1057” to Specification in the table of Clause 3.2 1 12104474H-R1 February 26, 2019 P.6 Addition of note in Clause 3.4 1 12104474H-R1 February 26, 2019 P.8 Addition of “Modulation characteristics” in Test Item of Clause 4.1 1 12104474H-R1 February 26, 2019 P.8 Correction of Configuration and peripherals of Clause 4.2 1 12104474H-R1 February 26, 2019 P.10 Correction of Test Distance of Radiated emission test in SECTION 5. 1 12104474H-R1 February 26, 2019 P.14 - Correction of RBW Correction Factor; From 10log to 20log - Correction of peak power value with modification of RBW Correction Factor; From 25.272 dB to 50.544 dB 1 12104474H-R1 February 26, 2019 P.14 Addition of the following sentence under the Radiated Power test data; The test method referred to KDB653005. 1 12104474H-R1 February 26, 2019 P.19 Deletion of note sentence under the Field strength of spurious radiation (above 40 GHz) test data 1 12104474H-R1 February 26, 2019 P.23 Correction of upper result value of 10.2 V in Frequency Stability test; From 76.676 GHz to 76.666 GHz 1 12104474H-R1 February 26, 2019 P.24 Correction of voltage of 20 deg. C; From DC 10.8 V to DC 10.2 V 1 12104474H-R1 February 26, 2019 P.27 Deletion of LIMS ID: 141806 and 141841 from Test Instruments 1 12104474H-R1 February 26, 2019 P.29 Replacement of setup photo for Field strength of spurious radiation. 2 12104474H-R2 April 9, 2019 P.4 Correction of Radio Specification in Clause 2.2 2 12104474H-R2 April 9, 2019 P.5 Correction of “Procedures and results” table in Clause 3.2 2 12104474H-R2 April 9, 2019 P.10 Correction of the description of [Test setup] 1 GHz - 10 GHz UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 3 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 CONTENTS PAGE SECTION 1: Customer information.......................................................................................................4 SECTION 2: Equipment under test (E.U.T.) .........................................................................................4 SECTION 3: Test specification, procedures & results..........................................................................5 SECTION 4: Operation of E.U.T. during testing ..................................................................................8 SECTION 5: Radiated Spurious Emission ............................................................................................9 SECTION 6: Frequency Stability .........................................................................................................12 APPENDIX 1: Test data ........................................................................................................................13 Occupied bandwidth .........................................................................................................................13 Radiated Power .................................................................................................................................14 Field strength of spurious radiation...................................................................................................17 Frequency Stability ...........................................................................................................................23 APPENDIX 2: Test instruments ...........................................................................................................26 APPENDIX 3: Photographs of test setup .............................................................................................28 Field strength of spurious radiation...................................................................................................28 Frequency Stability ...........................................................................................................................29 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 4 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 SECTION 1: Customer information Company Name : KEYCOM CORPORATION Address : Otsuka Minami Bldg, 3-39-14, Minamiotsuka, Toshimaku, Tokyo , 170-0005, Japan Telephone Number : +81-3-5950-3101 Facsimile Number : +81-3-5950-3380 Contact Person : HIROHIDE YAMASHITA The information provided from the customer is as follows; - Applicant, Type of Equipment, Model No. on the cover and other relevant pages - SECTION 1: Customer information - SECTION 