Test report part 2

FCC ID: 2AJOTTA-1187

Test Report

Download: PDF
FCCID_4399111

FCC RF Test Report Report No. : FR952702A CSE Plot on Ch 78 between 30MHz ~ 3 GHz CSE Plot on Ch 78 between 2 GHz ~ 25 GHz Sporton International (Kunshan) Inc. Page Number : 54 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 3.8 Radiated Band Edges and Spurious Emission Measurement 3.8.1 Limit of Radiated Band Edges and Spurious Emission In any 100 kHz bandwidth outside the intentional radiator frequency band, all harmonics/spurious must be at least 20 dB below the highest emission level within the authorized band. In addition, radiated emissions which fall in the restricted bands must also comply with the limits as below. Frequency Field Strength Measurement Distance (MHz) (microvolts/meter) (meters) 0.009 – 0.490 2400/F(kHz) 300 0.490 – 1.705 24000/F(kHz) 30 1.705 – 30.0 30 30 30 – 88 100 3 88 – 216 150 3 216 - 960 200 3 Above 960 500 3 3.8.2 Measuring Instruments The measuring equipment is listed in the section 4 of this test report. Sporton International (Kunshan) Inc. Page Number : 55 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 3.8.3 Test Procedures 1. The EUT was placed on a turntable with 0.8 meter for frequency below 1GHz and 1.5 meter for frequency above 1GHz respectively above ground. 2. The EUT was set 3 meters from the interference receiving antenna, which was mounted on the top of a variable height antenna tower. 3. For each suspected emission, the EUT was arranged to its worst case and then tune the Antenna tower (from 1 m to 4 m) and turntable (from 0 degree to 360 degrees) to find the maximum reading. A pre-amp and a high pass filter are used for the test in order to get better signal level to comply with the guidelines. 4. Set to the maximum power setting and enable the EUT transmit continuously. 5. Use the following spectrum analyzer settings: (1) Span shall wide enough to fully capture the emission being measured; (2) Set RBW=100 kHz for f < 1 GHz, RBW=1MHz for f>1GHz ; VBW  RBW; Sweep = auto; Detector function = peak; Trace = max hold for peak (3) For average measurement: use duty cycle correction factor method per 15.35(c). Duty cycle = On time/100 milliseconds On time = N1*L1+N2*L2+...+Nn-1*LNn-1+Nn*Ln Where N1 is number of type 1 pulses, L1 is length of type 1 pulses, etc. Average Emission Level = Peak Emission Level + 20*log(Duty cycle) 6. Corrected Reading: Antenna Factor + Cable Loss + Read Level - Preamp Factor = Level 7. For testing below 1GHz, if the emission level of the EUT in peak mode was 3 dB lower than the limit specified, then peak values of EUT will be reported, otherwise, the emissions will be repeated one by one using the CISPR quasi-peak method and reported. 8. For testing above 1GHz, the emission level of the EUT in peak mode was 20dB lower than average limit (that means the emission level in average mode also complies with the limit in average mode), then peak values of EUT will be reported, otherwise, the emissions will be measured in average mode again and reported. Note: The average levels were calculated from the peak level corrected with duty cycle correction factor (-24.76dB) derived from 20log (dwell time/100ms). This correction is only for signals that hop with the fundamental signal, such as band-edge and harmonic. Other spurious signals that are independent of the hopping signal would not use this correction. Sporton International (Kunshan) Inc. Page Number : 56 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 3.8.4 Test Setup For radiated