2: Equipment under test (E.U.T.) - SECTION 4: Operation of E.U.T. during testing * The laboratory is exempted from liability of any test results affected from the above information in SECTION 2 and 4. SECTION 2: Equipment under test (E.U.T.) 2.1 Identification of E.U.T. Type of Equipment : Imaging Radar Model No. : RCS05 Serial No. : Refer to Section 4, Clause 4.2 Rating Voltage : DC 12.0 V Receipt Date of Sample : October 2, 2018 (Information from test lab.) Country of Mass-production : Japan Condition of EUT : Production prototype (Not for Sale: This sample is equivalent to mass-produced items.) Modification of EUT : No Modification by the test lab 2.2 Product Description Model: RCS05 (referred to as the EUT in this report) is a Imaging Radar. Radio Specification Radio Type : Transceiver Frequency Band : 76 GHz - 77 GHz Frequency of Operation : 76.5 GHz Occupied frequency bandwidth : 1 GHz FCC Identifier : 337MP0N RF Output Power : Typ. 6 dBm (8 dBm to 4 dBm) Modulation : Pulse modulation Antenna Type : Internal Antenna Antenna Connector : None (Internal Antenna) Antenna Gain : 35 dBi EIRP : Typ. 41 dBm ( 43 dBm to 39 dBm) Steerable Antenna : Mechanically (Both Transmitting & Receiving Part) Usage location : Vehicle-mounted Clock Frequency (maximum) : 124.875 MHz UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 5 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 SECTION 3: Test specification, procedures & results 3.1 Test Specification Test Specification : FCC Part 95 Subpart M FCC Part 95 final revised on September 20, 2017 Title : FCC 47CFR Part95 - PERSONAL RADIO SERVICES Subpart M - The 76-81 GHz Band Radar Service 3.2 Procedures and results Item Test Procedure Specification Worst margin Results Remarks Conducted emission FCC: N/A FCC: N/A N/A N/A - FCC: ANSI C63.26-2015 FCC: Section 2.1049 Complied Occupied bandwidth 5.4 Occupied bandwidth Radiated a) FCC: ANSI C63.26-2015 FCC: Section 95.3367 Radiated Power 5.5 Radiated emissions testing Section 2.1046 See data. ANSI C63.10-2013 Section 2.1047 Complied Radiated Modulation 6. Standard test methods b) characteristics 9. Procedures for testing millimeter-wave systems FCC: ANSI C63.26-2015 FCC: Section 95.3379 (a) Field strength of 5.5 Radiated emissions testing Section 2.1053 5.58 dB Complied Radiated spurious radiation Section 2.1057 228.633 GHz c) FCC: ANSI C63.26-2015 FCC: Section 95.3379 (b) Complied Frequency stability 5.6 Frequency stability testing Section 2.1055 See data. Radiated d) Note: UL Japan, Inc.’s EMI Work Procedures No. 13-EM-W0420 and 13-EM-W0422. a) Refer to APPENDIX 1 (data of Occupied bandwidth) b) Refer to APPENDIX 1 (data of Radiated Power and Modulation characteristics) c) Refer to APPENDIX 1 (data of Field strength of spurious radiation) d) Refer to APPENDIX 1 (data of Frequency Stability) Symbols: Complied The data of this test item has enough margin, more than the measurement uncertainty. Complied# The data of this test item meets the limits unless the measurement uncertainty is taken into consideration. * In case any questions arise about test procedure, ANSI C63.26-2015 and C63.10-2013 are also referred. Supplied Voltage Information The EUT provides the stable voltage constantly to RF Part regardless of input voltage. DC power supply was used for the test. Antenna Information It is impossible for end users to replace the antenna, because the antenna is mounted inside of the EUT. 3.3 Addition to standard No addition, exclusion nor deviation has been made from the standard. UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 6 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 3.4 Uncertainty EMI There is no applicable rule of uncertainty in this applied standard. Therefore, the following results are derived depending on whether or not laboratory uncertainty is applied. The following uncertainties have been calculated to provide a confidence level of 95 % using a coverage factor k = 2. Ise EM C Lab. Radiated emission Test distance (+/-) 9 kHz - 30 M Hz 3m 3.3 dB 10 m 3.2 dB Radiated emission (Below 1 GHz) (3 m*) (+/-) (10 m*) (+/-) Polarity 200 M Hz - 30 M Hz - 200 M Hz - 30 M Hz - 200 M Hz 1000 M Hz 200 M Hz 1000 M Hz Horizontal 4.8 dB 5.2 dB 4.8 dB 5.0 dB Vertical 4.9 dB 6.3 dB 4.9 dB 5.0 dB Radiated emission (Above 1 GHz) (3 m*) (+/-) (1 m*) (+/-) (10 m*) (+/-) 1 GHz - 6 GHz - 10 GHz - 26.5 GHz - 1 GHz - 6 GHz 18 GHz 26.5 GHz 40 GHz 18 GHz 5.2 dB 5.5 dB 5.9 dB 5.9 dB 5.5 dB *M easurement distance Radiated emission (+/-) 40 GHz - 50 GHz 4.1 dB 50 GHz - 75 GHz 5.5 dB 75 GHz - 110 GHz 5.8 dB 110 GHz - 170 GHz 5.0 dB 170 GHz - 260 GHz 5.0 dB Radiated emission (+/-) With Block downconverter 75 GHz - 83 GHz 4.6 dB UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 7 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 3.5 Test Location UL Japan, Inc. Ise EM C Lab. 4383-326 Asama-cho, Ise-shi, M ie-ken 516-0021 JAPAN Telephone: +81 596 24 8999, Facsimile: +81 596 24 8124 NVLAP Lab. code: 200572-0 / FCC Test Firm Registration Number: 199967 M aximum IC Registration Width x Depth x Size of reference ground plane (m) / Test site Other rooms measurement Number Height (m) horizontal conducting plane distance No.1 semi-anechoic No.1 Power source 2973C-1 19.2 x 11.2 x 7.7 7.0 x 6.0 10 m chamber room No.2 semi-anechoic 2973C-2 7.5 x 5.8 x 5.2 4.0 x 4.0 - 3m chamber No.3 semi-anechoic No.3 Preparation 2973C-3 12.0 x 8.5 x 5.9 6.8 x 5.75 3m chamber room No.3 shielded room - 4.0 x 6.0 x 2.7 N/A - - No.4 semi-anechoic No.4 Preparation 2973C-4 12.0 x 8.5 x 5.9 6.8 x 5.75 3m chamber room No.4 shielded room - 4.0 x 6.0 x 2.7 N/A - - No.5 semi-anechoic - 6.0 x 6.0 x 3.9 6.0 x 6.0 - - chamber No.6 shielded room - 4.0 x 4.5 x 2.7 4.0 x 4.5 - - No.6 measurement - 4.75 x 5.4 x 3.0 4.75 x 4.15 - - room No.7 shielded room - 4.7 x 7.5 x 2.7 4.7 x 7.5 - - No.8 measurement - 3.1 x 5.0 x 2.7 3.1 x 5.0 - - room No.9 measurement - 8.8 x 4.6 x 2.8 2.4 x 2.4 - - room No.11 measurement - 6.2 x 4.7 x 3.0 4.8 x 4.6 - - room * Size of vertical conducting plane (for Conducted Emission test) : 2.0 m x 2.0m for No.1, No.2, No.3, and No.4 semi- anechoic chambers and No.3 and No.4 shielded rooms. 3.6 Test data, Test instruments, and Test set up Refer to APPENDIX. UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 8 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 SECTION 4: Operation of E.U.T. during testing 4.1 Operating Mode(s) Mode Test Item Normal operating mode Occupied bandwidth Radiated Power Modulation characteristics Field strength of spurious radiation Frequency stability Power of the EUT was set by the software as follows; Power settings: Same as production model Software: Ver. 1.33 This setting of software is the worst case. Any conditions under the normal use do not exceed the condition of setting. In addition, end users cannot change the settings of the output power of the product. 4.2 Configuration and peripherals B A 5 2 3 C 4 1 DC 12.0 V AC 120V / 60Hz : Standard Ferrite Core * Cabling and setup(s) were taken into consideration and test data was taken under worse case conditions. Description of EUT and Support equipment No. Item Model number Serial number Manufacturer Remarks A Imaging Radar RCS05 14418F28-02 KEYCOM CORPORATION EUT B Laptop PC CF-N8HWCDP5 9LKSA04L58 Panasonic - C AC Adapter CF-AA63720 6372BM409X1490B Panasonic - List of cables used No. Name Length (m) Shield Remarks Cable Connector 1 DC Cable 2.0 Unshielded Unshielded - 2 USB Cable 1.4 Shielded Shielded - 3 DC Cable 1.0 Unshielded Unshielded - 4 AC Cable 0.8 Unshielded Unshielded - 5 Coaxial Cable 0.5 Shielded Shielded - UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 9 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 SECTION 5: Radiated Spurious Emission Test Procedure [For below 1 GHz] EUT was placed on a urethane platform of nominal size, 1.0 m by 1.5 m, raised 0.8 m above the conducting ground plane. The Radiated Electric Field Strength has been measured in a Semi Anechoic Chamber with a ground plane. [For above 1 GHz, up to 40 GHz] EUT was placed on a urethane platform of nominal size, 0.5 m by 1.0 m, raised 1.5 m above the conducting ground plane. The Radiated Electric Field Strength has been measured in a Semi Anechoic Chamber with absorbent materials lined on a ground plane. The height of the measuring antenna varied between 1 m and 4 m (frequency range 9 kHz – 30 MHz: loop antenna was fixed height at 1.0 m) and EUT was rotated a full revolution in order to obtain the maximum value of the electric field strength. The measurements were performed for both vertical and horizontal antenna polarization with the Test Receiver, or the Spectrum Analyzer. The measurements were made with the following detector