emissions below 30MHz For radiated emissions from 30MHz to 1GHz For radiated emissions above 1GHz Sporton International (Kunshan) Inc. Page Number : 57 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 3.8.5 Test Results of Radiated Spurious Emissions (9 kHz ~ 30 MHz) The low frequency, which started from 9 kHz to 30MHz, was pre-scanned and the result which was 20dB lower than the limit line was not reported. There is a comparison data of both open-field test site and semi-Anechoic chamber, and the result came out very similar. 3.8.6 Test Result of Radiated Spurious at Band Edges Please refer to Appendix B. 3.8.7 Test Result of Radiated Spurious Emission (30MHz ~ 10th Harmonic) Please refer to Appendix B. 3.8.8 Duty cycle correction factor for average measurement Please refer to Appendix C. Sporton International (Kunshan) Inc. Page Number : 58 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 3.9 AC Conducted Emission Measurement 3.9.1 Limit of AC Conducted Emission For equipment that is designed to be connected to the public utility (AC) power line, the radio frequency voltage that is conducted back onto the AC power line on any frequency or frequencies within the band 150 kHz to 30 MHz shall not exceed the limits in the following table. Conducted limit (dBμV) Frequency of emission (MHz) Quasi-peak Average 0.15-0.5 66 to 56* 56 to 46* 0.5-5 56 46 5-30 60 50 *Decreases with the logarithm of the frequency. 3.9.2 Measuring Instruments The measuring equipment is listed in the section 4 of this test report. 3.9.3 Test Procedures 1. The EUT was placed 0.4 meter from the conducting wall of the shielding room was kept at least 80 centimeters from any other grounded conducting surface. 2. Connect EUT to the power mains through a line impedance stabilization network (LISN). 3. All the support units are connecting to the other LISN. 4. The LISN provides 50 ohm coupling impedance for the measuring instrument. 5. The FCC states that a 50 ohm, 50 microhenry LISN should be used. 6. Both sides of AC line were checked for maximum conducted interference. 7. The frequency range from 150 kHz to 30 MHz was searched. 8. Set the test-receiver system to Peak Detect Function and specified bandwidth (IF Bandwidth = 9kHz) with Maximum Hold Mode. Then measurement is also conducted by Average Detector and Quasi-Peak Detector Function respectively. Sporton International (Kunshan) Inc. Page Number : 59 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 3.9.4 Test Setup 3.9.5 Test Result of AC Conducted Emission Please refer to Appendix A. Sporton International (Kunshan) Inc. Page Number : 60 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 3.10 Antenna Requirements 3.10.1 Standard Applicable If directional gain of transmitting antennas is greater than 6dBi, the power shall be reduced by the same level in dB comparing to gain minus 6dBi. The use of a permanently attached antenna or of an antenna that uses a unique coupling to the intentional radiator shall be considered sufficient to comply with the rule. 3.10.2 Antenna Anti-Replacement Construction An embedded-in antenna design is used. 3.10.3 Antenna Gain The antenna peak gain of EUT is less than 6 dBi. Therefore, it is not necessary to reduce maximum peak output power limit. Sporton International (Kunshan) Inc. Page Number : 61 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 4 List of Measuring Equipment Calibration Instrument Manufacturer Model No. Serial No. Characteristics Test Date Due Date Remark Date Jun. 07, 2019~ Conducted Spectrum Analyzer