function of the test receiver and the Spectrum analyzer (in linear voltage average mode). The test was made with the detector (RBW/VBW) in the following table. When using Spectrum analyzer, the test was made with adjusting span to zero by using peak hold. Test Antennas are used as below; Frequency Below 30 MHz 30 MHz to 200 MHz 200 MHz to 1 GHz Above 1 GHz Antenna Type Loop Biconical Logperiodic Horn Frequency 9 kHz to 150 kHz to 30 MHz to 1 GHz to 40 GHz 150 kHz 30 MHz 1 GHz Instrument used Test Receiver Test Receiver Test Receiver Spectrum Analyzer Detector CISPR QP, CISPR QP, CISPR QP Peak Average *1) Average Average IF Bandwidth 200 Hz 9 kHz 120 kHz RBW: 1 MHz RBW: 1 MHz VBW: 3 MHz VBW: 3 MHz *1) An RMS average mode was used: 1 ms or less averaging time (integration time period for each spectrum analyzer bin; spectrum analyzer sweeptime / number-of-bins not exceeding one millisecond) UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 10 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 [Test setup] Below 1 GHz Test Distance: 3 m 1 GHz - 10 GHz Distance Factor: 20 x log (4.0 m*/3.0 m) = 2.5 dB * Test Distance: (3 + Test Volume /2) - r = 4.0 m Test Volume: 2 m (Test Volume has been calibrated based on CISPR 16-1-4.) r = 0.0 m * The test was performed with r = 0.0 m since that yielded the worst emission levels from the EUT. 10 GHz – 40 GHz Distance Factor: 20 x log (1.0 m* / 3.0 m) = -9.54 dB *Test Distance: 1 m UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 11 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 [Above 40 GHz] The test was performed based on “Procedures for testing millimeter-wave systems” of ANSI C63.10-2013. The EUT was placed on a urethane platform, raised 1.5 m above the conducting ground plane. The measurements were performed on handheld method. Set spectrum analyzer RBW, VBW, span, etc., to the proper values. Note these values. Enable two traces—one set to “clear write,” and the other set to “max hold.” Begin hand-held measurements with the test antenna (horn) at a distance of 1 m from the EUT in a horizontally polarized position. Slowly adjust its position, entirely covering the plane 1 m from the EUT. Observation of the two active traces on the spectrum analyzer will allow refined horn positioning at the point(s) of maximum field intensity. Repeat with the horn in a vertically polarized position. If the emission cannot be detected at 1 m, reduce the RBW to increase system sensitivity. Note the value. If the emission still cannot be detected, move the horn closer to the EUT, noting the distance at which a measurement is made. Note the maximum level indicated on the spectrum analyzer. Adjust this level, if necessary, by the antenna gain, conversion loss of the external mixer and gain of LNA used, at the frequency under investigation. Calculate the field strength of the emission at the measurement distance from the Friis’ transmission equation. Frequency 40 GHz to 50 GHz to 77 GHz to 83 GHz to 110 GHz to 170 GHz to 50 GHz 76 GHz 83 GHz 110 GHz 170 GHz 231 GHz Final measurement distance 1.0 m 1.0 m 1.0 m 1.0 m 0.02 m 0.02 m with 1 MHz Peak detector [About fundamental measurement] The carrier levels were confirmed at maximum direction of transmission. The maximum direction was searched under carefully since beam-widths are extremely narrow. The carrier levels were measured in the far field. The distance of the far field was calculated from follow equation. 2D2 r  where r is the distance from the radiating element of the EUT to the edge of the far field, in m D is the largest dimension of both the radiating element and the test antenna (horn), in m (The antenna aperture size of test antenna was used for this caluculation.) Lambda is the wavelength of the emission under investigation [300/f (MHz)], in m Frequency Wavelength Maximum Dimention Far Field EUT Test Antenna Maximum Boundary Lambda D r [GHz] [mm] [m] [m] [m] [m] 76.5 3.9 0.088000 0.026162 0.088000 3.950 The test was made on EUT at the normal use position. The test results and limit are rounded off to one decimal place, so some differences might be observed. Measurement range : 9 kHz - 231 GHz Test data : APPENDIX Test result : Pass UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 12 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 SECTION 6: Frequency Stability Test Procedure The block