R&S FSV40 101040 10Hz~40GHz Aug. 07, 2018 Aug. 06, 2019 Jun. 18, 2019 (TH01-KS) Jun. 07, 2019~ Conducted Power Senor Anritsu MA2411B 0917070 300MHz~40GHz Jan. 14, 2019 Jan. 13, 2020 Jun. 18, 2019 (TH01-KS) Jun. 07, 2019~ Conducted Power Meter Anritsu ML2495A 1005002 50MHz Bandwidth Jan. 14, 2019 Jun. 18, 2019 Jan. 13, 2020 (TH01-KS) MY564000 3Hz~8.5GHz;Max Radiation EMI Test Receiver Keysight N9038A Oct. 12, 2018 Jun. 18, 2019 Oct. 11, 2019 23 30dBm (03CH06-KS) EXA Spectrum MY574710 Radiation Keysight N9010B 10Hz-44GHz Jun. 25, 2018 Jun. 18, 2019 Jun. 24, 2019 Analyzer 84 (03CH06-KS) Radiation Loop Antenna R&S HFH2-Z2 100321 9kHz~30MHz Oct. 19, 2018 Jun. 18, 2019 Oct. 18, 2019 (03CH06-KS) Radiation Bilog Antenna TeseQ CBL6111D 44483 30MHz-1GHz Dec. 28, 2018 Jun. 18, 2019 Dec. 27, 2019 (03CH06-KS) Double Ridge Horn Radiation ETS-Lindgren 3117 75957 1GHz~18GHz Oct. 20, 2018 Jun. 18, 2019 Oct. 19, 2019 Antenna (03CH06-KS) Radiation SHF-EHF Horn Com-power AH-840 101070 18GHz~40GHz Jan. 05, 2019 Jun. 18, 2019 Jan. 04, 2020 (03CH06-KS) Radiation Amplifier SONOMA 310N 187289 9KHz ~1GHZ Aug. 06, 2018 Jun. 18, 2019 Aug. 05, 2019 (03CH06-KS) Radiation Amplifier MITEQ TTA1840-35-HG 2014749 18~40GHz Jan. 14, 2019 Jun. 18, 2019 Jan. 13, 2020 (03CH06-KS) AMF-7D-001018 Radiation high gain Amplifier MITEQ 2025788 1Ghz-18Ghz Apr. 17, 2019 Jun. 18, 2019 Apr. 16, 2020 00-30-10P (03CH06-KS) MY532702 Radiation Amplifier Keysight 83017A 500MHz~26.5GHz Apr. 15, 2019 Jun. 18, 2019 Apr. 14, 2020 03 (03CH06-KS) F1040900 Radiation AC Power Source Chroma 61601 N/A NCR Jun. 18, 2019 NCR 04 (03CH06-KS) Radiation Turn Table ChamPro EM 1000-T 060762-T 0~360 degree NCR Jun. 18, 2019 NCR (03CH06-KS) Radiation Antenna Mast ChamPro EM 1000-A 060762-A 1 m~4 m NCR Jun. 18, 2019 NCR (03CH06-KS) Conduction EMI Receiver R&S ESCI7 100768 9kHz~7GHz; Apr. 16, 2019 Jun. 19, 2019 Apr. 15, 2020 (CO01-KS) Conduction AC LISN MessTec AN3016 060103 9kHz~30MHz Oct. 12, 2018 Jun. 19, 2019 Oct. 11, 2019 (CO01-KS) AC LISN Conduction (for auxiliary MessTec AN3016 060105 9kHz~30MHz Nov. 19, 2018 Jun. 19, 2019 Nov. 18, 2019 (CO01-KS) equipment) ABP00000 AC 0V~300V, Conduction AC Power Source Chroma 61602 Oct. 12, 2018 Jun. 19, 2019 Oct. 11, 2019 0811 45Hz~1000Hz (CO01-KS) NCR: No Calibration Required Sporton International (Kunshan) Inc. Page Number : 62 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A 5 Uncertainty of Evaluation The measurement uncertainties shown below were calculated in accordance with the requirements of ANSI 63.10-2013. All the measurement uncertainty value were shown with a coverage K=2 to indicate 95% level of confidence. The measurement data show herein meets or exceeds the CISPR measurement uncertainty values specified in CISPR 16-4-2 and can be compared directly to specified limit to determine compliance. Uncertainty of Conducted Emission Measurement (150 kHz ~ 30 MHz) Measuring Uncertainty for a Level of Confidence 2.9dB of 95% (U = 2Uc(y)) Uncertainty of Radiated Emission Measurement (30 MHz ~ 1000 MHz) Measuring Uncertainty for a Level of Confidence 5.0dB of 95% (U = 2Uc(y)) Uncertainty of Radiated Emission Measurement (1000 MHz ~ 18000 MHz) Measuring Uncertainty for a Level of Confidence 5.0dB of 95% (U = 2Uc(y)) Uncertainty of Radiated Emission Measurement (18000 MHz ~ 40000 MHz) Measuring Uncertainty for a Level of Confidence 5.0dB of 95% (U = 2Uc(y)) Sporton International (Kunshan) Inc. Page Number : 63 of 63 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187 Report Template No.: BU5-FR15CBT Version 2.0