downconverter was placed in side of the temperature chamber’s drain hole. The power supply was set to nominal operating voltage (100 %), and the spectrum mask was measured at 20 deg. C. After that, EUT power supply was varied between 85 % and 115 % of nominal voltage and the frequency excursion of the EUT emission mask was recorded. The EUT operating temperature was raised to 50 deg. C, and the frequency excursion of the EUT emission mask was recorded. Measurements were repeated at each 10 deg. C decrement down to –20 deg. C. Both lower and upper frequencies of the 99 % OBW were recorded. Test data : APPENDIX Test result : Pass UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 13 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 APPENDIX 1: Test data Occupied bandwidth Report No. 12104474H Test place Ise EMC Lab. No.8 Measurement Room Date November 6, 2018 Temperature / Humidity 22 deg. C / 50 % RH Engineer Ryota Yamanaka Mode Normal operating mode Frequency 99 % Occupied bandwidth [GHz] [MHz] 76.5 336.6521 Occupied bandwidth The measurement was performed with Peak detector and Max Hold since the duty cycle was not 100 %. UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 14 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Radiated Power Report No. 12104474H Test place Ise EMC Lab. No.4 Semi Anechoic Chamber Date November 7, 2018 Temperature / Humidity 23 deg. C / 50 % RH Engineer Ryota Yamanaka Mode Normal operating mode Measured data in Test modes Mode Power Freq. Measured Tested Rx Down IF FSL EIRP Power Distance Antenna Converter Cable Gain Gain Loss [GHz] [dBm] [m] [dBi] [dB] [dB] [dB] [dBm] [mW] Spectrum Average 76.5 -36.19 3.95 22.33 14.80 1.42 82.05 10.15 10.34 Analyzer Peak 76.5 -55.48 3.95 22.33 14.80 1.42 82.05 -9.14 0.12 Calculating formula: FSL (Free Space path Loss) = 10 * log10(( 4 * Pi * Tested Distance / Lambda ) ^2) EIRP = Measured Power - Rx Antenna Gain - Down Converter Gain + IF Cable Loss + FSL These calculation results are same as results which were calculated with formulas described in the Section 9 of ANSI C63.10-2013. Final result in Normal operation mode EIRP Spectrum Duty Result Limit Margin Analyzer Factor [dBm] [dB] [mW] [dBm] [dBm] [dB] Average power 10.15 23.565 2350.68 33.71 50 16.29 Peak power -9.14 - 0.12 -9.14 55 64.14 Reference data of peak power. EIRP RBW Spectrum OBW Correction Result Limit Margin Analyzer Factor *1 [dBm] [MHz] [dB] [mW] [dBm] [dBm] [dB] Peak power -9.14 336.652 50.544 13805.65 41.40 55 13.60 *1 RBW Correction Factor = 20log * (OBW) For the peak power result, it is a maximum power. The test method referred to KDB653005. UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 15 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Radiated Power Report No. 12104474H Test place Ise EMC Lab. No.4 Semi Anechoic Chamber Date November 7, 2018 Temperature / Humidity 23 deg. C / 50 % RH Engineer Ryota Yamanaka Mode Normal operating mode Spectrum Analyzer UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 16 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Modulation characteristics Report No. 12104474H Test place Ise EMC Lab. No.4 Semi Anechoic Chamber Date November 7, 2018 Temperature / Humidity 23 deg. C / 50 % RH Engineer Ryota Yamanaka Mode Normal operating mode [Duty Factor] Tx On Tx On + Off Duty factor time time [μs] [μs] [dB] Measured 0.0044 1.000 -23.565 Declared * 0.005 1.000 -23.010 Duty factor = 10 * log (Tx On time / Tx On + Off time) * See the application document. [Data] Duty * This Duty Cycle is the worst case. Transmitting time does not exceed it. UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 17 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Field strength of spurious radiation Report No. 12104474H Test place Ise EMC Lab. Semi Anechoic Chamber No.3 No.3 No.3 Date October 2, 2018 October 3, 2018 October 29, 2018 Temperature / Humidity 23 deg. C / 51 % RH 23 deg. C / 48 % RH 22 deg. C / 55 % RH Engineer Ryota Yamanaka Junki Nagatomi Ryota Yamanaka (1 GHz - 40 GHz) (9 kHz - 30 MHz) (30 MHz - 1 GHz) Mode Normal operating mode Polarity Frequency Detector Reading Ant.Fac. Loss Gain Result Limit Margin Remark [MHz] [dBuV] [dB/m] [dB] [dB] [dBuV/m] [dBuV/m] [dB] Hori 168.882 QP 33.0 15.8 8.9 32.0 25.7 43.5 17.8 Hori 295.610 QP 42.9 13.5 9.9 32.0 34.3 46.0 11.7 Hori 499.501 QP 33.2 18.1 11.3 32.0 30.6 