FCC RF Test Report Report No. : FR952702A Appendix A. AC Conducted Emission Test Results Temperature : 25.3~26.2℃ Test Engineer : Amos Zhang Relative Humidity : 38~40% Test Voltage : 120Vac / 60Hz Phase : Line Sporton International (Kunshan) Inc. Page Number : A1 of A2 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187

FCC RF Test Report Report No. : FR952702A Temperature : 25.3~26.2℃ Test Engineer : Amos Zhang Relative Humidity : 38~40% Test Voltage : 120Vac / 60Hz Phase : Neutral Sporton International (Kunshan) Inc. Page Number : A2 of A2 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187

FCC RF Test Report Report No. : FR952702A Appendix B. Radiated Spurious Emission 2.4GHz 2400~2483.5MHz BT (Band Edge @ 3m) BT Note Frequency Level Over Limit Read Antenna Cable Preamp Ant Table Peak Pol. Limit Line Level Factor Loss Factor Pos Pos Avg. ( MHz ) ( dBμV/m ) ( dB ) ( dBμV/m ) ( dBμV ) ( dB/m ) ( dB ) ( dB ) ( cm ) ( deg ) (P/A) (H/V) 2364.86 53.54 -20.46 74 47.53 32.07 5.36 31.42 389 93 P H 2364.86 28.78 -25.22 54 - - - - - - A H * 2402 99.74 - - 93.74 32 5.41 31.41 389 93 P H BT * 2402 74.98 - - - - - - - - A H CH00 2336.39 53.22 -20.78 74 47.25 32.1 5.31 31.44 400 48 P V 2402MHz 2336.39 28.46 -25.54 54 - - - - - - A V * 2402 100.11 - - 94.11 32 5.41 31.41 400 48 P V * 2402 75.35 - - - - - - - - A V 2483.55 58.36 -15.64 74 52.03 32.27 5.45 31.39 100 107 P H 2483.55 33.6 -20.4 54 - - - - - - A H * 2480 103.96 - - 97.63 32.27 5.45 31.39 100 107 P H BT * 2480 79.2 - - - - - - - - A H CH 78 2483.55 57.33 -16.67 74 51 32.27 5.45 31.39 372 51 P V 2480MHz 2483.55 32.57 -21.43 54 - - - - - - A V * 2480 103.89 - - 97.56 32.27 5.45 31.39 372 51 P V * 2480 79.13 - - - - - - - - A V 1. No other spurious found. Remark 2. All results are PASS against Peak and Average limit line. Sporton International (Kunshan) Inc. Page Number : B1 of B5 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187

FCC RF Test Report Report No. : FR952702A 2.4GHz 2400~2483.5MHz BT (Harmonic @ 3m) BT Note Frequency Level Over Limit Read Antenna Cable Preamp Ant Table Peak Pol. Limit Line Level Factor Loss Factor Pos Pos Avg. ( MHz ) ( dBμV/m ) ( dB ) ( dBμV/m ) ( dBμV ) ( dB/m ) ( dB ) ( dB ) ( cm ) ( deg ) (P/A) (H/V) BT 4806 37.47 -36.53 74 56.91 34.2 7.95 61.59 100 360 P H CH 00 2402MHz 4806 39.19 -34.81 74 58.63 34.2 7.95 61.59 100 360 P V 4884 38.32 -35.68 74 57.78 34.13 8.02 61.61 100 187 P H BT 7320 39.98 -34.02 74 55.87 36.6 9.85 62.34 100 187 P H CH 39 4884 39.74 -34.26 74 59.2 34.13 8.02 61.61 100 360 P V 2441MHz 7320 39.97 -34.03 74 55.86 36.6 9.85 62.34 100 360 P V 4962 37.65 -36.35 74 57.09 34.1 8.1 61.64 100 360 P H BT 7440 37.17 -36.83 74 53.17 36.4 10 62.4 100 360 P H CH 78 4962 37.99 -36.01 74 57.43 34.1 8.1 61.64 100 360 P V 2480MHz 7440 39.07 -34.93 74 55.07 36.4 10 62.4 100 360 P V 1. No other spurious found. Remark 2. All results are PASS against Peak and Average limit line. Sporton International (Kunshan) Inc. Page Number : B2 of B5 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187

FCC RF Test Report Report No. : FR952702A Emission below 1GHz 2.4GHz BT (LF) BT Note Frequency Level Over Limit Read Antenna Cable Preamp Ant Table Peak Pol. Limit Line Level Factor Loss Factor Pos Pos Avg. ( MHz ) ( dBμV/m ) ( dB ) ( dBμV/m ) (dBμV) ( dB/m ) ( dB ) ( dB ) ( cm ) ( deg ) (P/A) (H/V) 105.66 16.06 -27.44 43.5 30.67 17.27 1.04 32.92 - - P H 188.11 23.01 -20.49 43.5 39.06 15.42 1.45 32.92 - - P H 278.32 20.04 -25.96 46 32.27 18.99 1.79 33.01 - - P H 390.84 18.74 -27.26 46 28.28 21.48 2.09 33.11 - - P H 580.96 23.13 -22.87 46 29.51 24.39 2.56 33.33 - - P H 2.4GHz 883.6 25.81 -20.19 46 28.6 26.43 3.19 32.41 100 360 P H BT 47.46 35.55 -4.45 40 52.74 15.1 0.67 32.96 100 0 P V LF 106.63 18.16 -25.34 43.5 32.71 17.33 1.05 32.93 - - P V 210.42 21.67 -21.83 43.5 37.58 15.44 1.58 32.93 - - P V 430.61 20.47 -25.53 46 29.22 22.25 2.19 33.19 - - P V 639.16 22.9 -23.1 46 28.78 24.72 2.71 33.31 - - P V 949.56 28.22 -17.78 46 29.58 27 3.35 31.71 - - P V 1. No other spurious found. Remark 2. All results are PASS against limit line. Sporton International (Kunshan) Inc. Page Number : B3 of B5 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187

FCC RF Test Report Report No. : FR952702A Note symbol Fundamental Frequency which can be ignored. However, the level of any unwanted emissions * shall not exceed the level of the fundamental frequency. ! Test result is over limit line. P/A Peak or Average H/V Horizontal or Vertical Sporton International (Kunshan) Inc. Page Number : B4 of B5 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187

FCC RF Test Report Report No. : FR952702A A calculation example for radiated spurious emission is shown as below: WIFI Note Frequency Level Over Limit Read Antenna Cable Preamp Ant Table Peak Pol. Ant. Limit Line Level Factor Loss Factor Pos Pos Avg. 1+2 ( MHz ) ( dBμV/m ) ( dB ) ( dBμV/m ) ( dBμV ) ( dB/m ) ( dB ) ( dB ) ( cm ) ( deg ) (P/A) (H/V) 802.11b 2390 55.45 -18.55 74 54.51 32.22 4.58 35.86 103 308 P H CH 01 2412MHz 2390 43.54 -10.46 54 42.6 32.22 4.58 35.86 103 308 A H 1. Level(dBμV/m) = Antenna Factor(dB/m) + Cable Loss(dB) + Read Level(dBμV) - Preamp Factor(dB) 2. Over Limit(dB) = Level(dBμV/m) – Limit Line(dBμV/m) For Peak Limit @ 2390MHz: 1. Level(dBμV/m) = Antenna Factor(dB/m) + Cable Loss(dB) + Read Level(dBμV) - Preamp Factor(dB) = 32.22(dB/m) + 4.58(dB) + 54.51(dBμV) – 35.86 (dB) = 55.45 (dBμV/m) 2. Over Limit(dB) = Level(dBμV/m) – Limit Line(dBμV/m) = 55.45(dBμV/m) – 74(dBμV/m) = -18.55(dB) For Average Limit @ 2390MHz: 1. Level(dBμV/m) = Antenna Factor(dB/m) + Cable Loss(dB) + Read Level(dBμV) - Preamp Factor(dB) = 32.22(dB/m) + 4.58(dB) + 42.6(dBμV) – 35.86 (dB) = 43.54 (dBμV/m) 2. Over Limit(dB) = Level(dBμV/m) – Limit Line(dBμV/m) = 43.54(dBμV/m) – 54(dBμV/m) = -10.46(dB) Both peak and average measured complies with the limit line, so test result is “PASS”. Sporton International (Kunshan) Inc. Page Number : B5 of B5 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187

FCC RF Test Report Report No. : FR952702A Appendix C. Duty Cycle Plots DH5 on time (One Pulse) Plot on Channel 39 DH5 on time (Count Pulses) Plot on Channel 39 Note: 1. Worst case Duty cycle = on time/100 milliseconds = 2 * 2.89 / 100 = 5.78 % 2. Worst case Duty cycle correction factor = 20*log(Duty cycle) = -24.76 dB 3. DH5 has the highest duty cycle worst case and is reported. Sporton International (Kunshan) Inc. Page Number : C1 of C1 TEL : +86-512-57900158 Report Issued Date : Aug. 05, 2019 FAX : +86-512-57900958 Report Version : Rev. 01 FCC ID: 2AJOTTA-1187


Document Created: 2019-08-08 17:20:48
Document Modified: 2019-08-08 17:20:48
© 2024 FCC.report
This site is not affiliated with or endorsed by the FCC