46.0 15.4 Hori 528.000 QP 35.3 17.9 11.4 32.1 32.5 46.0 13.5 Hori 624.000 QP 31.4 19.6 11.9 32.1 30.8 46.0 15.2 Hori 874.122 QP 34.1 22.1 13.1 31.3 38.0 46.0 8.0 Hori 12750.050 PK 49.2 38.9 -3.2 33.3 51.6 73.9 22.3 Hori 12750.050 AV 45.0 38.9 -3.2 33.3 47.4 53.9 6.5 Vert 168.882 QP 35.6 15.8 8.9 32.0 28.3 43.5 15.2 Vert 299.311 QP 42.3 13.5 10.0 32.0 33.8 46.0 12.2 Vert 499.500 QP 32.9 18.1 11.3 32.0 30.3 46.0 15.7 Vert 528.000 QP 31.0 17.9 11.4 32.1 28.2 46.0 17.8 Vert 624.000 QP 30.1 19.6 11.9 32.1 29.5 46.0 16.5 Vert 874.122 QP 34.5 22.1 13.1 31.3 38.4 46.0 7.6 Vert 12750.050 PK 46.9 38.9 -3.2 33.3 49.3 73.9 24.6 Vert 12750.050 AV 40.2 38.9 -3.2 33.3 42.6 53.9 11.3 Result = Reading + Ant Factor + Loss (Cable+Attenuator+Filter+Distance factor(above 1 GHz)) - Gain(Amplifier) *Other frequency noises omitted in this report were not seen or had enough margin (more than 20 dB). *The 10th harmonic was not seen so the result was its base noise level. Distance factor: 1 GHz - 10 GHz 20log (4.0 m / 3.0 m) = 2.5 dB 10 GHz - 40 GHz 20log (1.0 m / 3.0 m) = -9.54 dB UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 18 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Field strength of spurious radiation (Plot data, Worst case) Report No. 12104474H Test place Ise EMC Lab. Semi Anechoic Chamber No.3 No.3 No.3 Date October 2, 2018 October 3, 2018 October 29, 2018 Temperature / Humidity 23 deg. C / 51 % RH 23 deg. C / 48 % RH 22 deg. C / 55 % RH Engineer Ryota Yamanaka Junki Nagatomi Ryota Yamanaka (1 GHz - 40 GHz) (9 kHz - 30 MHz) (30 MHz - 1 GHz) Mode Normal operating mode Horizontal 80 70 Field strength [dBuV/m] 60 50 40 30 20 10 10 100 1000 10000 Frequency [MHz] QP Peak Average QP Limit Peak Limit Average Limit Vertical 80 70 Field strength [dBuV/m] 60 50 40 30 20 10 10 100 1000 10000 Frequency [MHz] QP Peak Average QP Limit Peak Limit Average Limit *These plots data contains sufficient number to show the trend of characteristic features for EUT. UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 19 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Field strength of spurious radiation (above 40 GHz) Report No. 12104474H Test place Ise EMC Lab. Semi Anechoic Chamber No. 3 Date October 4, 2018 Temperature / Humidity 23 deg. C / 63 % RH Engineer Ryota Yamanaka 50 GHz - 231 GHz Mode Normal operating mode Freq. Reading Rx Filter LNA Mixer IF IF Meas. FSL EIRP Power density at 3 m Remarks ant. loss gain loss amp. cable range Result Limit Margin gain gain loss D [GHz] [dBm] [dBi] [dB] [dB] [dB] [dB] [dB] [m] [dB] [dBm] [mW] [pW/cm2] [pW/cm2] [dB] 49.974 -57.66 22.64 0.00 22.91 0.00 0.00 9.19 1.0 66.42 -27.60 0.001739 1.54 600 25.91 50.852 -78.30 22.73 0.00 25.72 46.70 32.07 0.10 1.0 66.57 -45.45 0.000028 0.03 600 43.77 75.915 -68.76 22.26 0.00 0.00 -14.73 0.00 1.24 1.0 70.05 -34.46 0.000358 0.32 600 32.78 82.354 -68.94 22.94 0.00 0.00 -12.33 0.00 2.62 1.0 70.76 -30.83 0.000825 0.73 600 29.15 83.639 -71.01 23.11 2.59 0.00 42.24 32.07 0.10 1.0 70.89 -10.37 0.091875 81.24 600 8.68 101.449 -74.08 24.76 0.31 0.00 44.43 32.07 0.10 1.0 72.57 -13.50 0.044686 39.51 600 11.81 116.969 -91.58 22.53 0.00 0.00 57.10 0.00 0.00 0.02 39.82 -17.18 0.019124 16.91 600 15.50 131.297 -93.29 22.98 0.00 0.00 52.72 0.00 0.00 0.02 40.83 -22.72 0.005341 4.72 600 21.04 153.066 -88.32 23.35 0.00 0.00 57.14 0.00 0.00 0.02 42.16 -12.37 0.057928 51.2 600 10.69 154.770 -94.13 23.37 0.00 0.00 56.57 0.00 0.00 0.02 42.26 -18.67 0.013574 12.0 600 16.99 172.654 -92.08 22.46 0.00 0.00 59.24 0.00 0.00 0.02 43.21 -12.10 0.061715 54.6 600 10.41 192.168 -93.31 22.88 0.00 0.00 59.41 0.00 0.00 0.02 44.14 -12.64 0.054413 48.1 600 10.96 211.923 -93.84 23.19 0.00 0.00 60.59 0.00 0.00 0.02 44.99 -11.45 0.071564 63.3 1000 11.99 228.633 -89.42 23.34 0.00 0.00 62.07 0.00 0.00 0.02 45.65 -5.05 0.312761 276.5 1000 5.58 2 Calculation: FSL (Free Space path Loss) = 10 * log ((4 * Pi * D / λ ) ) EIRP = Reading - Rx ant. gain + Filter loss - LNA gain + Mixer loss - IF amp. gain + IF cable loss + FSL 2 Power density Result at 3 m = EIRP / (4 * Pi * 300 ) These calculation results are same as results which were calculated with formulas described in the Section 9 of ANSI C63.10-2013. The equipment were not used for factor 0 dB of the data sheets. There is no spurious emission from 40 GHz to 231 GHz except for operating band. UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 20 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Field strength of spurious radiation (above 40 GHz) 40 GHz – 50 GHz 50 GHz – 75 GHz 75 GHz – 76 GHz 81 GHz – 83 GHz 83 GHz – 90 GHz 90 GHz – 110 GHz UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 21 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Field strength of spurious radiation (above 40 GHz) 110 GHz – 130 GHz 130 GHz – 152 GHz 152 GHz – 154 GHz 154 GHz – 170 GHz 170 GHz – 190 GHz 190 GHz – 210 GHz UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 22 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Field strength of spurious radiation (above 40 GHz) 210 GHz – 228 GHz 228 GHz – 231 GHz UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 23 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Frequency Stability Report No. 12104474H Test place Ise EMC Lab. No.8 Measurement Room Date November 9, 2018 Temperature / Humidity 22 deg. C / 51 % RH Engineer Ryota Yamanaka Mode Normal operating mode Test Condition Measured -20 dBc Frequency Remarks Temperature Power Supply Lower Result Upper Result [deg. C] [V] [GHz] [GHz] 50 12.0 76.213 76.647 40 12.0 76.217 76.650 30 12.0 76.232 76.646 20 12.0 76.194 76.650 20 10.2 76.232 76.666 85 % of the minimum operating voltage, DC 12V * 0.85 20 13.8 76.230 76.653 115 % of the maximum operating voltage, DC 12 V * 1.15 10 12.0 76.157 76.670 0 12.0 76.098 76.673 -10 12.0 76.088 76.675 -20 12.0 76.027 76.767 Fundamental emissions were contained within the frequency band 76 GHz - 77 GHz during all conditions of operation. UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 24 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Frequency Stability 50 deg. C, DC 12.0 V 40 deg. C, DC 12.0 V 30 deg. C, DC 12.0 V 20 deg. C, DC 12.0 V 20 deg. C, DC 10.2 V 20 deg. C, DC 13.8 V UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 25 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Frequency Stability 10 deg. C, DC 12.0 V 0 deg. C, DC 12.0 V -10 deg. C, DC 12.0 V -20 deg. C, DC 12.0 V UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 26 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 APPENDIX 2: Test instruments Test Instruments (1/2) Test LIMS ID Description Manufacturer Model Serial Last Calibration Cal Int item Calibration Due Date Date RE 141152 EMI measurement TSJ TEPTO-DV - - - - program RE 141265 Logperiodic Schwarzbeck VUSLP9111B 911B-190 5/31/2018 5/31/2019 12 Antenna(200-1000MHz) RE 141317 Coaxial Cable Fujikura/Agilent - - 2/23/2018 2/28/2019 12 RE 141203 Attenuator(6dB) Weinschel Corp 2 BK7970 11/5/2018 11/30/2019 12 RE 141578 Pre Amplifier AGILENT 8447D 2944A10845 9/19/2018 9/30/2019 12 RE 141542 Digital Tester Fluke Corporation FLUKE 26-3 78030611 8/21/2018 8/31/2019 12 RE 141427 Biconical Antenna Schwarzbeck VHA9103B 8031 5/31/2018 5/31/2019 12 RE 141582 Pre Amplifier SONOMA 310 260834 2/27/2018 2/28/2019 12 INSTRUMENT RE 141222 Coaxial Cable FUJIKURA 3D-2W(12m)/ - 2/23/2018 2/28/2019 12 5D-2W(5m)/ 5D-2W(0.8m)/5 RE 159670 Coaxial Cable UL Japan Inc. - - 11/7/2018 11/30/2019 12 RE 142152 Loop Antenna Rohde & Schwarz HFH2-Z2 836553/009 11/22/2017 11/30/2018 12 RE 141942 Test Receiver Rohde & Schwarz ESCI 100300 8/8/2018 8/31/2019 12 RE 141885 Spectrum Analyzer AGILENT E4448A US44300523 11/7/2018 11/30/2019 12 RE 142182 Measure KOMELON KMC-36 - - - - RE 142004 AC2_Semi Anechoic TDK Semi Anechoic DA-06902 6/29/2018 6/30/2020 24 Chamber(NSA) Chamber 3m RE 141556 Thermo-Hygrometer CUSTOM CTH-201 0003 12/21/2017 12/31/2018 12 RE 142013 AC3_Semi Anechoic TDK Semi Anechoic DA-10005 4/6/2018 4/30/2019 12 Chamber(SVSWR) Chamber 3m RE 141532 DIGITAL HiTESTER HIOKI 3805 51201197 1/9/2018 1/31/2019 12 RE 141507 Horn Antenna 1-18GHz Schwarzbeck BBHA9120D 258 6/7/2018 6/30/2019 12 RE 141513 Horn Antenna 15-40GHz Schwarzbeck BBHA9170 BBHA9170306 6/7/2018 6/30/2019 12 RE 142183 Measure KOMELON KMC-36 - - - - RE 141580 MicroWave System AGILENT 83017A MY39500779 3/13/2018 3/31/2019 12 Amplifier RE 141417 Microwave Cable Junkosha MWX221 1404S374(1m) / 5/7/2018 5/31/2019 12 1405S074(5m) RE 142008 AC3_Semi Anechoic TDK Semi Anechoic DA-10005 6/26/2018 6/30/2020 24 Chamber(NSA) Chamber 3m RE 141554 Thermo-Hygrometer CUSTOM CTH-180 1301 1/24/2018 1/31/2019 12 RE 148898 Attenuator KEYSIGHT 8491A MY52462282 10/3/2018 10/31/2019 12 RE 141425 Biconical Antenna Schwarzbeck BBA9106 1302 6/1/2018 6/30/2019 12 RE 141397 Coaxial Cable UL Japan - - 6/13/2018 6/30/2019 12 RE 141545 DIGITAL HiTESTER HIOKI 3805 51201148 1/9/2018 1/31/2019 12 RE 141951 EMI Test Receiver Rohde & Schwarz ESR26 101408 1/30/2018 1/31/2019 12 RE 141267 Logperiodic Schwarzbeck VUSLP9111B 911B-192 6/1/2018 6/30/2019 12 Antenna(200-1000MHz) RE 142227 Measure KOMELON KMC-36 - - - - RE 141583 Pre Amplifier SONOMA 310 260833 2/27/2018 2/28/2019 12 INSTRUMENT RE 142011 AC4_Semi Anechoic TDK Semi Anechoic DA-10005 6/28/2018 6/30/2020 24 Chamber(NSA) Chamber 3m RE 141562 Thermo-Hygrometer CUSTOM CTH-180 1501 1/24/2018 1/31/2019 12 RE 142041 Horn Antenna Oshima Prototype A16-186 1 9/11/2018 9/30/2019 12 Engineering Co. RE 142029 Horn Antenna WiseWave ARH1523-02 10766-01 10/30/2017 10/31/2018 12 UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124

Test report No. : 12104474H-R2 Page : 27 of 29 Issued date : April 9, 2019 FCC ID : 2AON3-RCS05 Test Instruments (2/2) Test LIMS ID Description Manufacturer Model Serial Last Calibration Cal Int item Calibration Due Date Date RE 142055 Power Amplifier SAGE Millimeter, Inc. SBP-5037532015- 11599-01 12/22/2017 12/31/2018 12 1515-N1 RE 142047 Preselected Millimeter AGILENT 11974V-E01 3001A00412 7/13/2018 7/31/2019 12 Mixer RE 142032 Microwave Cable Huber+Suhner SUCOFLEX102 37511/2 9/4/2018 9/30/2019 12 RE 142033 Microwave Cable Huber+Suhner SUCOFLEX102 37512/2 9/4/2018 9/30/2019 12 RE 142031 Horn Antenna WiseWave ARH1023-02 10766-01 10/30/2017 10/31/2018 12 RE 141329 Microwave Cable 1G- Suhner SUCOFLEX102 28635/2 4/11/2018 4/30/2019 12 40GHz RE 142050 Block Downconverter KEYSIGHT PS-X30-W10117A 13715 2/1/2018 2/28/2019 12 RE 142048 Harmonic Mixer AGILENT 11970W 2521 A01909 7/9/2018 7/31/2019 12 RE 142042 High Pass Filter 81- VCSS HPF-10-778030 201 8/22/2018 8/31/2019 12 110GHz RE 142036 Horn Antenna Custom Microwave HO6R - 9/11/2018 9/30/2019 12 Inc. RE 142049 Harmonic Mixer OML INC. M06HWD D100709-1 10/31/2018 10/31/2019 12 RE 142026 Diplexer OML INC. DPL26 - 10/17/2017 10/31/2018 12 RE 142038 Horn Antenna Custom Microwave HO5R - 9/11/2018 9/30/2019 12 Inc. RE 142039 Horn Antenna Custom Microwave HO4R - 9/11/2018 9/30/2019 12 Inc. RE 142053 Harmonic Mixer OML INC. M04HWD Y100709-1 10/31/2018 10/31/2019 12 RE 141962 Digital Oscilloscope Rohde & Schwarz RTO1004 200355 8/30/2018 8/31/2019 12 RE 141440 Temperature and TABAI ESPEC PL-1KP 14019569 4/10/2018 4/29/2019 12 Humidity Chamber RE 141567 Thermo-Hygrometer CUSTOM CTH-201 0008 1/24/2018 1/31/2019 12 RE 142529 Detector HEROTEK, INC. DT1840P 484823 - - - RE 151897 Microwave Cable RINEI SEIKI SF101EA/11PC24/ SN MY1726/1EA 4/19/2018 4/30/2019 12 11PC24/2.5M *Hyphens for Last Calibration Date, Calibration Due Date and Cal Int (month) are instruments that Calibration is not required (e.g. software), or instruments checked in advance before use. The expiration date of the calibration is the end of the expired month. All equipment is calibrated with valid calibrations. Each measurement data is traceable to the national or international standards. [Below 40 GHz] All equipment is calibrated with valid calibrations. Each measurement data is traceable to the national or international standards. [Above 40 GHz] Acceptance criteria for untraceable equipment was formulated according to ISO/IEC 17025 5.6.2.2.2, and the regular inspection was performed based on it annually. For 40 GHz – 110 GHz, power sensor is calibrated by manufacturer, and the measured calibration data is used as in-house reference. The calibration data by manufacturer is checked for acceptance by a calorie meter except for some frequency bands. For above 110 GHz, output level of millimeter wave source module is used as the reference, and inspection by the calorie meter is performed. Electric power is checked with the calorie meter by measuring resistance and voltage of reference resistor. As for some calibrations performed after the tested dates, those test equipment have been controlled by means of an unbroken chains of calibrations. Test Item: RE: Radiated Emission test UL Japan, Inc. Ise EMC Lab. 4383-326 Asama-cho, Ise-shi, Mie-ken 516-0021 JAPAN Telephone : +81 596 24 8999 Facsimile : +81 596 24 8124


Document Created: 2019-04-26 07:38:27
Document Modified: 2019-04-26 07:38:27
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC